Fisher-Price POWER WHEELS H7455 User manual

For a Power Wheels®12-volt system with two 6-volt batteries.
This product is not intended for children; it is for adult use only.
This charger is not a toy.
Please read this booklet before first-time use.
Keep these instructions for future reference,
as they contain important information.
H7455
12 Volt Quick Charger
Product features may vary from the picture above.

DANGER
To prevent electric shock, do not immerse
in water; wipe clean with a damp cloth.
CAUTION
Use the charger in dry locations only.
WARNING
Use of the wrong type battery or charger could
cause a fire/explosion resulting in serious injury.
IMPORTANT INFORMATION
2

•IMPORTANT! Batteries can be severly damaged if they are not charged
after each use. Charge the batteries either 2 hours (80%) or 6-8 hours
(100%). Make sure the batteries are fully charged (6-8 hours) every
other use.
•Adults Note: Regularly examine the charger for damage to the cord, plug,
housing or other parts that may result in the risk of fire, electric shock or
injury. In the event of any damage, do not use the charger until the damage
has been properly repaired. Please call 1-800-348-0751.
• Before charging the batteries, examine battery cases for cracks and other
damage which may cause sulfuric acid (electrolyte) to leak during the
charging process. If damage is detected, do not charge the battery(ies) or
use it (them) in your vehicle. Battery acid is very corrosive and can cause
severe damage to the surfaces it contacts.
• Do not charge the batteries on a surface (such as a kitchen counter top)
which could be damaged by the acid contained inside a battery. Take
precautions to protect the surface on which you charge the batteries.
• Do not short circuit the batteries.
• The batteries must be upright while charging.
• Disconnect the charger before cleaning.
• Charger specifications are as follows:
Input 100-240 V AC 50/60Hz 50W
Output 12V DC 2.5A
IMPORTANT INFORMATION
3

WARNING
•PREVENT FIRE
- Use of the wrong type battery or charger
could cause a fire or explosion resulting in
serious injury.
- Use of Power Wheels®components in
products other than Power Wheels®vehicles
could cause overheating, fire or explosion.
• The battery must be handled by adults only.
The battery is heavy and contains sulfuric
acid (electrolyte). Dropping the battery could
result in serious injury.
• Never allow children to charge the battery.
Battery charging must be done by adults only.
A child could be injured by the electricity
involved in charging the battery.
• Read the safety instructions on the battery.
• Examine the battery, charger and their
connectors for excessive wear or damage
each time you charge the battery. If damage
or excessive wear is detected, do not use the
charger or the battery until you have replaced
the worn or damaged part.
4
QUICK CHARGE

QUICK CHARGE
5
Charge Ready Approximate
Indicator Status for Use Time
Solid Red Charging No --
Flashing Green 80% Yes*2 hours
Solid Green 100% Yes 6-8 hours
Flashing Red No Charge No** --
*2-hour quick charge energizes batteries to 80% capacity. For
maximum battery life, 100% battery charge is recommended
every other charge.
**Error - wrong or dead batteries.

• Join the charger connectors and the 6 volt battery connectors.
• Plug the power cord into the charger.
• Plug the 6 volt battery connectors into the charger connectors.
• Plug the power cord into a standard 120 volt wall outlet.
Note: The charger may be hot to the touch while charging. New batteries may
make a “sizzling” or “bubbling” noise and swell slightly. These are normal
conditions and do not indicate a problem.
• Charge the batteries either 2 hours (80%) or 6-8 hours (100%). Be sure to fully
charge (100%, 6-8 hours) every other use. For example, 1st charge is 2 hours
(80%); 2nd charge is 6-8 hours (100%); 3rd charge is 2 hours (80%);
4th charge is 6-8 hours (100%), etc.
6 Volt
Batteries
Charger
Power Cord
Charger Connectors
Battery Connectors
Wall Outlet
Power Cord
QUICK CHARGE
6
PRINTED IN CHINA H7455pr-0920

