Advantech PCE-7214 Installation and operation manual

PCE-7214 Startup Manual 1
Before you begin installing your card, please make sure that
the following items have been shipped:
1 PCE-7214 Dual Intel®Xeon®/ LV Xeon®processor-
based single board computer
1 PCE-7214 Startup Manual
1 CD with driver utility and manual (in PDF format)
1 FDD cable P/N: 1700340640
2 Ultra ATA 66/100 HDD cables P/N: 1701400452
2 Serial ATA HDD data cable P/N: 1700003194
2 Serial ATA HDD power cable P/N: 1703150102
1 Printer & COM port cable kit P/N: 1701260305
1 Dual USB cable kit P/N: 1700008461
1 Y cable for PS/2 KB & MS P/N: 1700060202
1 Jumper Pack P/N: 9689000068
1 User note for full-sized CPU card
1 Warranty card
Necessary Accessory (not included in the package)
Xeon CPU Cooler for 110W TDP
CPU (CPU Cooler Option 1) P/N: 1750000282
Low Profile Xeon CPU Cooler for
55W TDP CPU (CPU Cooler Option 2) P/N: 1750001660
Note: Purchasing PCE-7214’s proprietary CPU
cooler(s) from Advantech is a must. Other
brands of CPU coolers are NOT compatible with
PCE-7214.
If any of these items are missing or damaged, please con-
tact your distributor or sales representative immediately.
Note1: For detailed contents of PCE-7214, please refer
to information on the enclosed CD-ROM (in PDF
format).
Note2: Acrobat Reader is required to view any PDF file.
Standard SBC functions
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
PCE-7214 Dual Socket 771 Intel®Quad / Dual-Core Xeon®
Processor Card with PCIe / VGA / Dual GbE / FSB 1333 MHz
Startup Manual
CPU: Dual LGA771 socket Intel®Quad-Core / Dual-Core
Xeon®/ LV Xeon®processors with FSB 1333 MHz
BIOS: AMI Flash BIOS (32 Mbit SPI Flash Memory)
Chipset: Intel®E5100 MCH plus ICH7R I/O Hub
System memory: Up to 32 GB in four 240-pin DIMM
sockets. Supports Dual-channel DDR2 533/667 MHz ECC
Registered DIMMs
SATA/EIDE hard disk drive interface: Supports up to
6 independent Serial ATA hard drives (up to 300 MB/s)
with software RAID 0, 1, 5, 10 as well as one IDE port
(maximum 2 devices).
FDD interface: Supports up to two FDDs
Serial ports: Two serial RS-232 ports
Parallel port: One parallel port, supports SPP/EPP/ECP
mode
Keyboard/mouse connector: Supports one standard
PS/2 keyboard and mouse
Watchdog timer: 255 level timer intervals
USB (2.0): 12 USB 2.0 ports, 8 ports on the CPU card, 4
ports on the backplane.
VGA Interface
Chipset: XGI Volari Z11
Interface: PCIe x 1
Display memory: 64 MB frame buffer memory on chip
Video Output: 1600 x 1200 at 70 Hz VGA output; 15 pin
D-Sub connector x 1
Ethernet Interface
Chipset:
Dual 10/100/1000 Mbps: LAN 1: Intel 82566DM; LAN 2:
Intel 82573V
Connection: Onboard RJ-45 connector x 2
Mechanical and Environmental
Dimensions (L x W): 338 x 122 mm
Power supply voltage: +5 V, + 12 V, 3.3 V, +5 VSBY
Power consumption:
CPU: Two Intel® Xeon® 2.0 GHz / 4M/ 1333 MHz FSB /
65W TDP
MEMORY: Four DDR2 2GB
Test program: Intel Max power 100% + BurnIn test 4.0
+12 V: 9.7 A
+5 V: 7.4 A
+3.3 V: 2.5 A
+5 VSB: 0.71 A
-12 V: 0 A
-5 V: 0 A
Operating temperature: 0 ~ 60° C (depending on CPU)
Weight: 0.5 kg (weight of board)
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
Specications Packing List
For more information on this and other Advantech
products, please visit our website at:
http://www.advantech.com
http://www.advantech.com/eplatform
For technical support and service, please visit our
support website at:
http://www.advantech.com/support
This manual is for the PCE-7214 series Rev. A1
Part No. 2002721411
Printed in Taiwan
2nd Edition
May 2009

