Chauvet Hurricane 1300 User manual

User Manual

Hurricane™ 1300 User Manual 2 August 2011
TABLE OF CONTENTS
1. BEFORE YOU BEGIN ................................................................................................... 3
What Is Included ......................................................................................................... 3
Unpacking Instructions................................................................................................ 3
Claims.................................................................................................................. 3
Product at a Glance..................................................................................................... 3
Safety Instructions....................................................................................................... 4
2. INTRODUCTION............................................................................................................ 5
Product Overview........................................................................................................ 5
Product Dimensions.................................................................................................... 6
3. SETUP ........................................................................................................................... 7
AC Power.................................................................................................................... 7
Fuse Replacement...................................................................................................... 7
Mounting ..................................................................................................................... 8
Orientation ........................................................................................................... 8
Rigging................................................................................................................. 8
4. OPERATING INSTRUCTIONS ...................................................................................... 9
Manual Remote Operation (FC-M) (Optional) ............................................................. 9
Timer Remote Operation (FC-T) (Standard) ............................................................... 9
Wireless Controller (FC-W) (Optional)....................................................................... 10
General Troubleshooting........................................................................................... 11
Contact Information................................................................................................... 11
5. APPENDIX................................................................................................................... 12
General Maintenance................................................................................................ 12
Returns Procedure.................................................................................................... 13
TECHNICAL SPECIFICATIONS...................................................................................... 14

Hurricane™ 1300 User Manual 3 August 2011
1. BEFORE YOU BEGIN
What Is Included
1 x Hurricane™ 1300
1 x FC-T wired timer remote
1 x Warranty Card
1 x User Manual
Unpacking Instructions
Immediately upon receiving a fixture, carefully unpack the carton, check the contents to
ensure that all parts are present, and have been received in good condition. Notify the
shipper immediately and retain packing material for inspection if any parts appear
damaged from shipping or the carton itself shows signs of mishandling. Save the carton
and all packing materials. In the event that a fixture must be returned to the factory, it is
important that the fixture be returned in the original factory box and packing.
Claims
The carrier is responsible for any damage incurred during shipping to this product or any
part that shipped with it. Therefore, if the received merchandise appears to have damages
caused during shipping, the customer must submit the damage report and any related
claims with the carrier, not CHAUVET®. The customer must submit the report upon
reception of the damaged merchandise. Failure to do so in a timely manner may invalidate
the customer’s claim with the carrier.
For other issues such as missing components or parts, damage not related to shipping, or
concealed damage, the customer must make claims to CHAUVET® within seven (7) days
of receiving the merchandise.
Product at a Glance

UseonDimmerAutoPrograms
OutdoorUseAuto‐rangingPowerSupply
SoundActivatedReplaceableFuse
DMXUserServiceable
Master/SlaveDutyCycle

Hurricane™ 1300 User Manual 4 August 2011
Safety Instructions
Please read the following notes carefully because they include important safety
information about the installation, usage, and maintenance of this product.
Please keep this User Guide for future consultation. If you sell the unit to another
user, be sure that they also receive this instruction booklet.
Always make sure that you are connecting to the proper voltage, and that the line
voltage you are connecting to is not higher than that stated on the decal or rear panel
of the fixture.
This product is intended for indoor use only! (If applicable)
To prevent risk of fire or shock, do not expose fixture to rain or moisture. Make sure
there are no flammable materials close to the unit while operating.
The unit must be installed in a location with adequate ventilation, at least 20in (50cm)
from adjacent surfaces. Be sure that no ventilation slots are blocked.
Always disconnect from power source before servicing or replacing lamp or fuse and
be sure to replace with same lamp source.
Secure fixture to fastening device using a safety chain. Never carry the fixture solely
by its head. Use its carrying handles.
Maximum ambient temperature (Ta) is 104°F (40°C). Do not operate fixture at
temperatures higher than this.
In the event of a serious operating problem, stop using the unit immediately. Never try
to repair the unit by yourself. Repairs carried out by unskilled people can lead to
damage or malfunction. Please contact the nearest authorized technical assistance
center. Always use the same type spare parts.
Never connect the device to a dimmer pack.
Make sure the power cord is never crimped or damaged.
Never disconnect the power cord by pulling or tugging on the cord.
Avoid direct eye exposure to the light source while it is on.
There are no user serviceable parts inside the unit. Do not open the housing or
attempt any repairs yourself. In the unlikely event your unit may require service,
please contact CHAUVET at: 954-929-1115.

