Aeroflex IFR 6000 Installation manual

Test Set
Operation Manual
1002-580 0-2P0
IFR 6000
ADS-B/TIS/TIS-B
XPDR/DME/TCAS
Issue 6
EXPORT CONTROL WARNING: This document contains controlled technology
or technical data under the jurisdiction of the Export Administration
Regulations (EAR), 15 CFR 730-774. It cannot be transferred to any foreign
third party without the specific prior approval of the U.S. Department of
Commerce Bureau of Industry and Security (BIS). Violations of these
regulations are punishable by fine, imprisonment, or both.

Subject to Export Control, see Cover Page for details.
OPERATION MANUAL
XPDR/DME/TCAS/ADS-B/TIS/TIS-B
TEST SET
IFR 6000
PUBLISHED BY
Aeroflex
COPYRIGHT ©Aeroflex 2007
All rights reserved. No part of this publication may be reproduced, stored in a retrieval system, or
transmitted in any form or by any means, electronic, mechanical, photocopying, recording or
otherwise without the prior permission of the publisher.
Original Printing Mar 2005
Issue 2 Sep 2005
Issue 3 Nov 2005
Issue 4 Jan 2006
Issue 5 Aug 2007
Issue 6 Dec 2007
10200 West York / Wichita, Kansas 67215 U.S.A. / [phone] / FAX [phone]

OPERATION MANUAL
IFR 6000
Subject to Export Control, see Cover Page for details.
THIS PAGE INTENTIONALLY LEFT BLANK.

OPERATION MANUAL
IFR 6000
Subject to Export Control, see Cover Page for details.
Cable Statement:
For continued EMC compliance, all external cables must be double shielded.
For continued EMC compliance, all external cables must be 3 meters or less in length.
Nomenclature Statement:
In this manual Test Set or Unit refers to the IFR 6000 XPDR/DME/TCAS/ADS-B/TIS/TIS-B Test Set.

OPERATION MANUAL
IFR 6000
Subject to Export Control, see Cover Page for details.
THIS PAGE INTENTIONALLY LEFT BLANK.

OPERATION MANUAL
IFR 6000
Subject to Export Control, see Cover Page for details.
SAFETY FIRST: TO ALL OPERATIONS PERSONNEL
REFER ALL SERVICING OF UNIT TO QUALIFIED TECHNICAL PERSONNEL. THIS UNIT CONTAINS NO
OPERATOR SERVICEABLE PARTS.
WARNING: USING THIS EQUIPMENT IN A MANNER NOT SPECIFIED BY THE ACCOMPANYING
DOCUMENTATION MAY IMPAIR THE SAFETY PROTECTION PROVIDED BY THE EQUIPMENT.
CASE, COVER OR PANEL REMOVAL
Opening the Case Assembly exposes the operator to electrical hazards that can result in electrical shock or
equipment damage. Do not operate this Test Set with the Case Assembly open.
SAFETY IDENTIFICATION IN TECHNICAL MANUAL
This manual uses the following terms to draw attention to possible safety hazards, that may exist when
operating or servicing this equipment.
CAUTION: THIS TERM IDENTIFIES CONDITIONS OR ACTIVITIES THAT, IF IGNORED, CAN RESULT IN
EQUIPMENT OR PROPERTY DAMAGE (E.G., FIRE).
WARNING: THIS TERM IDENTIFIES CONDITIONS OR ACTIVITIES THAT, IF IGNORED, CAN RESULT IN
PERSONAL INJURY OR DEATH.
SAFETY SYMBOLS IN MANUALS AND ON UNITS
CAUTION: Refer to accompanying documents. (This symbol refers to
specific CAUTIONS represented on the unit and clarified in the text.)
AC OR DC TERMINAL: Terminal that may supply or be supplied with AC or
DC voltage.
DC TERMINAL: Terminal that may supply or be supplied with DC voltage.
AC TERMINAL: Terminal that may supply or be supplied with AC or
alternating voltage.
EQUIPMENT GROUNDING PRECAUTION
Improper grounding of equipment can result in electrical shock.
USE OF PROBES
Check the specifications for the maximum voltage, current and power ratings of any connector on the Test
Set before connecting it with a probe from a terminal device. Be sure the terminal device performs within
these specifications before using it for measurement, to prevent electrical shock or damage to the
equipment.
POWER CORDS
Power cords must not be frayed, broken nor expose bare wiring when operating this equipment.
USE RECOMMENDED FUSES ONLY
Use only fuses specifically recommended for the equipment at the specified current and voltage ratings.
INTERNAL BATTERY
This unit contains a Lithium Ion Battery, serviceable only by a qualified technician.
CAUTION: SIGNAL GENERATORS CAN BE A SOURCE OF ELECTROMAGNETIC INTERFERENCE (EMI) TO
COMMUNICATION RECEIVERS. SOME TRANSMITTED SIGNALS CAN CAUSE DISRUPTION
AND INTERFERENCE TO COMMUNICATION SERVICES OUT TO A DISTANCE OF SEVERAL
MILES. USERS OF THIS EQUIPMENT SHOULD SCRUTINIZE ANY OPERATION THAT RESULTS
IN RADIATION OF A SIGNAL (DIRECTLY OR INDIRECTLY) AND SHOULD TAKE NECESSARY
PRECAUTIONS TO AVOID POTENTIAL COMMUNICATION INTERFERENCE PROBLEMS.