No indicator light No power Make sure power flow to the wall outlet
to charger is “ON”.
Loose connections Check connections of all plugs. Make
sure the battery connectors are tightly
plugged into the charger connectors and
the power cord connector is tightly
plugged into both the charger and the
wall outlet.
Bad charger There is no sure way to tell if your
charger is working unless you have a
volt meter. If you suspect there is a
problem with your charger, contact
Power Wheels®Consumer Relations.
Wrong batteries This charger is intended for use only
with a Power Wheels®12-volt system
with two 6-volt batteries.
Flashing red Loose connections Check connection of all plugs. Make sure
indicator light the battery connectors are tightly
plugged into the charger connectors and
the power cord connector is tightly
plugged into both the charger and the
wall outlet.
Undercharged Batteries need a full (100%) charge
batteries (6-8 hours) every other use.
Batteries dead Replace the batteries with a new,
Power Wheels®12-volt system with two
6-volt batteries.
Problem Possible Cause Solution
PROBLEMS AND SOLUTIONS
7

Problem Possible Cause Solution
Solid red Undercharged It will take 2 hours for an 80% minimum
indicator light batteries charge; 6-8 hours for a 100% full charge.
Batteries are Normal while No action required.
warm while quick charging
charging
Charger is hot Normal while No action required.
while charging quick charging
Short vehicle run Undercharged It will take 2 hours for an 80% minimum
time or vehicle batteries charge; 6-8 hours for a 100% full charge.
runs sluggishly
Flashing green Batteries dead In rare situations, severely depleted
indicator light - (dead) batteries will give a false, fully
but vehicle does charged indicator (flashing green
not run indicator light). Try charging the batteries
again for 6-8 hours. If your vehicle still
won’t run, you will need to replace your
batteries with a new, Power Wheels®
12-volt system with two 6-volt batteries.
Solid green Batteries dead In rare situations, severely depleted
indicator light - (dead) batteries will give a false,
but vehicle does minimally charged indicator (solid green
not run indicator light). Try charging the batteries
for a full 6-8 hours. If your vehicle still
won’t run, you will need to replace your
battery with a new, Power Wheels®
12-volt system with two 6-volt batteries.
PROBLEMS AND SOLUTIONS
8

This equipment has been tested and found to comply with the limits for a
Class B digital device, pursuant to part 15 of the FCC rules. These limits are
designed to provide reasonable protection against harmful interference in a
residential installation. This equipment generates, uses and can radiate radio
frequency energy and, if not installed and used in accordance with the
instructions, may cause harmful interference to radio communications.
However, there is no guarantee that interference will not occur in a particular
installation. If this equipment does cause harmful interference to radio or
television reception, which can be determined by turning the equipment off
and on, the user is encouraged to try to correct the interference by one or
more of the following measures:
Reorient or relocate the receiving antenna.
Increase the separation between the equipment and receiver.
Connect the equipment into an outlet on a circuit different from that to which
the receiver is connected.
Consult the dealer or an experienced radio/TV technician for help.
NOTE: Changes or modifications not expressly approved by the
manufacturer responsible for compliance could void the user's authority to
operate the equipment.
FCC STATEMENT
(UNITED STATES ONLY)
9

Fisher-Price, Inc., a subsidiary of Mattel, Inc., East Aurora, New York 14052 U.S.A.
©2005 Mattel, Inc. All Rights Reserved. ® and ™ designate U.S. trademarks of Mattel, Inc.
www.powerwheels.com
If you have any questions about this product, please call our
toll-free service lines at 1-800-348-0751 from 8 AM to 6 PM (EST)
Monday through Friday. You can also visit us on-line at
www.powerwheels.com.
For your convenience, Power Wheels®maintains an independently
owned and operated Authorized Service Center Network with more
than 400 authorized service centers nationwide. The authorized
service centers will repair or replace parts under warranty at no extra
charge, and can perform non-warranty repairs for a minimal charge.
To find the authorized service center nearest to you, visit us on-line
at www.powerwheels.com or call 1-800-348-0751.
CUSTOMER SERVICE
10