FCQ (Fog Cleaner Quart) was specifically developed by Chauvet to clean your
Hurricane™ 1300. Make sure you use FCQ regularly to increase the life of your fogger.

Hurricane™ 1300 User Manual 5 August 2011
2. INTRODUCTION
Product Overview
Fluid
container
Hanging
bracket
Fluid level
indicator
Low Fluid
indicator
Heater
Nozzle
Tilt
Adjustment
knob
Power
switch
Manual
controller
Fuse holder
Wireless
Controlle
r
Manual Fog
button
Handle
Safety
eyebolt
Power input
(hardwired)

Hurricane™ 1300 User Manual 6 August 2011
Product Dimensions
317 mm / 12.5 in 425 mm / 16.7 in
306 mm / 12 in

Hurricane™ 1300 User Manual 7 August 2011
The fuse is located
inside this
compartment.
Remove using a flat
head screwdriver.
3.SETUP
AC Power
To determine the power requirements for a particular fixture, see the label affixed to the
back plate of the fixture or refer to the fixture’s specifications chart. A fixture’s listed
current rating is its average current draw under normal conditions. All fixtures must be
powered directly off a switched circuit and cannot be run off a rheostat (variable resistor)
or dimmer circuit, even if the rheostat or dimmer channel is used solely for a 0% to 100%
switch. Before applying power to a fixture, check that the source voltage matches the
fixture’s requirement. Check the fixture or device carefully to make sure that if a voltage
selection switch exists that it is set to the correct line voltage you will use.
Fuse Replacement
Unplug the IEC power cable before replacing the fuse! Always replace with same type
of fuse.
This product has a replaceable fuse. In the event that the fuse needs to be replaced, follow
the instructions provided below.
1. Using a flat head screwdriver, remove the fuseholder from the IEC housing.
2. Remove the bad fuse from the fuseholder.
3. Insert the new fuse into the fuseholder.
4. Install the fuseholder in the IEC
housing.

Hurricane™ 1300 User Manual 8 August 2011
Hanging Clamp
Note!
Clamp is sold separately.
Angled Up
Angled Down
Mounting
Orientation This fixture should only be mounted/used on a flat surface. This fixture may not be tilted.
Rigging It is important never to obstruct the vents pathways. Mount the fixture using, a suitable “C”
or “O” type clamp.
When selecting installation location, take into consideration the fluid reservoir
access and routine maintenance.
Safety cables must always be used, utilizing the provided safety eye bolt.
Never mount in places where the fixture will be exposed to rain, high humidity,
extreme temperature changes or restricted ventilation.

Hurricane™ 1300 User Manual 9 August 2011
4. OPERATING INSTRUCTIONS
Manual Remote Operation (FC-M) (Optional)
1. Plug in the fog machine to power and turn the power switch to the fixture on.
2. Plug in the wired manual remote to the Manual Controller socket on the rear of the
fog machine.
3. Press the single button located on the remote to trigger the fog output.

The button is momentary, which means that the fog machine will only output while the button
is pressed. Once the button is released, the fog will stop outputting.
Timer Remote Operation (FC-T) (Standard)
This mode will allow you to control the fogger manually, set the fog machine to run
continuously, or to set the fog machine to run off bursts with adjustable interval and
duration settings.
1. Plug in the fog machine to power and turn the power switch to the fixture on.
2. Plug in the timer remote to the Manual Controller socket on the rear of the fog
machine.
3. Press the TIMER ON/OFF button on the timer remote. The LED above the button
should light, indicating activation of function.
4. You may now set the INTERVAL & DURATION adjustment knobs to the desired
position.

