Fisher-Price POWER WHEELS H7455 Operation manual

For a Power Wheels®12-volt system with two
6-volt lead acid batteries.
This product is not intended for children; it is for adult use only.
This charger is not a toy.
Please read this booklet before first-time use.
Keep these instructions for future reference,
as they contain important information.
H7455
12 Volt Quick Charger
Product features may vary from the picture above.

DANGER
To prevent electric shock, do not immerse
in water; wipe clean with a damp cloth.
CAUTION
Use the charger in dry locations only.
WARNING
Use of the wrong type battery or charger could
cause a fire/explosion resulting in serious injury.
IMPORTANT INFORMATION
2

• IMPORTANT! Batteries can be severly damaged if they are not charged
after each use. For maximum battery life, charge batteries 100% (solid
green) every other charge.
• If your batteries are new, charge batteries 100% (solid green).
• Do not charge the batteries longer than 30 hours.
• Adults Note: Regularly examine the charger for damage to the cord, plug,
housing or other parts that may result in the risk of fire, electric shock or
injury. In the event of any damage, do not use the charger until the damage
has been properly repaired. Please call 1-800-348-0751.
• Before charging the batteries, examine battery cases for cracks and other
damage which may cause sulfuric acid (electrolyte) to leak during the
charging process. If damage is detected, do not charge the batteries or use
them in your vehicle. Battery acid is very corrosive and can cause severe
damage to the surfaces it contacts.
• Do not charge the batteries on a surface (such as a kitchen counter top)
which could be damaged by the acid contained inside a battery. Take
precautions to protect the surface on which you charge the batteries.
• Do not short circuit the batteries.
• The batteries must be upright while charging.
• Disconnect the charger before cleaning.
• Charger specifications are as follows:
Input 100-240 V AC 50/60Hz 50W
Output 12V DC 2.5A
IMPORTANT INFORMATION
3

WARNING
• PREVENT FIRE
- Use of the wrong type batteries or charger
could cause a fire or explosion resulting in
serious injury.
- Use of Power Wheels
®
components in
products other than Power Wheels
®
vehicles
could cause overheating, fire or explosion.
• The batteries must be handled by adults only.
The batteries are heavy and contain sulfuric
acid (electrolyte). Dropping the batteries could
result in serious injury.
• Never allow children to charge the batteries.
Battery charging must be done by adults only.
A child could be injured by the electricity
involved in charging the batteries.
• Read the safety instructions on the batteries.
• Examine the batteries, charger and their
connectors for excessive wear or damage
each time you charge the batteries. If damage
or excessive wear is detected, do not use
the charger or the batteries until you have
replaced the worn or damaged part.
4
IMPORTANT INFORMATION

CHARGING INSTRUCTIONS
5
Approximate
Status Charge Time
Solid Red Charging --
Flashing Green Ready for Use 2 hours
Solid Green 100% (Full)*6-8 hours
Flashing Red No Charge** --
*For maximum battery life, charge batteries 100% (solid green) every
other charge.
**Error - wrong or dead batteries.

• Join the charger connectors and the 6-volt battery connectors.
• Plug the power cord into the charger.
• Plug the 6-volt battery connectors into the charger connectors.
• Plug the power cord into a standard 120 volt wall outlet.
Note: The charger may be hot to the touch while charging. New batteries
may make a “sizzling” or “bubbling” noise and swell slightly. These are normal
conditions and do not indicate a problem.
• Charge the batteries 100% (solid green) or Ready for Use (flashing green). For
maximum battery life, charge batteries 100% (solid green) every other charge.
• Unplug the charger from the wall outlet when not in use.
6 Volt
Batteries
Power Cord
Charger Connectors
Battery Connectors
Charger
Wall Outlet
Power Cord
CHARGING INSTRUCTIONS
6
PRINTED IN CHINA H7455b-0920

