DXV Randall D35102980 User manual

- 1 -
INSTALLATION INSTRUCTIONS
Product names listed herein are trademarks of AS America, Inc.
© AS America, Inc. 2015
SAVE FOR FUTURE USE
RECOMMENDED TOOLS AND MATERIALS
Most of the procedures require the use of common tools and materials, which are available from hardware and plumbing
supply stores. It is essential that the tools and materials be on hand before work is begun.
M965523 Rev. 1.5 (4/17)
Cross Handle
Model D35102980
Randall®
Exposed Tub Filler
with Hand Shower
ROUGHING-IN DIMENSIONS:
• For reference
8-5/8"
(218 mm)
2-3/4" DIA.
(70 mm)
1/2" NPT
(13 mm)
MOUNTING HOLES
ARE 1/38" DIA. (35 mm)
2-7/8"
(72 mm)
7/8"
(23 mm)
5"
(126 mm)
2-7/8 "
(73 mm)
3-1/8"
(80 mm)
6"
(152 mm)
30°
3-1/2"
(89 mm)
9-5/8"
(244 mm)
Adjustable Wrench
Phillips Screwdriver
Sealing TapeLevel
Channel LocksTubing Cutter Flat Blade Screwdriver
In the United States:
DXV
One Centennial Avenue
Piscataway, New Jersey 08855
Attention: Director of Customer Care
For residents of the United States, warranty
information may also be obtained by calling
the following toll free number: [phone]
www.DXV.com
In Canada:
DXV
5900 Avebury Road
Mississauga, Ontario
L5R 3M3
Canada
Toll Free: 1-800-387-0369
Local: 905-306-1093
Fax: [phone]
www.DXV.ca
In Mexico:
DXV
Via Morelos 330
Col. Santa Clara Coatitla
Ecatepec, Estado de México 55540
Toll Free: 01-800-8391200
www.DXV.mx
Thank you for selecting DXV. To ensure that your
installation proceeds smoothly, please read these
instructions carefully before you begin.

- 2 - M965523 Rev. 1.5 (4/17)
1
2INSTALL ESCUTCHEONS
INSTALL ROUGH PIPING IMPORTANT NOTICE TO THE INSTALLER!
Please check with your local Code Authority for acceptable installation requirements for this
Roman Tub set with hand shower. Some local codes may require a vacuum breaker and/or
a pressure balanced mixing valve to be installed in conjunction with this product.
CAUTION Turn off hot and cold water
supplies before beginning.
1-5/8"
(41 mm)
1-5/8"
(16 mm)
CROSS BRACE
C/L
C/L
1/2" NPT
(13 mm)
FINISHED WALL OPTIONAL TO
FINISHED FLOOR
FINISHED
WALL
FINISHED
WALL
OFF-SET NIPPLE
PIPE
BRACE
6"
(152 mm)
COLD
HOT
1
2
2
1
C/L OF SUPPLIES (MIN).
C/L TO C/L OF
ADAPTER
C/L TO C/L OF
ADAPTER
C/L OF SUPPLIES (MAX.).
6"
(152 mm)
1/4" (6 mm) OFF-SET
5-1/2"
(140 mm)
Figure A.
Figure B.
Figure C.
6"
(152 mm)
6-1/2"
(165 mm)
6" ±1/2"
(152 ±13 mm)
• Determine where the nished wall location will be.
This measurement is very important!
Note: The rough-in measurement from the finished wall to
the end of the off-set nipple is 1-5/8” (41mm).
See rough-in illustration below. Figure A.
• The C/L of the supplies are 6", ±1/2". Figure B.
• Install a cross brace between the wall studs.
• Apply thread sealant or Teon Tape to threads of Hot and
Cold supplies connections. Assemble 1/2" (13 mm) NPT
SUPPLIES at 6" (152 mm) from center to center. Thread
ECCENTRICS (1) into roughed-in 1/2” SUPPLY
COUPLINGS (2). Center to center dimension of
ECCENTRICS (1) is 6" (152 mm). Figure C.
• Finish all wall construction.
6 "
(152mm)
1
2
• Thread ESCUTCHEONS (1) ush against nished wall.
Make sure ECCENTRICS (2) are level.

- 3 - M965523 Rev. 1.5 (4/17)
3INSTALL FAUCET
4
5
CONNECT HOSE AND SPRAY
TEST INSTALLED FAUCET
• Install SEAL WASHERS (1) into COUPLING NUTS (2).
• Thread COUPLING NUTS (2) onto ECCENTRICS (3) and tighten.
• Install SEAL WASHER (1) and connect smaller end of
HOSE (2) to Outlet Nipple on side of BRACKET (3).
• Install SEAL WASHER (4) to conical end of HOSE (5)
and attach HAND SPRAY (6).
• Fully tighten both connections.
• Turn VALVES to “off” position.
• With handles in “off” position, turn on water supplies
and check all connections for leaks.
• Remove HAND SHOWER (7) and operate both
handles to ush lines.
• Lift HAND SHOWER (7) from BRACKET (8) and direct spray
into tub. Remove HAND SHOWER (7) from HOSE (5).
Turn DIVERTER LEVER (9) to SHOWER and check
all connections for leaks. Replace HAND SHOWER (7)
onto HOSE (5).
1
2
3
1
7
8
3
2
4
6
5
9
BATH HAND
SHOWER
CAUTION The flow rate of this Tub Filler exceeds 20 gallons/minute
at higher water pressure. Do not fill bathtub unattended.

- 4 - M965523 Rev. 1.5 (4/17)
MODEL NUMBER
D35102980
Randall®
Exposed Tub Filler
with Hand Shower
H960317.XXX
HOSE AND SEALS
M964600-0070A
DIVERTER
CRANK ASSEMBLY
M970043-XXX0A
PLUG BUTTON &
SET SCREW
A860843.XXX
CROSS HANDLE KIT
M964598-YYY0A
HAND SPRAY
HOLDER
M964593-YYY0A
ESCUTCHEON
M964601-YYY0A
DIVERTER
HANDLE KIT
H960136.191
1/2" CARTRIDGE
(COLD)
H960104.191
1/2" CARTRIDGE
(HOT)
D35107781.XXX
HAND SHOWER
M964599-YYY0A
SHOWER BASE
ASSEMBLY
860682.XXX
HANDLE CAP
M964595-0070A
OFFSET ADAPTOR
Replace the “YYY” with
appropriate finish code
POLISHED CHROME 100
BRUSHED NICKEL 144
PLATINUM NICKEL 150
SATIN BRASS 427