The INTERVAL is the time between bursts of fog.
The DURATION is the time the fog machine will run during the burst.
Duration
Adjustment
Interval
A
d
j
ustment
Timer LED
Indicator Manual
Momentary LED
Manual/Power
LED Manual control
Momentary
Continuous
Latching Button
Timer Latching
Button

Hurricane™ 1300 User Manual 10 August 2011
Wireless Controller (FC-W) (Optional)
This mode will allow you to control the fogger using the optional wireless controller. This
consists of the transmitter and the receiver. You may control up to 4 independent fog
machines or many more if you run them simultaneously. See the below instructions on
setting up your fogger to operate with the FC-W.
1. Plug the wires receiver into the fog machine 5-pin port labeled “Wireless
Controller”.
2. There are 4 buttons on the wireless remote transmitter which act as triggers.
Each button can be assigned to a different fog machine. You may only
choose 1 dipswitch on each receiver. See the below configuration for setting
the receivers to operate with the transmitter remote.
Mode Dipswitches
CH1 1 = On, 2-4 = Off
CH2 2 = On, 1,3,4 = Off
CH3 3 = On, 1,2,4 = Off
CH4 4 = On, 1,2,3 = Off
3. Press the fog button, and the fog machine will output fog momentarily for as
long as you hold down the button.
Wireless Receiver
LED indicator
(heating)
LED indicator
(ready)
Dipswitches
Wireless
Transmitter
Fog Triggers

Hurricane™ 1300 User Manual 11 August 2011
General Troubleshooting
Symptom Solution(s)
No Power Check mains power.
Check external fuse.
Check internal fuse.
No fog output Check fluid level.
Check remote.
If using wireless, check batteries.
If using wireless, check dipswitches on receiver.
Breaker/Fuse keeps
blowing Possible electrical short. Contact Chauvet or a Chauvet Dealer/distributor for further instruction.
Low fog output Run a cleaning solution through the fog machine.
Check that the fog machine is plugged into the correct voltage.
Fog machine is not
heating up Check to replace the external fuse.
Check to replace the internal fuse.
Possible bad part. Contact Chauvet or a Chauvet Dealer/distributor for further
instruction.
Remote does not
work Make sure connector is firmly connected to device.
Try using another controller. Possible bad controller.
Check the internal fuse.
Check the external fuse.
Fluid indicator states
no fog, but the
container if full.
Try resetting the fog machine by turning the power off, and then on again.
Possible bad part. Contact Chauvet or a Chauvet Dealer/distributor for further
instruction.
If you still have a problem after trying the above solutions, please contact CHAUVET Technical
Support at the location listed below.
Contact Information
WorldHeadquartersUnitedKingdom&Ireland
CHAUVET®CHAUVET®EuropeLtd.
GeneralInformation
Address:5200NW108thAvenue
Sunrise,FL33351
Voice: (954)929‐1115
Fax: (954)929‐5560
Tollfree: (800)762‐1084
TechnicalSupport
Voice: (954)929‐1115(Press4)
Fax: (954)756‐8015
GeneralInformation
Address: Unit1C
BrookhillRoad
Pinxton,Nottingham,UK
NG166NT
Voice: +44(0)1773511115
Fax: +44(0)1773511110
Email: [email protected]

