Elkay EWTLA16*1E Series Installation manual

98246C (Rev. A - 6/08)
EWTLA16*1E,2E&3E
PAGE1
With FLEXI-GUARD®
Installation/Care/Use Manual
USES HFC-134A REFRIGERANT
FIG. 1
SEE FIG. 4 7
7
SEE FIG. 3
36
38
32, 39,
40
16, 17, 18,
19, & 20
37
SEE FIG. 4
SEE FIG. 3
14 31
21
35
26
15
27, 39,
40
30
13
33
22, 23,
24,25
29
41
34
42
42

98246C (Rev. A - 6/08)
EWTLA16*1E,2E&3E
PAGE2
FIG. 2
E = INSURE PROPER VENTILATION BY MAINTAINING 4" (102mm) (MIN.) CLEARANCE FROM CABINET LOUVERS TO WALL.
ASEGURE UNAVENTILACIÓNADECUADA MANTENIENDO UN ESPACIO E 4" (102mm) (MÍN.) DE HOLGURAENTRE LA REJILLA DE VENTILACIÓN DEL MUEBLE Y LA PARED ASSUREZ-VOUS UNE BONNE VENTILATION EN GARDANT 4" (102mm) (MIN.) ENTRE LES ÉVENTS DE L’ENCEINTE ET LE MUR.
F = POWER CORD 4 FEET (1219mm) LONG
CABLE ELÉCTRICO DE 4 PIE (1219mm), DE LARGO CORDOND’ALIMENTATION 4' (1219mm)
G = ALT. ELECTRICAL OUTLET LOCATION
UBICACIÓN ALT. DE LA TOMA DE ELECTRICIDAD EMPLACEMENT ALTERNATIF DE LA PRISE DE COURANT
FINISHED FLOOR PISO ACABADO PLANCHER FINI
LEGEND/LEYENDA/LÉGENDE A= RECOMMENDED WATER SUPPLY LOCATION 3/8 O.D. UNPLATED COPPER TUBE CONNECT STUB OUT 1-1/2 IN. (38mm)
FROM WALL SHUT OFF BY OTHERS
SE RECOMIENDAUBICAR EL TUBO CORTO DE CONEXIÓN ALTUBO DE COBRE SIN CHAPAR DE 3/8" DE DIÁM. EXT. A1-1/2"
(38mm)FUERADELALLAVE DE PASOEN LAPARED COLOCADAPOR TERCEROS.
EMPLACEMENT RECOMMANDÉ D'ALIMENTATION EN EAU PAR TUBE EN CUIVRE NON PLAQUÉ DE 3/8 PO. (9,5 mm) D.E.
CONNECTANT UNE TUYAUTERIE DE 1-1/2 PO. (38 mm) DEPUIS LE ROBINET D'ARRÊT FOURNI PAR D'AUTRES.
B = RECOMMENDED LOCATION FOR WASTE OUTLET 1-1/4” O.D. DRAIN
UBICACIÓN RECOMENDADAPARA ELDRENAJE DE SALIDADEAGUA, DE 1¼” DE DIÁMETRO. EMPLACEMENTRECOMMANDÉPOURLE DRAIN DE D.E. 1-1/4" DE SORTIE D’EAU.
C = 1-1/4 TRAP NOT FURNISHED
PURGADORDE1¼ NO PROPORCIONADO SIPHON1-1/4NONFOURNI
D = ELECTRICAL OUTLET LOCATION
UBICACIÓNDELATOMADEELECTRICIDAD EMPLACEMENTDELAPRISEDECOURANT

98246C (Rev. A - 6/08)
EWTLA16*1E,2E&3E
PAGE3
FIG. 3 FIG. 4
NOTE:
WHENINSTALLINGREPLACEMENTBUBBLER
ANDPEDESTAL, TIGHTEN NUT (ITEM 12) ONLY
TO HOLD PARTS SNUG IN POSITION.
DONOT OVER TIGHTEN.
BASIN
9
10
11
12
8
Stream height is factory set at 35 PSI. If supply
pressurevariesgreatly from this,removeItems
1 & 2 and adjust screw on
Item 4. Clockwise adjustment will raise stream
andcounter-clockwise adjustment willlower
stream. For best adjustment, stream should hit
basinapproximately6-1/2" (165mm) from
bubbler.
BASIN
4
3
1
5
6
2
When provided
1
6
7
2
43
5
ITEM NO.
Filter Head Ass’y
Screw #8-18 X .75 PH
Fitting - Superseal 3/8” (10mm)
Fitting - Superseal 1/4” (6mm)
Filter Ass’y
Elbow - 3/8” (10mm)
Bracket
1
2
3
4
5
6
7
51294C
70792C
70823C
70822C
51299C
70818C
22490C
DESCRIPTION
PART
NO.
WATERSENTRY®FILTER PARTSLIST
FIG. 5

