Cretors E1200 User manual

176 MITTEL DRIVE, WOOD DALE , IL 60191
Models E1200 & E1201
Nacho & Popco n Display Cabinets
Manual
100 Volt, Single Phase, 50/60 Hz
120 Volt, Single Phase, 60 Hz
230 Volt, Single Phase, 50 Hz
READ and UNDERSTAND these operating and safety
instructions before operating this Cretors machine

Display Cabinet Manual
Revised 1.27.06
2
TABLE OF CONTENTS
. Safety Alert Symbol............................................................................................... 3
. Safety First .............................................................................................................. 3
. ntroduction............................................................................................................ 3
V. Purpose of Manual ................................................................................................ 4
V. Product dentification ........................................................................................... 4
V . Principles of Display Cabinet Operation ........................................................... 4
V . Control Switch ....................................................................................................... 4
V . nstallation nstructions ........................................................................................ 4
X. Operating nstructions .......................................................................................... 5
X. Sanitation nstructions .......................................................................................... 5
X . Service nstructions ............................................................................................... 6
Troubleshooting ..................................................................................................... 6

Display Cabinet Manual
Revised 1.27.06
3
I. SAFETY ALERT SYMBOL
The symbol shown is used to call your attention to instructions concerning your personal safety
and the safety of others. Watch for this symbol. t points out important safety precautions. t
means ATTENTION! Become Ale t! You pe sonal safety is involved! Read the message that
follows and be alert to the risk of personal injury or death.
II. SAFETY FIRST
The information in this manual is essential for the safe installation and
operation of your Cretors machine. The manual must be read and
understood before installing, and operating the equipment, or equivalent
training must be provided.
The employer shall instruct each employee in the recognition and avoidance
of unsafe conditions, as well as, the regulations applicable to his work
environment and to control or eliminate any hazards or other exposure to
illness or injury. Ref.: 29 CFR 1926.20 (b)(4)(a)(2)
t is understood that safety rules within individual companies vary. f a conflict
exists between the safety procedures contained in this manual and the rules of a
using company, the more stringent rule should take precedence.
III. INTRODUCTION
This manual is filled with time-saving and money-saving information regarding your Cretors
machine. There is nothing more important than the safety aids and warnings that are throughout
this document. The Safety Alert Symbol is used to identify topics of primary safety concern
wherever they appear.
f, after reviewing this manual, anything is unclear or technical problems are encountered, contact
the distributor from whom you purchased your machine for assistance. f there are any additional
questions, feel free to contact our Customer Service Department at the address and/or phone
number listed on the last page of this manual. Always have the model and serial number of your
machine available to assist in obtaining the correct information.

Display Cabinet Manual
Revised 1.27.06
4
IV. PURPOSE OF MANUAL
This instruction manual is intended to familiarize owners with the operation and safety
procedures associated with your Cretors machine.
t is important that this manual be kept available to operating personnel.
V. PRODUCT IDENTIFICATION
CRETORS POPCORN AND NACHO D SPLAY CAB NET
MODEL 1200/1200E – NACHO DISPLAY CABINET
1201/1201E – POPCORN DISPLAY CABINET
Electrical: 100 Volt, 50/60 Cycle, 0.6 Amp, 60 Watts
120 Volt, 60 Cycle, 0.7 Amp, 80 Watts
VI. PRINCIPLES OF DISPLAY CABINET OPERATION
Theo y and Obse vations of Display Cabinet Ope ation
The Nacho and Popcorn Display cabinets hold nacho chips and popcorn respectively. Load
product through a 6-inch by 8-inch opening on the cabinet top, equipped with a lip to prevent
spillage, and keep them warm through a 40-watt heating element in the unit base. Dispense
product through a large door on the unit’s front. The unit features a corrosion-resistant design
and tempered glass for easy cleaning; the surface will not scratch or discolor. The unit’s door is
easily removable for cleaning. Rubber feet prevent skidding on counter top surfaces.
VII. CONTROL SWITCH
MA N POWER SW TCH -Controls light and cabinet.
VIII. INSTALLATION INSTRUCTIONS
1. Location
Choose a location for your Cretors Display Cabinet to maximize the ease of operation and
maintenance procedures. Check your local building and fire codes for location restrictions.
2. Powe Supply
This Cretors machine is rated at 120 volts, 80 watts. Use a GROUNDED 120 VOLT
CIRCUIT WITH A 15 AMP BREAKER OR FUSE.