OPERATION MANUAL
IFR 6000
Subject to Export Control, see Cover Page for details.
THIS PAGE INTENTIONALLY LEFT BLANK.

OPERATION MANUAL
IFR 6000
Subject to Export Control, see Cover Page for details.
DECLARATION OF CONFORMITY
The Declaration of Conformity Certificate included with
the Unit should remain with the Unit.
Aeroflex recommends the operator reproduce a copy of
the Declaration of Conformity Certificate to be stored
with the Operation Manual for future reference.

OPERATION MANUAL
IFR 6000
Subject to Export Control, see Cover Page for details.
THIS PAGE INTENTIONALLY LEFT BLANK.

OPERATION MANUAL
IFR 6000
TABLE OF CONTENTS
Subject to Export Control, see Cover Page for details. Page 1
Dec 1/07
TABLE OF CONTENTS
Title Chapter/Section
Title Page / Copyright Page
Statements
Safety Page
Declaration of Conformity
Table of Contents
Introduction
Service Upon Receipt of Material
Chapter 1
Section 1 - Description and Quick Start 1-1
Section 2 - Operation 1-2
Section 3 - Specifications 1-3
Section 4 - Shipping 1-4
Section 5 - Storage 1-5
Appendix A - Connector Pin-Out Tables
Appendix B - Metric/British Imperial Conversion Table with Nautical Distance Conversions
Appendix C - Factory/Power Up Presets
Appendix D - Abbreviations
Appendix E - Breakout Box
Appendix F - Transponder Configurations
Appendix G - Mode S Address Blocks (Product Specific List)
Appendix H - Mode S Address Blocks (Complete List)
Appendix I - Signal Formats
Appendix J - Standard Accessories
Appendix K - Target Acquisition Time Probability Table
Index
Battery/Fuse Instructions

OPERATION MANUAL
IFR 6000
TABLE OF CONTENTS
Subject to Export Control, see Cover Page for details. Page 2
Dec 1/07
THIS PAGE INTENTIONALLY LEFT BLANK.

OPERATION MANUAL
IFR 6000
INTRODUCTION
Subject to Export Control, see Cover Page for details. Page 1
Dec 1/07
INTRODUCTION
This manual contains operating instructions for the IFR 6000. It is strongly recommended that
personnel be thoroughly familiar with the contents of this manual before attempting to operate this
equipment.
Refer all servicing of unit to qualified technical personnel.
ORGANIZATION
This manual is divided into the following Chapters and Sections:
CHAPTER 1 - OPERATION
Section 1 - DESCRIPTION and Quick Start (for operators familiar with avionics systems)
Section 2 - OPERATION (installation, description of controls, connectors and indicators,
performance evaluation and operating procedures)
Section 3 - SPECIFICATIONS
Section 4 - SHIPPING
Section 5 - STORAGE

OPERATION MANUAL
IFR 6000
INTRODUCTION
Subject to Export Control, see Cover Page for details. Page 2
Dec 1/07
THIS PAGE INTENTIONALLY LEFT BLANK.

