Cata F-2060 User manual

INSTALLATION AND USER’S MANUAL
COOKER HOOD
F-2060

2
TABLE OF CONTENTS
1. Introduction 2
2. Safety precaution 2
3. Intended use 3
4. Parts supplied 3
5. Installation 3
6. Operation 5
7. Maintenance 5
8. Troubleshooting 5
9. Technical data 5
10. Environmental protection 5
1. INTRODUCTION
Thank you for choosing this cooker hood.
This installation and user’s manual is designed to provide you
with all required instructions related to the installation, use and
maintenance of the appliance. In order to operate the appliance
correctly and safety, please read this installation and user’s manual
carefully before installation and usage.
Keep this installation and user’s manual for future use. Should this
appliance be passed on to a third party, then this installation and
user’s manual must be included.
No liability will be accepted for damage resulting from improper
use or non-compliance with these instructions.
2. SAFETY PRECAUTION
Important! Always switch o the electricity supply at
the mains during installation and maintenance such as
for light bulb replacement.
General
t5IFDPPLFSIPPEJTTVJUBCMFGPSEPNFTUJDVTFPOMZChildren
t1MFBTFEJTQPTFPGUIFQBDLBHJOHNBUFSJBMDBSFGVMMZPackaging material can be dangerous to children. Danger of
suocation!
t$IJMESFOTIPVMECFTVQFSWJTFEUPFOTVSFUIBUUIFZEPOPUplay with the appliance.
Installation
t5IFDPPLFSIPPENVTUCFJOTUBMMFEJOBDDPSEBODFXJUIUIFinstallation instructions and all measurements must be
followed.
t"MMJOTUBMMBUJPOXPSLNVTUCFDBSSJFEPVUCZBDPNQFUFOUperson or qualied electrician.
t8IFOJOTUBMMJOHUIFDPPLFSIPPENBLFTVSFUIBUUIFGPMMPXJOHrecommended distances between the top of cooker and the
lowest part of the cooker hood are observed:
Gas cookers: 70cm
Electric cookers: 67cm
$PBMPSPJMDPPLFSTDNt%POPUJOTUBMMBCPWFBDPPLFSXJUIBIJHIMFWFMHSJMMt.BLFTVSFUIFEVDUJOHIBTOPCFOETTIBSQFSUIBOEFHSFFTas this will reduce the eciency of the cooker hood.
t1BZBUUFOUJPOUPUIFTIBSQFEHFTJOTJEFUIFDPPLFSIPPEduring installation.
Electrical safety
t3FHVMBSMZDIFDLUIFQPXFSDPSEGPSEBNBHF*GUIFTVQQMZcord is damaged, it must be replaced by the manufacturer, its
service agent or similarly qualied persons in order to avoid a
hazard.
t5IFBQQMJBODFNVTUCFJOTUBMMFEJOTVDIBXBZUIBUUIFQPXFSsupply is accessible at all times. t#FGPSFDPOOFDUJOHUIFBQQMJBODFUPUIFQPXFSTVQQMZDIFDLthat the power supply voltage and current rating corresponds
with the power supply details shown on the appliance rating
label.
t/FWFSVTFBEBNBHFEBQQMJBODF%JTDPOOFDUUIFBQQMJBODFfrom the power source and contact your supplier if it is
damaged.
tDanger of electric shock! %POPUBUUFNQUUPSFQBJSUIFappliance yourself. In case of malfunction, repairs are to be
conducted by qualied personnel only.
t5PBWPJEEBNBHJOHUIFDPSEEPOPUTRVFF[FCFOEPSDIBGFit on sharp edges. Keep it away from hot surfaces and open
ames as well.
t-BZPVUUIFDPSEJOTVDIBXBZUIBUOPVOJOUFOUJPOBMQVMMJOHor tripping over it is possible.
t%POPUPQFOUIFBQQMJBODFDBTJOHVOEFSBOZDJSDVNTUBODFT%POPUJOTFSUBOZGPSFJHOPCKFDUTJOUPUIFJOTJEFPGUIFDBTJOHt/FWFSVTFBDDFTTPSJFTXIJDIBSFOPUSFDPNNFOEFECZUIFmanufacturer. They could pose a safety risk to the user and
might damage the appliance. Only use original parts and
accessories.
