Come.up Winch Seal Gen2 12.5s User manual

Instore "130"you
canfind and buy almostall necessarygoodsforyourauto
in
Kyiv and othercities,deliveryby ground andpostal services. Ourexperienced
consultantswill provide youwithexhaustive informationand helpyoutochose
the very particular thing.We arewaiting foryou at the address
http://130.com.ua
PHONES
(044) 338-0-130
(050) 332-0-130
(063) 577-0-130
(067) 353-0-130
Internet storeof
autogoods
CARRECEIVERS —Receivers •Mediareceiversandstations•Nativereceivers •CD/DVD changers •FM-modulators/USBadapters•Flashmemory•Faciaplates and adapters •Antennas •Accessories |
CARAUDIO —Car audiospeakers •Amplifiers•Subwoofers •Processors•Crossovers •Headphones•Accessories|TRIPCOMPUTERS —Universalcomputers •Modelcomputers •Accessories|
GPSNAVIGATORS —PortableGPS•Built-in GPS•GPSmodules •GPStrackers •Antennas forGPSnavigators•Accessories|VIDEO —DVR •TVsetsand monitors•Car TVtuners•Cameras •Videomodules
•Transcoders •Car TVantennas•Accessories|SECURITYSYSTEMS —Car alarms •Bikealarms •Mechanicalblockers •Immobilizers •Sensors •Accessories |OPTICANDLIGHT —Xenon•Bixenon •Lamps
•LED •Stroboscopes •OpticandHeadlights •Washers •Light,rainsensors •Accessories |PARKTRONICS ANDMIRRORS —Rear parktronics•Frontparktronics •Combined parktronics •Rear-viewmirrors
•Accessories |HEATINGANDCOOLING —Seat heaters •Mirrorsheaters •Screen-wipers heaters •Engineheaters •Auto-refrigerators •Airconditioningunits •Accessories |TUNING —Vibro-isolation
•Noise-isolation •Tintfilms •Accessories |ACCESSORIES —Radar-detectors•Handsfree,Bluetooth•Windowlifters•Compressors •Beeps,loudspeakers •Measuring instruments •Cleaners •Carsits
•Miscellaneous|MOUNTING —Installationkits •Upholstery•Grilles•Tubes•Cableand wire •Tools•Miscellaneous|POWER —Batteries •Converters •Start-chargingequipment•Capacitors
•Accessories |MARINE AUDIOANDELECTRONICS —Marinereceivers•Marineaudiospeakers •Marinesubwoofers •Marineamplifiers•Accessories |CARCARE PRODUCTS —Additives •Washer fluid •
Care accessories •Car polish •Flavors •Adhesives andsealants |LIQUIDANDOIL —Motoroil•Transmissionoil •Brakefluid •Antifreeze•Technicallubricant
SKYPE
km-130

Self-Recovery Winch
Model: Seal Gen2 12.5s
PN: 295750 12V DC
Introduction
 Feature
Line
pull:
5
,670 kg / 12,500 lb synthetic rope first layer
Synthetic
rope:
11
mm × 25 m (7/16"×82′) synthetic rope SK-75
Brake:
Patented cone brake holds full l
oad
Clutch
:
Turn the T
-handle for rapid rope payout
Control:
Handheld pendant switch powers the winch
 Unpacking
．
Winch assembly……………………………………..……………………
1
pc
．
Control box……………….................…………......……………...........
1
pc
．
Remote control………………………………….……………………......
1
pc
．
Synthetic rope with clevis hook………………….……………………...
1
pc
．
Hawse fairlead………………………………….…………………………
1
pc
．
1.8 m (6′) 2 gauge battery lead……………………...………………….
1
pc
 Read this manual carefully
You should carefully read and understand this manual before operating it.
Careless winch operation may result in personal injury hazards or property
damage.
Installation
Before using the winch, make sure all electrical components have no
corrosion or damaged; the environment should be clear and d r y.
 Winch and hawse fairlead mountings
 It is very important that the winch will be
mounted on a flat and hard surface of
mounting channel in order to make sure
the motor, drum and gearbox housing
are aligned correctly.
 Hawse fairlead does not mount to the
winch directly
Autogoods “130”
130.com.ua

 The synthetic rope shall be wound in an under-wound orientation only.
 Four (4) M10 x 1.50 pitch 8.8 grade with 44 N-m torque settings
(maximum) high tensile steel bolts must be used in order to sustain the
loads imposed on the winch mounting.
 Two (2) M12 x 1.75 pitch 8.8 grade with 76 N-m torque settings
(maximum) high tensile steel bolts must be used for fastening the hawse
fairlead into the mounting channel.
 Foot forward mounting only
 Wiring Diagram
Attach the black lead firmly to the negative (–) battery terminal and red lead
to the positive (+) battery terminal. The voltage drop for the winch motor must
not exceed 10% of the nominal voltage of 12V DC.
 Nut fastening for motor & contactor
1.Holding the lower nut on the stub and fastening the upper nut clockwise.
2.The torque setting for nut is 14 N-m/124 lb-in.
Warning
．
The winch is not intended to be used in any manner for the movement or
lifting of personnel.
．
The rated line pull shown is based on the first layer of rope on the drum.
．
The rope winding on the drum shall remain 10 wraps from the drum to support
Autogoods “130”
130.com.ua

the rated load.
．
Manufacturer is not responsible for the results of misuse, misapplication,
faulty installation or abuse of synthetic rope in any way.
Parts List
Item No. Description Part No. Qty
1
Water proof motor w/housing 12V
882519
1
2
Forward Tie bar kit
882521
1
3
Reverse Tie bar kit
882528
1
4
Motor coupling
880005
1
5
Drum bushing
880006
2
6
Drum kit
881521
1
7
Gearbox support rack
882523
1
8
Grounding lead
880009
1
9
Synthetic rope
881649
1
10 1st shaft 881523 1
11
3
rd
ring gear kit
882535
1
12
3
rd
stage carrier
881960
1
13
2
nd
stage carrier
881961
1
14
1
st
stage carrier
881962
1
15
1
st
& 2
nd
ring gear
881963
1
16
1
st
pinion
881964
1
17
Clutch kit
881564
1
18
Gear box kit
882536
1
19
Cone brake disc kit
880122
1
20
Brake clutch base
881100
1
21
Brake cover kit
882537
1
22
Hawse fairlead
881061
1
23
Mounting hardware
880024
1
24
Remote control
880126
1
25
Handsaver strap
880026
1
26
Control box 12V
881164
1
26-1
Remote socket kit 12V
881373
1
26-2
Control pack 12V
881400
1
27 Clevis hook 882477 1
Autogoods “130”
130.com.ua

Winch Assembly
Autogoods “130”
130.com.ua