OPERATION MANUAL
IFR 6000
1-TABLE OF CONTENTS
Subject to Export Control, see Cover Page for details. Page 1
Dec 1/07
CHAPTER ONE
IFR 6000 XPDR/DME/TCAS/ADS-B/TIS/TIS-B TEST SET
OPERATION MANUAL
TABLE OF CONTENTS
Title Chapter/Section/Subject Page
SECTION 1 - DESCRIPTION 1-1
1. General Description and Capabilities 1-1-1 1
1.1 Description 1-1-1 1
1.2 Functional Capabilities 1-1-1 1
1.3 Regulatory Responsibilities 1-1-1 2
2. Quick Start 1-1-2 1
2.1 Controls 1-1-2 1
2.2 General Setup 1-1-2 2
2.3 XPDR Setup Over the Air 1-1-2 2
2.4 XPDR Setup Direct Connect 1-1-2 4
2.5 XPDR Testing 1-1-2 5
2.5.1 ADS-B/GICB Testing 1-1-2 6
2.5.1.1 ADS-B MON 1-1-2 6
2.5.1.2 ADS-B GEN 1-1-2 7
2.5.1.2 GICB 1-1-2 8
2.6 DME Setup Antenna 1-1-2 8
2.7 DME Setup Direct Connect 1-1-2 9
2.8 DME Testing 1-1-2 9
2.9 TCAS Setup Antenna 1-1-2 10
2.10 TCAS Testing 1-1-2 11
2.11 TIS Setup Antenna 1-1-2 12
2.12 TIS Setup Direct Connect 1-1-2 13
2.13 TIS Testing 1-1-2 13
SECTION 2 - OPERATION 1-2
1. Installation 1-2-1 1
1.1 General 1-2-1 1
1.2 Battery Operation 1-2-1 1
1.3 Battery Charging 1-2-1 1
1.4 Safety Precautions 1-2-1 1
1.4.1 Complying with Instructions 1-2-1 1
1.4.2 Grounding Power Cord 1-2-1 1
1.4.3 Operating Safety 1-2-1 1
1.5 AC Power Requirements 1-2-1 2
1.6 Battery Recharging 1-2-1 2
1.7 External Cleaning 1-2-1 3
2. Controls, Connectors and Indicators 1-2-2 1
3. Performance Evaluation 1-2-3 1
3.1 General 1-2-3 1
3.2 Self Test 1-2-3 1
4. Operating Procedures 1-2-4 1
4.1 General 1-2-4 1
4.2 Start-Up 1-2-4 2

OPERATION MANUAL
IFR 6000
1-TABLE OF CONTENTS
Subject to Export Control, see Cover Page for details. Page 2
Dec 1/07
TABLE OF CONTENTS (cont)
Title Chapter/Section/Subject Page
SECTION 2 – OPERATION (cont) 1-2
4.3 XPDR (Transponder) 1-2-4 2
4.3.1 Configurations 1-2-4 2
4.3.2 Setup 1-2-4 3
4.3.3 Auto Test 1-2-4 8
4.3.4 Test List 1-2-4 10
4.3.5 Altitude Encoder 1-2-4 28
4.3.6 Direct Connect Procedure 1-2-4 29
4.3.7 “Over the Air” Ground Test 1-2-4 29
4.3.8 “Over the Air” Simulated Altitude Test 1-2-4 30
4.4 DME 1-2-4 30
4.4.1 Setup 1-2-4 32
4.5 TCAS Mode 1-2-4 35
4.5.1 TCAS Operation Concept 1-2-4 35
4.5.2 TCAS Testing 1-2-4 38
4.5.3 TCAS Setup 1-2-4 38
4.5.4 TCAS Screen 1-2-4 42
4.5.5 Setup-Scenario Data Screen 1-2-4 45
4.5.6 Monitor Screens 1-2-4 47
4.5.6.1 Surveillance Monitor 1-2-4 47
4.5.6.2 Broadcast Monitor 1-2-4 49
4.5.6.3 ATCRBS 1-2-4 51
4.5.7 Recommended Test Procedure 1-2-4 54
4.6 ADS-B General 1-2-4 56
4.6.1 ADS-B/GICB Modes 1-2-4 56
4.6.2 Setup ADS-B 1-2-4 56
4.6.3 ADS-B/GICB MAIN 1-2-4 58
4.6.4 ADS-B MON 1-2-4 58
4.6.5 ADS-B GEN 1-2-4 68
4.6.6 GICB General 1-2-4 76
4.6.7 GICB Mode 1-2-4 76
4.7 TIS General 1-2-4 97
4.7.1 TIS Mode 1-2-4 97
4.7.2 TIS Setup 1-2-4 97
4.8 Directional Antenna 1-2-4 101
4.9 Breakout Box 1-2-4 105
SECTION 3 - SPECIFICATIONS 1-3
SECTION 4 - SHIPPING 1-4
1. Shipping Test Sets 1-4-1 1
1.1 Information 1-4-1 1
1.2 Repacking Procedure 1-4-1 1
SECTION 5 - STORAGE 1-5

