Dover DESTACO ROBOHAND DLB Series User manual

destaco.com
Automating Tomorrow™
WARNING: This is a controlled document. It is your responsibility to deliver this information to the end user of the
Destaco Robohand product. Failure to deliver this could result in your liability for injury to the user or damage to the
machine. For copies of this manual, call your Customer Service Representative at 1.248.836.6700
ROBOHAND
Service Manual
DLB Externally Powered Series

Dimensions and technical information are subject to change without notice
142
Linear Slides | Maintenance and Assembly Procedure
DLB-T, A, n, u Series
For more information call us at: 1-800-ROBOHAND or 203-261-5558 Fax: [phone] Visit us on the Internet at: www.destaco.com
4.36
DLB-T, A, N, R, U
SERIES
MAINTENANCE
Third Angle
Projection
Seal Kit
Items
Thread
Locker
Krytox™
Lubricant
Teflon®Based
Grease
Lightweight
Machine Oil
Super
Bonder
(4 BEARINGS)
(4 DOWEL PINS)
(4 SCREWS)
1
4
3
30
5
2
7
8
DLB-T, A, N, R, U Series Exploded View
Item Qty Name
01 1 Cylinder
02 1 Body, Internally Powered
03 2 Guide Shaft
04 2 End Block
05 1 Coupling,Externally Powered
07 4 Bushing
08 8 Shock Pad,Urethane
30 4 Dowel Pin
NOTE: Contact the Robohand Sales
Department for a complete spare parts
list with order numbers and prices.
Assembly Procedure
1) Press bearings into body, insert
shafts, and slide bumpers over each
shaft end.
2) Install external coupler to body with
retainer ring.
3) Mount end blocks onto shaft ends
and tighten.
4) Attach cylinder through end block and
external coupler.
5) Lock cylinder in place by tightening
set screws in the external coupler
and end block.
Seal Repair Kit Order #’s
See Product Data Sheets
SK
4.001-4.037RED.qxd 2/3/06 2:17 PM Page 36

Dimensions and technical information are subject to change without notice 143
Linear Slides | Maintenance and Assembly Procedure
DLB-T, A, n, u Series
For more information call us at: 1-800-ROBOHAND or 203-261-5558 Fax: [phone] Visit us on the Internet at: www.destaco.com
4.37
DLB-T, A, N, R, U
SERIES
MAINTENANCE
Third Angle
Projection
Seal Kit
Items
Thread
Locker
Krytox™
Lubricant
Teflon®Based
Grease
Lightweight
Machine Oil
Super
Bonder
DLB-T, A, N, R, U Series Assembled View
1
4
2
8
3
30
5
7
Item Qty Name
01 1 Cylinder
02 1 Body, Internally Powered
03 2 Guide Shaft
04 2 End Block
05 1 Coupling,Externally Powered
07 4 Bushing
08 8 Shock Pad,Urethane
30 4 Dowel Pin
NOTE: Contact the Robohand Sales
Department for a complete spare parts
list with order numbers and prices.
NOTE: For accessory mounting, see
product data sheets.
CYLINDER VALVE
Main
Supply
Auxiliary
Supply
LOCK VALVE
5 WAY, 3 POS
3 WAY, 2 POS
G1/8
EXHAUST PORT
LOCKING CYLINDER -R
PLUMBING DIAGRAM (external pilot)
(internal pilot)
Lock valve must be maintained
energized during cylinder motion,
otherwise lock is engaged and
cylinder valve shifts to mid position.
Cylinder valve must be maintained
energized during extend or retract.
Also, keep energized at end of stroke
until change of direction is desired.
Mid-position of 5/3 cylinder valve
may be pressurized outlets if the
combinaton of pressure load on the
cylinder and inertia effects of the
attached load do not exceed the
holding force rating of the locking
device, including allowance for wear.
DO NOT use cylinder lines for any
logic functions - pressure levels vary
too much.
1)
2)
3)
4)
4.001-4.037RED.qxd 2/3/06 2:17 PM Page 37

Global Locations
NORTH AMERICA
Corporate Headquarters
Auburn Hills, Michigan
Toll Free: 1.888.DESTACO
Marketing: [email protected]
Global Technology Center
Auburn Hills, Michigan
Tel: [phone]
Customer Service: [email protected]
Mt. Juliet, Tennessee
Tel: 1.888.DESTACO
Customer Service: [email protected]
Wheeling, Illinois
Tel: [phone]
Customer Service: [email protected]
Red Wing, Minnesota (Central Research Laboratories)
Tel: [phone]
Customer Service: [email protected]
ASIA
Bangkok, Thailand
Tel: [phone]
Customer Service: [email protected]
Shanghai, China
Tel: [phone]
Customer Service: [email protected]
Bangalore, India
Tel: [phone]
Customer Service: [email protected]
EUROPE
Oberursel, Germany
Tel: [phone]
Customer Service: [email protected]
Sainte Florine, France
Tel: [phone]
Customer Service: [email protected]
Wolverhampton, United Kingdom
Tel: [phone]
Customer Service: [email protected]
Sant Boi de LLobregat, Spain
Tel: [phone]
Customer Service: [email protected]
Uithoorn, Netherlands
Tel: [phone]
Customer Service: [email protected]
Spain
Netherlands
UK
France
India
Thailand
China
Mt. Juliet, TN USA
Auburn Hills, MI USA
Germany
Red Wing, MN USA
Wheeling, IL USA
© Copyright, 2019 DESTACO. All rights for layout, photos and text rest with the publisher
DESTACO. All photomechanical or other reproductions only with our express permission.
All sales are based on our terms and conditions of sale, delivery and payment. IN_SM-DLB-EXT_03/19