2 PCE-7214 Startup Manual
Connectors and Jumpers
The board has a number of connectors and jumpers that
allow you to configure your system to suit your application.
The table below lists the function of each of the connectors
and jumpers.
Connectors
Label Function
IDE1 Primary IDE connector
FDD1 Floppy drive connector
LPT1 Parallel port
VGA1 VGA connector
COM1 Serial port: COM1 (9-pin connector)
COM2 Serial port: COM2 (9-pin connector)
KBMS1 PS/2 keyboard and mouse connector
KBMS2 External keyboard/mouse pin header
JIR1 Infrared port pin header
CPUFAN1 CPU1 FAN connector
CPUFAN2 CPU2 FAN connector
JFP1 Power and Reset Button connector
JFP2 HDD LED / SNMP(SM bus) / Speaker
connector
JFP3 Power LED and keyboard lock connector
JOBS1
HW Monitor Alarm
Close: Enable OBS Alarm
Open: Disable OBS Alarm
LAN12 Dual Giga LAN RJ45 connector with
Transformer
HDAUD1 High Denition audio interface connector
SATA1 Serial ATA1
SATA2 Serial ATA2
SATA3 Serial ATA3
SATA4 Serial ATA4
SATA5 Serial ATA5
SATA6 Serial ATA6
USB12 Two USB port pin headers
USB34 Two USB port pin headers
USB56 Two USB port pin headers
USB78 Two USB port pin headers
LANLED1 LAN1 and LAN2 LED connector
GPIO1 GPIO header
Jumpers
Label Function
CMOS1 CMOS clear
JWDT1 Watchdog timer output selection
CMOS1: CMOS clear function
Closed Pins Result
1-2 Keep CMOS data *
2-3 Clear CMOS
JWDT1: Watchdog timer output option
Closed Pins Result
1-2 Reserved
2-3 System reset *
Software Installation
The CD disc contains a driver installer program that will lead
you through the installation of various device drivers needed
to take full advantage of your CPU card.
The computer is provided with a battery-powered real-time
clock circuit. There is a danger of explosion if battery is
incorrectly replaced. Replace only with same or equivalent
type recommended by the manufacturer. Discard used bat-
teries according to manufacturer’s instructions
Safety Information
This device complies with the requirements in Part 15 of
the FCC rules. Operation is subject to the following two
conditions.
This device may not cause harmful interference.
This device must accept any interference received,
including interference that may cause undesired opera-
tion.
1.
2.
Caution
1 2 3
* default setting
12 3
* default setting

PCE-7214 Startup Manual 3
Board Layout
The locations of all connectors and jumpers:
Board Layout: Jumper and Connector Location
COM2
IDE1
FDD1
LPT1
VGA1
COM1
KBMS1
KBMS2
CPUFAN2 CPUFAN1
JOBS1
JWDT1
JIR1
1 2 3 4
5 6
SATA 1~4
LANLED1
LAN12
GPIO1
CPU1
CPU2
DIMMA1 DIMMB1
DIMMA2 DIMMB2
Page Connectors
HDAUD1
USB56 USB78 USB12 USB34
SATA 5~6
Note: Purchasing PCE-7214’s proprietary CPU
cooler(s) from Advantech is a must. Other
brands of CPU coolers are NOT compatible
with PCE-7214.

Mouser Electronics
Authorized Distributor
Click to View Pricing, Inventory, Delivery & Lifecycle Information:
Advantech:
1750001660