t,FFQUIFBQQMJBODFBXBZGSPNBOZIPUTVSGBDFTBOEPQFOames. Install the appliance on a level, stable, clean and
dry surface. Protect the appliance against heat, dust, direct
sunlight, moisture, dripping and splashing water.
t%POPUQMBDFIFBWZPCKFDUTPOUPQPGUIFBQQMJBODF%POPUQMBDFPCKFDUTXJUIPQFOøBNFTFHDBOEMFTPOUPQPGPSCFTJEFUIFBQQMJBODF%POPUQMBDFPCKFDUTöMMFEXJUIXBUFSe.g. vases on or near the appliance.
t5IJTBQQMJBODFJTOPUJOUFOEFEGPSVTFCZQFSTPOTJODMVEJOHchildren) with reduced physical, sensory, or mental
capabilities, or by those who lack experience and knowledge,
unless they have been given supervision and instruction
concerning the use of the appliance by a person responsible
for their safety.
Gas safety
t"MXBZTQVUMJETPOQPUTBOEQBOTXIFODPPLJOHPOBHBTcooker.
Operation
Danger of re!
t%POPUøBNCÏVOEFSUIFDPPLFSIPPEt%POPUMFBWFGSZJOHQBOTVOBUUFOEFEEVSJOHVTFbecause overheated fats or oils might catch re.
t/FWFSMFBWFOBLFEøBNFTVOEFSUIFDPPLFShood.
t0OMZGSZVOEFSOFBUIUIFDPPLFSIPPEXIFOZPVare in the kitchen.
t
%POPUVTFUIFDPPLFSIPPEXJUIPVUUIFHSFBTFöMUFSTPSJGUIFöMUFSTBSFFYDFTTJWFMZHSFBTZ
Caution! Accessible parts may become hot when used
with cooking appliances.
Exhaust operation
Danger!
t%VSJOHFYIBVTUPQFSBUJPOUIFDPPLFSIPPESFNPWFTBJSGSPNa room. If other re sources that require the surrounding air
GPSDPNCVTUJPOBSFCFJOHPQFSBUFEJOUIFTBNFSPPNFHgas, oil or coal heaters), the oxygen they require is taken
away. Thus ames could be suocated and gas could leak out
or the fumes could be drawn back into the room.
t
In order to guarantee a safe operation, there should be non-
closable openings in doors, windows or in an air intake wall
box to ensure a fresh supply of combustion air. This will prevent
the combustion fumes from being drawn back into the room.

3
t8IFOBTTFTTJOHUIFNFBTVSFTOFDFTTBSZBMXBZTUBLFUIFentire ventilation system of the house into consideration. In
case of doubt, ask your local chimney sweeper for help.
t/FWFSTFDVSFUIFDPPLFSIPPEUPBWFOUJMBUJPOEVDUPSBSPPNPSFYIBVTUHBTDIJNOFZ%POPUMFUUIFBJSUIBUJTSFNPWFEGSPNthe room be drawn into a duct where warm air is circulating.
The extracted air should only be drawn outdoors through a
separate ventilating duct that is only for the extractor hood.
t8IFOJOFYUSBDUJPONPEFBJSJOUIFSPPNJTCFJOHSFNPWFEby the cooker hood. Please make sure that proper ventilation
measures are being observed. The cooker hood removes
odours from room but not steam.
t5IFSFTIBMMCFBEFRVBUFWFOUJMBUJPOPGUIFSPPNXIFOUIFrange hood is used at the same time as appliances burning
HBTPSPUIFSGVFMTOPUBQQMJDBCMFUPBQQMJBODFTUIBUPOMZdischarge the air back into the room).
t5IFBJSNVTUOPUCFEJTDIBSHFEJOUPBøVFUIBUJTVTFEGPSexhausting fumes from appliances burning gas or other fuels
OPUBQQMJDBCMFUPBQQMJBODFTUIBUPOMZEJTDIBSHFUIFBJSCBDLinto the room).