No status light No power Make sure power flow to the wall outlet
to charger is “ON”.
Loose connections Check connections of all plugs. Make
sure the battery connectors are tightly
plugged into the charger connectors
and the power cord connector is tightly
plugged into both the charger and the
wall outlet.
Bad charger There is no sure way to tell if your
charger is working unless you have a
volt meter. If you suspect there is a
problem with your charger, contact
Power Wheels®Consumer Relations.
Wrong batteries This charger is intended for use only
with a Power Wheels®12-volt system
with two 6-volt lead acid batteries.
Flashing red Loose connections Check connections of all plugs. Make
status light sure the battery connectors are tightly
plugged into the charger connectors
and the power cord connector is tightly
plugged into both the charger and the
wall outlet.
Undercharged Batteries need a 100% (solid green)
batteries charge every other use.
Batteries dead Replace the batteries with a new,
Power Wheels®12-volt system with
two 6-volt lead acid batteries.
Solid red Undercharged Charge batteries 100% (solid green) or
status light batteries Ready for Use (flashing green).
Problem Possible Cause Solution
PROBLEMS AND SOLUTIONS
7

Problem Possible Cause Solution
Batteries are Normal while No action required.
warm while quick charging
charging
Charger is hot Normal while No action required.
while charging quick charging
Short vehicle run Undercharged Charge batteries 100% (solid green) or
time or vehicle batteries Ready for Use (flashing green).
runs sluggishly
Flashing green Batteries dead In rare situations, severely depleted
status light - (dead) batteries will give a false,
but vehicle does Ready for Use (flashing green) status.
not run Try charging the batteries again for 6-8
hours. If your vehicle still won’t run, you
will need to replace your batteries with a
new, Power Wheels®12-volt system with
two 6-volt lead acid batteries.
Solid green Batteries dead In rare situations, severely depleted
status light - (dead) batteries will give a false,
but vehicle does 100% (solid green) status. Try charging
not run the batteries for a full 6-8 hours. If your
vehicle still won’t run, you will need to
replace your battery with a new,
Power Wheels®12-volt system with
two 6-volt lead acid batteries.
Flashing green Batteries may be Unplug the charger from the batteries
status light does dead and wall outlet for at least 12 hours. Now,
not progress to charge the batteries again for 6-8 hours.
a solid green If the status flashes red or you see the
status light after same results, replace the batteries with a
6-8 hours of new, Power Wheels®12-volt system with
charging and two 6-volt lead acid batteries.
vehicle does
not run
PROBLEMS AND SOLUTIONS
8

(United States Only)
This equipment has been tested and found to comply with the limits for a
Class B digital device, pursuant to part 15 of the FCC rules. These limits
are designed to provide reasonable protection against harmful interference
in a residential installation. This equipment generates, uses and can radiate
radio frequency energy and, if not installed and used in accordance with
the instructions, may cause harmful interference to radio communications.
However, there is no guarantee that interference will not occur in a particular
installation. If this equipment does cause harmful interference to radio or
television reception, which can be determined by turning the equipment off and
on, the user is encouraged to try to correct the interference by one or more of
the following measures:
Reorient or relocate the receiving antenna.
Increase the separation between the equipment and receiver.
Connect the equipment into an outlet on a circuit different from that to which
the receiver is connected.
Consult the dealer or an experienced radio/TV technician for help.
Note: Changes or modifications not expressly approved by the
manufacturer responsible for compliance could void the user's authority to
operate the equipment.
FCC STATEMENT
9

Fisher-Price, Inc., a subsidiary of Mattel, Inc., East Aurora, New York 14052 U.S.A.
©2005 Mattel, Inc. All Rights Reserved. ® and ™ designate U.S. trademarks of Mattel, Inc.
www.powerwheels.com
If you have any questions about this product, please call our
toll-free service lines at 1-800-348-0751 from 8 AM to 6 PM (EST)
Monday through Friday. You can also visit us on-line at www.
powerwheels.com.
For your convenience, Power Wheels®maintains an independently
owned and operated Authorized Service Center Network with more
than 400 authorized service centers nationwide. The authorized
service centers will repair or replace parts under warranty at no extra
charge, and can perform non-warranty repairs for a minimal charge.
To find the authorized service center nearest to you, visit us on-line
at www.powerwheels.com or call 1-800-348-0751.
CUSTOMER SERVICE
10