OPERATION MANUAL
IFR 6000
1-LIST OF TABLES
Subject to Export Control, see Cover Page for details. Page 1
Dec 1/07
LIST OF ILLUSTRATIONS
Title Chapter/Section/Subject Page
Controls 1-1-2 1
Soft Keys 1-1-2 1
DATA Keys 1-1-2 1
General Setup Screen 1-1-2 2
Antenna Mounting 1-1-2 2
Ramp Testing 1-1-2 3
XPDR SETUP Screen 1-1-2 3
XPDR CONFIG Screen 1-1-2 5
XPDR AUTO Test Screen 1-1-2 5
XPDR Test List Screen 1-1-2 5
ADS-B/GICB SETUP Screen 1-1-2 6
ADS-B/GICB MAIN Menu 1-1-2 6
ADS-B GEN List Screen 1-1-2 7
ADS-B MON List Screen 1-1-2 7
ADS-B MON BDS Screen Example 1-1-2 7
GICB List Screen 1-1-2 8
GICB BDS Screen Example 1-1-2 8
SETUP-DME Screen 1-1-2 9
DME Test Screen 1-1-2 10
SETUP TCAS Screen 1-1-2 10
TCAS Test Screen 1-1-2 11
SETUP TIS Screen 1-1-2 12
TIS Test Screen 1-1-2 14
Battery Recharging 1-2-1 2
IFR 6015 Front Panel 1-2-2 1
Directional Antenna 1-2-2 6
Breakout Box, Front View 1-2-2 6
Breakout Box, Top View 1-2-2 7
Breakout Box, Bottom View 1-2-2 7
Setup XPDR Screen 1-2-4 3
Setup General Screen 1-2-4 6
Setup Test Data Screen 1-2-4 6
Confirm Screen 1-2-4 6
Setup Store Name Screen 1-2-4 7
Auto Test Screen Test Running 1-2-4 8
Auto Test Screen PASS 1-2-4 8
Auto Test Screen FAIL 1-2-4 10
Auto Test Screen NO REPLY 1-2-4 10
XPDR Test List Mode S 1-2-4 11
XPDR Test List ATCRBS 1-2-4 11
XPDR A/C Decoder/SLS Test Screen 1-2-4 11
XPDR A/C Spacing Width Test Screen 1-2-4 12
Power and Frequency (Mode S) Test Screen 1-2-4 13
Power and Frequency (ATCRBS) Test Screen 1-2-4 13
XPDR - S All Call Test Screen 1-2-4 15
XPDR - S Reply Timing Test Screen 1-2-4 16
XPDR - S Reply Test Screen 1-2-4 17
UF0 Test Screen 1-2-4 18
UF4 Test Screen 1-2-4 19
UF5 Test Screen 1-2-4 19
UF11 Test Screen 1-2-4 20
UF11 FAIL Test Screen 1-2-4 20

OPERATION MANUAL
IFR 6000
1-LIST OF TABLES
Subject to Export Control, see Cover Page for details. Page 2
Dec 1/07
LIST OF ILLUSTRATIONS (cont)
Title Chapter/Section/Subject Page
UF16 Test Screen 1-2-4 21
UF20 Test Screen 1-2-4 21
UF21 Test Screen PASS 1-2-4 22
UF21 Test Screen, NOT RUN 1-2-4 23
UF24 Test Screen 1-2-4 23
XPDR Elementary Surveillance 1 Test Screen 1-2-4 24
XPDR Elementary Surveillance 2 Test Screen 1-2-4 25
Enhanced Surveillance Test Screen 1-2-4 26
Altitude Encoder Test Screen, Source Encoder 1-2-4 28
Altitude Encoder Test Screen, Source XPDR 1-2-4 28
DME Screen 1-2-4 30
Setup DME Screen 1-2-4 32
TCAS Protection Volume 1-2-4 35
Typical TCAS II Display 1-2-4 37
Setup - TCAS Screen 1-2-4 38
TCAS Reply Parameters Screen 1-2-4 40
TCAS Screen (Mode S) 1-2-4 42
TCAS Screen (ATCRBS) 1-2-4 42
TCAS Surveillance Monitor Screen 1-2-4 47
TCAS Broadcast Monitor Screen 1-2-4 49
Whisper-Shout Monitor Screen 1-2-4 51
Recommended Test Locations 1-2-4 54
Setup ADS-B Screen 1-2-4 56
Setup Test Data Screen 1-2-4 57
Confirm Screen 1-2-4 57
Setup Store Name Screen 1-2-4 57
ADS-B/GICB Main Menu 1-2-4 58
ADS-B MON List Screen 1-2-4 58
ADS-B MON BDS 0,5 Screen 1-2-4 59
ADS-B MON BDS 0,6 Screen 1-2-4 60
ADS-B MON BDS 0,8 Screen 1-2-4 61
ADS-B MON BDS 0,9 Screen 1-2-4 62
ADS-B MON BDS 6,1 Screen 1-2-4 63
ADS-B MON BDS 6,2 Screen 1-2-4 64
ADS-B MON BDS 6,3 Screen 1-2-4 65
ADS-B GEN List Screen 1-2-4 68
ADS-B GEN BDS 0,5 Screen 1-2-4 68
ADS-B GEN BDS 0,6 Screen 1-2-4 69
ADS-B GEN BDS 0,8 Screen 1-2-4 70
ADS-B GEN BDS 0,9 Screen 1-2-4 71
ADS-B GEN BDS 6,1 Screen 1-2-4 72
ADS-B GEN BDS 6,2 Screen 1-2-4 73
ADS-B GEN BDS 6,3 Screen 1-2-4 74
GICB List Screen, 1-12 1-2-4 76
GICB List Screen, 13-24 1-2-4 76
GICB BDS 0,5 Screen 1-2-4 77
GICB BDS 0,6 Screen 1-2-4 78
GICB BDS 0,7 Screen 1-2-4 79
GICB BDS 0,8 Screen 1-2-4 80
GICB BDS 0,9 Screen 1-2-4 81
GICB BDS 1,0 Screen 1-2-4 82