WorldWideWeb
www.chauvetlighting.com
WorldWideWeb
www.chauvetlighting.co.uk

Hurricane™ 1300 User Manual 12 August 2011
5.APPENDIX
General Maintenance
To maintain optimum performance and minimize wear fixtures should be cleaned
frequently. Usage and environment are contributing factors in determining frequency. As
a general rule, fixtures should be cleaned at least twice a month. Dust build up reduces
light output performance and can cause overheating. This can lead to reduced lamp life
and increased mechanical wear. Be sure to power off fixture before conducting
maintenance.
Unplug fixture from power. Use a vacuum or air compressor and a soft brush to remove
dust collected on external vents and internal components. Clean all glass when the fixture
is cold with a mild solution of glass cleaner or Isopropyl Alcohol and a soft lint free cotton
cloth or lens tissue. Apply solution to the cloth or tissue and drag dirt and grime to the
outside of the lens. Gently polish optical surfaces until they are free of haze and lint.
The cleaning of internal and external optical lenses and/or mirrors must be carried out
periodically to optimize light output. Cleaning frequency depends on the environment in
which the fixture operates: damp, smoky or particularly dirty surrounding can cause
greater accumulation of dirt on the unit’s optics. Clean with soft cloth using normal glass
cleaning fluid. - Always dry the parts carefully. - Clean the external optics at least every 20
days. Clean the internal optics at least every 30/60 days.

FCQ (Fog Cleaner Quart) was specifically developed by Chauvet to clean your
Hurricane™ 1300. Make sure you use FCQ regularly to increase the life of your
fogger.

Hurricane™ 1300 User Manual 13 August 2011
Returns Procedure
Returned merchandise must be sent prepaid and in the original packing, call tags will not
be issued. Package must be clearly labeled with a Return Merchandise Authorization
Number (RMA #). Products returned without a RMA # will be refused. Call CHAUVET and
request a RMA # prior to shipping the fixture. Be prepared to provide the model number,
serial number and a brief description of the cause for the return. Be sure to properly pack
fixture, any shipping damage resulting from inadequate packaging is the customer’s
responsibility. CHAUVET reserves the right to use its own discretion to repair or replace
product(s). As a suggestion, proper UPS packing or double-boxing is always a safe
method to use.
If you are given a RMA #, please include the following information on a piece of
paper inside the box:
1. Your name
2. Your address
3. Your phone number
4. The RMA #
5. A brief description of the symptoms

Hurricane™ 1300 User Manual 14 August 2011
TECHNICAL SPECIFICATIONS
WEIGHT & DIMENSIONS
Length ........................................................................................................16.7 in (425 mm)
Width..........................................................................................................12.5 in (317 mm)
Height.........................................................................................................12.0 in (306 mm)
Weight............................................................................................................21 lbs (9.5 kg)
POWER
AC Power...............................................................................120V 60Hz AC or 230V 50Hz
Fuse ......................................................................................................................13A 250V
Power Consumption................................................................1,328W (11.2A) max at 120V
Inrush Power................................................................................................(11.2A) at 120V
Power Factor.................................................................................................... 0.99 at 120V
Fuse ........................................................................................................................7A 250V
Power Consumption..................................................................1,325W (5.8A) max at 230V
Inrush Power................................................................................................(1.83A) at 230V
Power Factor.................................................................................................... 0.99 at 230V
THERMAL
Maximum ambient temperature........................................................................104°F (40°C)
CONTROL & PROGRAMMING
Data input......................................................................5-pin & ground DIN5 female socket
Data pin configurationpin1(LED), pin2(control), pin3(+5V), pin4(ground), pin5(none), ground(none)
ORDERING INFORMATION
Hurricane™ 1300........................................................................................................F1300
Wired manual remote (optional)...................................................................................FC-M
Wired timer remote (included).......................................................................................FC-T
Wireless manual remote (optional).............................................................................. FC-W
SPARE PARTS ORDERING INFORMATION
Master PCB................................................................................................ P170-F3MSPCB
Heater ................................................................................................................ 1P20-HT13
Pump.............................................................................................................P200-F3PUMP
Fluid container.................................................................................................. P170-F3FLC
Fluid sensor ...................................................................................................P170-F1FLOS
Thermal switch ...............................................................................................P170-THEF11
Bracket knob ...............................................................................................P111-F3BKNOB
Fuse holder ...............................................................................................P170-FUSEHOL
Manual fog button..........................................................................................P111-F3FOGB
WARRANTY INFORMATION
Warranty............................................................................................1-year limited warranty