Cleaning
t5IFSFJTBöSFSJTLJGDMFBOJOHJTOPUDBSSJFEPVUJOBDDPSEBODFwith the instructions.
t1BZBUUFOUJPOUPUIFTIBSQFEHFTJOTJEFUIFDPPLFSIPPEespecially during cleaning.
t"MXBZTEJTDPOOFDUUIFQPXFSTVQQMZQSJPSUPDMFBOJOHUIFcooker hood or the lter. If the switched fused connection
unit is dicult to reach, shut o the power supply by using
the corresponding circuit breaker at the distribution board.
t,FFQUIFDPPLFSIPPEDMFBO'BUEFQPTJUTDPVMEMJHIUPOöSFwhen exposed to high temperatures.
3. INTENDED USE
t:PVSDPPLFSIPPEDBOCFPQFSBUFEJOSFDJSDVMBUFEBJSoperation or in exhaust operation.
tRecirculated-air: Kitchen fumes are removed and after
purication are fed back into the room through the upper air
outlet openings. The purication takes place via the grease
lter.
4. PARTS SUPPLIED
No. Part Qty.
1$PPLFSIPPE1
2 Extraction duct frame 1
3#MPDLFS1
4-VNJOBSZ1
5. INSTALLATION
tImportant! 8FSFDPNNFOEUIBUUXPQFPQMFDBSSZPVUUIFinstallation. Pay attention to the procedure described in the
assembly instructions.
Preparation
tExhaust operation:5IFXBMMCSFBLUISPVHIDPSFESJMMIPMFmin. 125mm) must be carried out by a professional prior to
installing the extractor hood.
Pay attention to the length of the exhaust hose when
planning the wall breakthrough. The exhaust hose must
reach the outer edge of the wall without any kinks.
Important! If the exhaust hose leads through an outer wall,
the air outlet on the outside must be equipped with a cover
UIBUIBTTFMGPQFOJOHTMJUTOPUTVQQMJFE5IJTDBOCFJOTUBMMFEby the company that performs the wall breakthrough.
If open replaces are operated in the same room, ask your
local chimney sweeper about the local regulations prior to
installation.
If you are renting, then approval must be obtained from the
owner of the property.
tAttention! In order for the cooker hood to reach optimal
performance, mount it over the middle of the cooking area.
t1MBOUIFQPXFSDPOOFDUJPOQSJPSUPJOTUBMMBUJPOTPUIBUBdisturbing cable will not be visible afterwards.
t5IFGPMMPXJOHBDDFTTPSJFTBSFSFRVJSFEUPNPVOUUIFDPPLFSIPPEOPUJODMVEFEXJUIUIFEFMJWFSZ4 sets of suitable screws
öUUJOHXBMMQMVHTBOETQBDFSTJGSFRVJSFEExhaust duct
Power drill
Screwdriver
8BUFSMFWFM$BCMFEFUFDUPSt3FNPWFTUZSPGPBNBOEQSPUFDUJWFXSBQQJOHGSPNUIFNPUPSinside the appliance.
Electrical connectionöH)
Danger of electric shock! Any electrical installation
must be carried out by an authorised professional.
t"MMöUUJOHTNVTUCFJOTUBMMFECZBDPNQFUFOUQFSTPOJOBDDPSEBODFXJUIDVSSFOU*&&8JSJOH3FHVMBUJPOT#4and local building regulations. If in doubt, consult a qualied
electrician.
tImportant! Always switch o the electricity supply at the
NBJOTEVSJOHJOTUBMMBUJPOBOENBJOUFOBODF8FSFDPNNFOEthat the fuse is withdrawn or circuit breaker switched o at
the distribution board whilst work is in progress.
t1SJPSUPESJMMJOHIPMFTUPTFDVSFJUUPUIFXBMMNBLFTVSFUIBUOPDBCMFTPSQJQFTXJMMCFDPNFEBNBHFEFMFDUSJDHBTXBUFSetc.; test the areas in question with a cable detector).
t5IJTVOJUJTEPVCMFJOTVMBUFEBOENVTUOPUCFFBSUIFE*GUIFSFBSFBOZJODPNJOHFBSUIDBCMFTUIFZNVTUCFKPJOFEBOEXFMMinsulated with good quality insulation tape. This is to ensure
earth continuity throughout your property.
t4IPVMEZPVSFRVJSFBOBEEJUJPOBMQPXFSDPOOFDUJPOGPSUIJTappliance, hire an electrician.
t.FBOTGPSEJTDPOOFDUJPONVTUCFJODPSQPSBUFEJOUIFöYFEwiring in accordance with the wiring rules. To achieve this
install appropriate switched fused connection unit.
tNote! A switched fused connection unit having a contact
separation of at least 3mm in all poles should be connected
in xed wiring.