OPERATION MANUAL
IFR 6000
1-LIST OF TABLES
Subject to Export Control, see Cover Page for details. Page 1
Dec 1/07
LIST OF ILLUSTRATIONS (cont)
Title Chapter/Section/Subject Page
GICB BDS 1,7 Screen 1-2-4 84
GICB BDS 1,8 Screen 1-2-4 84
GICB BDS 1,9 Screen 1-2-4 84
GICB BDS 1,A Screen 1-2-4 84
GICB BDS 1,B Screen 1-2-4 85
GICB BDS 1,C Screen 1-2-4 85
GICB BDS 1,D Screen 1-2-4 86
GICB BDS 1,E Screen 1-2-4 86
GICB BDS 1,F Screen 1-2-4 86
GICB BDS 2,0 Screen 1-2-4 87
GICB BDS 2,1 Screen 1-2-4 87
GICB BDS 3,0 Screen 1-2-4 88
GICB BDS 4,0 Screen 1-2-4 89
GICB BDS 4,1 Screen 1-2-4 90
GICB BDS 4,2 Screen 1-2-4 90
GICB BDS 4,3 Screen 1-2-4 91
GICB BDS 5,0 Screen 1-2-4 91
GICB BDS 6,0 Screen 1-2-4 92
GICB BDS 6,1 Screen 1-2-4 93
GICB BDS 6,2 Screen 1-2-4 93
GICB BDS 6,3 Screen 1-2-4 95
Setup TIS Screen 1-2-4 97
TIS Operation Screen 1-2-4 99
TIS Display Example 1-2-4 99
TIS Operation Flow Chart 1-2-4 100
Directional Antenna Mounted on Test Set 1-2-4 101
Hand Held Directional Antenna 1-2-4 101
Tripod Mounted Directional Antenna 1-2-4 101
Mode S Coverage Within 12 nmi Simulate Range 1-2-4 102
TCAS 6015 Effective Test Coverage 1-2-4 102
Suggested Layout to Reduce Multipath Errors 1-2-4 103
Ramp Testing 1-2-4 104
IFR 6015 with Breakout Box 1-2-4 105
Repacking Procedure 1-4-1 1

OPERATION MANUAL
IFR 6000
1-LIST OF TABLES
Subject to Export Control, see Cover Page for details. Page 4
Dec 1/07
THIS PAGE INTENTIONALLY LEFT BLANK.

OPERATION MANUAL
IFR 6000
1-LIST OF TABLES
Subject to Export Control, see Cover Page for details. Page 1
Dec 1/07
LIST OF TABLES
Title Chapter/Section/Subject Page
Test Identifier Symbols 1-2-4 9
Common Usage GICB BDS 1-2-4 25
Protection Volume Parameters Versus Altitude 1-2-4 35
SL: Field Valid Data 1-2-4 40
CA: Field Valid Data 1-2-4 41
RI: Field (Acquisition) Valid Data 1-2-4 41
RI: Field (Tracking) Valid Data 1-2-4 41
RAC: Field Valid Data 1-2-4 41
ARA: Field Valid Data 1-2-4 42
CVC: Field Display Data 1-2-4 48
VRC: Field Display Data 1-2-4 48
CHC: Field Display Data 1-2-4 48
HRC: Field Display Data 1-2-4 48
ESB: Field Display Data 1-2-4 49
ARA=Field Valid Data 1-2-4 50
RAC=Field Valid Data 1-2-4 51
GICB Supported BDS Registers 1-2-4 77