98246C (Rev. A - 6/08)
EWTLA16*1E,2E&3E
PAGE4
REPAIR SERVICE INFORMATION TOLL FREE NUMBER 1.800.260.6640
FOR PARTS, CONTACT YOUR LOCAL DISTRIBUTOR OR CALL 1.800.323.0620
ELKAY MANUFACTURING COMPANY • 2222 CAMDEN COURT • OAK BROOK, IL 60523 • 630.574.8484
PRINTED IN U.S.A.
PARTS LIST 115V
ITEM NO. PARTNO.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22*
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
40089C
40048C
15005C
61313C
40169C
50986C
20776C
20713C
56073C
40322C
56011C
55997C
75580C
31513C
36208C
66417C
21516C
31491C
30664C
20239C
70018C
66203C
35744C
36222C
36221C
35768C
55996C
45693C
66256C
66506C
70682C
40022C
40088C
See Color Table
See Color Table
See Color Table
See Color Table
See Color Table
See Color Table
50005C
70016C
70683C
56092C
100322740560
15009C
Cover
Button
Regulator Retaining Nut
Regulator
Hex Nut
RegulatorHolder
Basin
Basin (GF Only)
Bubbler Assy
Orifice Assy
Housing Assy
Pedestal
Bubbler Locknut
Cold Control
PowerCord
Condenser
FanShroud
FanMotor
Fan Blade
Fan Bracket
Fan Blade Nut
Drier
Compressor Serv. Pak
Overload
Relay
Relay Cover
Strainer
Precooler
Heat Exchanger
Evaporator
Fitting - Tee
Waste Connection Assy
Assy - Tailpipe
Panel-Left Side (Right Unit)
Panel-Right Side (Right Unit)
Panel-Front (Right Unit)
Panel-Left Side (Left Unit)
Panel-Right Side (Left Unit)
Panel-Front (Left Unit)
Gasket - Tailpipe
Nut - Hex
Fitting - Union
Poly. Tubing (Cut To Length)
Gasket (GF)
Nipple - Bubbler (GF Only)
DESCRIPTION
*INCLUDES RELAY & OVERLOAD. IF UNDER WARRANTY,
REPLACE WITH SAME COMPRESSOR USED IN ORIGINAL
ASSEMBLY.
NOTE: All correspondence pertaining to any of the above
water coolers or orders for repair parts MUST include Model
No. and Serial No. of cooler, name and part number of replace-
ment part.
Item No. 33
Part No.
COLORTABLE
Gray Beige
Almond
Stainless Stl
Sandalwood
Granite
Light Gray
20639C
21465C
20641C
21463C
27174C
27175C
20675C
20676C
20672C
21454C
27150C
21455C
PANEL
COLOR Item No. 34
Part No.
Item No. 36
Part No. Item No. 37 Part No.
Item No. 35
Part No.
20646C
21468C
20648C
21466C
27177C
27178C
20736C
21479C
20737C
21478C
27189C
27190C
Item No. 38
Part No.
20684C
20685C
20681C
21456C
27153C
27154C
20732C
21477C
20733C
21476C
27186C
27187C
Gray Beige
Almond
Stainless Stl
Sandalwood
Granite
Light Gray
PANEL
COLOR
COLORTABLE
43
44
Glass Filler Shown
for Reference Only
FIG. 6
36024C
31431C
35776C
35875C
35864C
30181C
30182C
35826C
14
17
22*
23
24
NS
PowerCord
FanMotor
Compressor Serv. Pak
Overload
Relay
Terminal Cover
Bale Strap
Power Inlet
PART. NO. DESCRIPTIONITEMNO.
220V/50Hz
36024C
31431C
35856C
35953C
35954C
35826C
14
17
22*
23
23
NS
PowerCord
FanMotor
Compressor Serv. Pak
Overload
Relay
Power Inlet
PART. NO. DESCRIPTIONITEMNO. 230V/60Hz