4
t$POOFDUUIFJODPNJOHQPTJUJWFBOEOFVUSBMDBCMFTUPUIFterminals of the switched fused connection unit. Ensure
connections are tight.
Mounting methods
t5IFDPPLFSIPPEDBOCFFJUIFSNPVOUFEPOBXBMMöH), or
VOEFSOFBUIBTVJUBCMFLJUDIFODBCJOFUöH).













A
#$$t5IFBQQMJBODFJTQSPWJEFEXJUIBJSPVUMFUT"#POFXIJDIJTPOUIFVQQFSQBSUBOEUIFPUIFSPOUIFCBDLöH#PUIof them can be used according to your requirements.
Option 1 - Mounting on a wall
t%SJMMIPMFTJOUPUIFXBMMXIJDIDPSSFTQPOEUPQPTJUJPO$
öH). Insert 2 sets of screws and wall plugs, which are
BQQSPQSJBUFGPSUIFUZQFPGXBMMFYBNQMFDPODSFUFQMBTUFSCPBSE%POPUGVMMZJOTFSUUIFTDSFXTMFUUIFNQSPUSBDUPVUof the wall by about 2mm. Then, hang the cooker hood on
the 2 screws.
t"UUBDIUIFFYUSBDUJPOEVDUGSBNFUPFYIBVTUEVDUBOEVTFEBJSPVUMFU"PS#$MPTFUIFVOVTFEBJSPVUMFU"PS#XJUIUIFCMPDLFSOption 2 - Mounting under a hanging kitchen cabinet
t%SJMMIPMFTPGNNEJBNFUFSBUUIFCPUUPNPGUIFIBOHJOHLJUDIFODBCJOFUöH). Attach the cooker hood by using
fasteners, such as self-retaining screws, that are suitable for
UIFDBCJOFUTNBUFSJBMUZQFFYBNQMFXPPEQMBTUJDNFUBMt"UUBDIUIFFYUSBDUJPOEVDUGSBNFUPFYIBVTUEVDUBOEVTFEBJSPVUMFU"PS#$MPTFUIFVOVTFEBJSPVUMFU"PS#XJUIUIFCMPDLFSInstallation with exhaust duct
t5PVTFUIFFYIBVTUPQFSBUJPOBXBMMCSFBLUISPVHIJTSFRVJSFEXJUIBEJBNFUFSPGBUMFBTUNN8FSFDPNNFOEUIBUZPVMFUBTQFDJBMJTUFMFDUSJDJBOQFSGPSNUIFXBMMCSFBLUISPVHIDPSFESJMMIPMFt5IFTIPSUFSUIFFYIBVTUEVDUJTBOEUIFMFTTCFOETJUIBTUIFmore ecient the cooker hood will be.
t0óDJBMSFHVMBUJPOTNBZWBSZGSPNSFHJPOUPSFHJPO*ODBTFof doubt, we recommend asking your local chimney sweeper
for advice.
t*GZPVIBWFBOPVUMFUUPUIFPVUTJEFZPVSDPPLFSIPPEDBOCFDPOOFDUFECZNFBOTPGBOFYUSBDUJPOEVDUFOBNFMaluminum, exible pipe or inammable material with an
interior diameter of 125mm).
t5IFDPPLFSIPPETIPVMECFQMBDFEBUBEJTUBODFPG_DNabove the cooking place for best eect.
t%SJMMIPMFTPOUIFXBMMUPBDDPNNPEBUFUIFIPMFTPGUIFcooker hood. Screw and tighten the cooker hood onto the
wall with suitable screws and wall plugs.
Bridging larger distances
t#SJEHJOHMBSHFSEJTUBODFTUPUIFPVUEPPSTDBOCFBDIJFWFECZinstalling an external motor inside the exhaust duct. To do
this, consult an electrician.