Display Cabinet Manual
Revised 1.27.06
5
Connect your cabinet only to the correct power source.
Make certain the main power switch on the cabinet is in the 'OFF' position when
plugging into power source.
IX. OPERATING INSTRUCTIONS
Do not attempt to oper
ate your Cretors Display Cabinet until you have read and
understood this manual. Failure to do so may result in serious injury or death.
Do not attempt to operate your Cretors machine unless the installation instructions
have been strictly adhered to. Failure to do so may result in serious injury or death.
Operate your display cabinet only if it is in sanitary condition (SAN TAT ON
NSTRUCT ONS). Failure to do so may result in illness to your customers.
1. Load unit with product up to bottom of top cap. Do not overfill the cabinet.
2. Fill from top through access opening only.
3. Dispense chips through the front door.
X. SANITATION INSTRUCTIONS
Be certain the machine is turned off and the power is unplugged before sanitizing this
machine, unless a specific cleaning procedure requires power to the machine. Failure
to do so could result in serious injury or death.
Do not clean heated surfaces until they have been given sufficient time to cool.
Failure to do so may result in serious burns or scalds.
Do not immerse the cabinet in water. This will damage the electrical components, and
may cause short circuits, resulting in an electrical shock hazard if power is applied.
1. After unit has been allowed to cool and has been unplugged, remove any excess
product remaining in the bottom.
2. Clean all surfaces with a non-abrasive food safe cleaner.
This appliance should not be cleaned with a water jet.

Display Cabinet Manual
Revised 1.27.06
6
XI. SERVICE INSTRUCTIONS
Only a qualified person should perform the following diagnostic checks, and, if
necessary, corresponding adjustments and repairs. Many of the following procedures
may present an electrical shock hazard and can cause serious injury or death.
Perform work only on de-energized circuits. Failure to do so may lead to electrical
shock resulting in personal injury or death.
A. Pa ts
When ordering parts, refer to the parts diagram included with this manual. Always supply
the serial number and model number of your machine.
B. Check Unit Pe iodically
Periodically check electrical switch and cord for signs of wear. Check all screws and rivets
for tightness.
C. To Access Elect ical Components
To access all electrical components, unplug power cord from outlet, and then lay unit on its
side and remove the four screws from the bottom cover, exposing heating element, switch,
and wiring. THIS UNIT IS NOT FUSED.
D. T oubleshooting
PROBLEM POSSIBLE CAUSE ACTION
Unit will not heat. Machine unplugged or not
switched on.
Plug unit in. Turn on power.
Loose connection to heater. Repair connection.
Light will not work. Machine unplugged or not
switched on.
Plug unit in. Turn on power.
Bulb burned out. Replace bulb with
recommended replacement
part (#EP2053)

Display Cabinet Manual
Revised 1.27.06
7
This manual is filled with timesaving and money-saving information regarding your Cretors
Display Cabinet. There is nothing, however, more important than the safety aids and warnings
found throughout this document.
f you have any questions, feel free to contact our Customer Service Department at 800-840-6166.
Additional copies of this manual can be obtained from Customer Service.
Cretors warranties this machine to be free of defects in parts, materials, and workmanship for two
year. Please complete and return the registration card to activate your warranty. f you have
questions concerning the warranty, please contact Customer Service at 800-840-6166.
CUSTOMER SERV CE HOURS:
Our office hours are 8:30 a.m. to 5 p.m. (U.S. Central Time) Monday through Friday. An answering
machine is in use all other times.
SH PP NG POL CY:
We make every effort to ship approved orders on the requested ship date. f a delay in shipment is
necessary, you will be notified. Pallet quantities vary by product. Please inquire when placing
order. Most of our products are shippable by UPS.
DAMAGE OR SHORTAGE POL CY:
We recommend that you do not sign the delivery receipt until after inspecting the product(s).
Claims can be filed if a shortage is observed, but only when it has been noted on the delivery
receipt.
RETURN POL CY:
Unless it is our error, we will charge a 20% restocking charge on product(s) returned. Contact us
for a return authorization form, and ship freight prepaid.
C. CRETORS AND COMPANY
176 MITTEL DRIVE
WOOD DALE, IL 60191
PHONE [phone], FAX [phone]
WEB SITE: http://www.cretors.com Email: [e-mail]