Installation without exhaust duct
t*GZPVEPOPUIBWFBOPVUMFUUPUIFPVUTJEFUIFFYIBVTUQJQFis not required and the installation is similar to the one shown
in the Installation with exhaust duct section.
t
$MPTFPOFPGUIFBJSPVUMFUTöH"PS# XJUIUIFCMPDLFSt4FUUIFTNBMMMFWFSJOTJEFUIFBQQMJBODFUPUIFöMUFSJOHQPTJUJPOöH).'JMUFSJOHposition Air-exhaust
position
%FGBVMU

5
6. OPERATION
t4XJUDIPOUIFBQQMJBODFBUUIFTXJUDIFEGVTFEDPOOFDUJPOunit.
Functions
Switch
position
Function
OAppliance switched o
I-PXTQFFEII Medium speed
III High speed
-JHIUTPO-JHIUTPò7. MAINTENANCE
t#FGPSFDMFBOJOHTXJUDIUIFBQQMJBODFPòBOEEJTDPOOFDUUIFcooker hood from power supply.
t$MFBOUIFBQQMJBODFJOUIFGPMMPXJOHJOUFSWBMT
Regularly
Use a soft cloth moistened with hand-warm mildly
soapy water or household cleaning detergent. Never
use metal pads, chemical, abrasive material or sti
brush to clean the appliance.
Monthly
Metallic anti-grease lter: The lter collects grease,
smoke and dust so the lter is directly aecting the
eciency of the cooker hood. If not cleaned, the
HSFBTFSFTJEVFQPUFOUJBMøBNNBCMFXJMMTBUVSBUFPOUIFöMUFS$MFBOJUXJUIIPVTFIPMEDMFBOJOHEFUFSHFOUImportant:$MFBOUIFöMUFSFWFSZNPOUIUPprevent risk of re.
Light bulb replacement
t4XJUDIUIFBQQMJBODFPòBOEEJTDPOOFDUUIFQPXFSTVQQMZt*OPSEFSUPSFQMBDFUIFMJHIUCVMCUIFNFUBMMJDBOUJHSFBTFöMUFSshould be detached rst. Press the lock and pull it downward.
t4DSFXUIFMJHIUCVMCGSPNUIFIPMEFSBOEJOTFSUBMJHIUCVMCPGUIFTBNFUZQFNBY8&t3FQMBDFUIFNFUBMMJDBOUJHSFBTFöMUFSBOENBLFTVSFJUMPDLTin place.
8. TROUBLESHOOTING
Fault Cause Solution
Excessive
vibration
The appliance is
not hung properly
on the bracket.
Take down the
appliance and
check it is properly
xed.
The fan blade is
damaged.
Switch o the
BQQMJBODF3FQBJSto be carried out
by qualied service
personnel only.
The fan motor is
not xed tightly.
-JHIUPOCVUGBOdoes not work
The fan blade is
KBNNFEThe motor is
damaged.
#PUIMJHIUBOEGBOdo not work -JHIUCVMCCSPLFO3FQMBDFXJUIBbulb with correct
rating.
Power connection
loose. $IFDLQPXFSsupply.
Suction
performance
not good %JTUBODFCFUXFFOthe appliance and
the cooking place
too large. 3FBEKVTUUIFdistance to:
Gas cookers: 70cm
Electric cookers: 67cm
$PBMPJMDPPLFSTDN
Metallic anti-
grease lter is dirty. $MFBOöMUFSTFFMaintenance
chapter).
9. TECHNICAL DATA
1PXFSTVQQMZ7_)[1PXFSDPOTVNQUJPOū'BO81PXFSDPOTVNQUJPOū-VNJOBSZ81PXFSDPOTVNQUJPOū5PUBM8Protection class : II
-VNJOBSZ.BY8&10. ENVIRONMENTAL PROTECTION
8BTUFFMFDUSJDBMQSPEVDUTTIPVMEOPUCFEJTQPTFEPGwith household waste. Please recycle where facilities
FYJTU$IFDLXJUIZPVS-PDBM"VUIPSJUZPSSFUBJMFSGPSrecycling advice.