Golden Technologies Companion I GC240 User manual

Owner’s Manual
Companion II, 4-wheel
Companion II, 3-wheel
Companion I
Golden Technologies · 401 Bridge Street · Old Forge, PA · Tel: [phone] · Fax: [phone] · www.goldentech.com

Thank you for purchasing your Companion Scooter. We are honored you have chosen
Golden Technologies for your mobility needs. Please note, unless otherwise specified, the
term Companion refers to each of the models listed below:
Companion I — 3 wheel scooter
GC240 — 300 lb. load capacity
Companion II – 3 wheel scooters
GC340 – 350 lb. load capacity
Companion II – 4 wheel scooters
GC440 – 350 lb. load capacity
Standard Packing List:
1 Owner’s Manual
1 Consumer Instructional DVD
2 Battery Cables with Hardware
1 Front Basket
1 Seat with Arms
2 Keys
Charger
Seat Post Nut and Bolt
DISCLAIMER
We ask that you read this manual completely before operating your new Companion.
Golden Technologies, Inc. is not and cannot be held responsible for any damage or
injury incurred due to improper or unsafe use of the Golden Companion scooter.
Golden Technologies, Inc. specifically disclaims responsibility for any bodily injury or
property damage that may occur during any use that does not comply with applicable
federal, state, or local laws or ordinances.

Companion Owner's Manual: GC240, GC340, GC440
Companion 3
I. INTRODUCTION................................................................................................................... 4
Features and Benefits ................................................................................................................. 5
Accessories for the Companion Scooter...................................................................................... 6
II. SAFETY ............................................................................................................................... 7
III. EMI/RFI ............................................................................................................................ 11
IV. YOUR GOLDEN COMPANION ...................................................................................... 12
Specifications .......................................................................................................................... 13
V. OPERATION ..................................................................................................................... 14
Controls ................................................................................................................................... 14
Control Options ...................................................................................................................... 16
Seating Controls ...................................................................................................................... 16
Freewheel Mode....................................................................................................................... 18
VI. RIDING YOUR COMPANION ........................................................................................ 19
Mounting ................................................................................................................................. 19
Basic Driving ......................................................................................................................... 19
Steering in Tight Spots ............................................................................................................ 20
VII. DISASSEMBLY .............................................................................................................. 22
VIII. ASSEMBLY ................................................................................................................... 24
IX. TRANSPORTING YOUR COMPANION ........................................................................ 26
X. CARE AND MAINTENANCE .......................................................................................... 27
Routine Maintenance................................................................................................................ 27
Cleaning Your Companion....................................................................................................... 27
Batteries and Charging ............................................................................................................. 28
If Your Companion Does Not Operate...................................................................................... 29
Diagnostics............................................................................................................................... 30
XI. WARRANTY .................................................................................................................... 33
Registration Card ..................................................................................................................... 35
CONTENTS

Companion Owner's Manual: GC240, GC340, GC440
Companion 4
Congratulations on the purchase of your new Golden Companion scooter. The Companion,
the Companion II, and the four-wheel Companion II all combine cutting edge technology
with attractive designs that are also highly functional in today’s world. We at Golden
Technologies, Inc. know that you have chosen a scooter that will give you years of
dependable operation and also will enhance the quality of your life by providing you with the
mobility to experience an active daily life-style.
Even though your new Companion is both user-friendly and designed for maximum
maneuverability in even the tightest spaces, we ask that you please read, understand and
follow all of the instructions and suggestions in this manual before you operate your
Companion for the first time. The safe use of your new scooter is very important to us.
If you feel that you do not understand the instructions and suggestions presented in this
owner’s manual, or if, for any reason, you do not feel capable of performing the activities
necessary to assemble, disassemble, operate, or maintain your Companion, please contact
your local Golden Technologies, Inc. representative or call Golden Technologies, Inc.
Technical Support Services at [phone].
Golden Technologies, Inc. cannot be held responsible for personal injury or property damage
resulting from the unsafe or the improper use of any of our broad range of health and
personal mobility products. Also, Golden Technologies, Inc. cannot be held responsible for
personal injury or property damage resulting from attempts to follow instructions,
suggestions, and guidelines presented in this owner’s manual.
Our Research and Development Department, our Quality Control Department, and our
Engineering Department have used the latest product specifications and the latest product
design information to produce this owner’s manual. Golden Technologies, Inc. reserves the
right to implement changes into our product lines when those changes become desirable or
necessary. If changes are implemented into our product line, there may be minor differences
between the product you purchased and the illustrations and instructions in this owner’s
manual.
Please fill out and mail the enclosed warranty registration card. We at Golden Technologies,
Inc. would appreciate hearing about the dependability of your Companion and about the
convenience of mobility it has provided for you. We would also appreciate hearing about the
service you received from your local Golden Technologies, Inc. dealer or representative.
Golden Technologies, Inc. Phone: [phone]
401 Bridge Street Fax: [phone]
Old Forge, PA 18518 Toll free: [phone]
For more information about our products and services or to send us your comments, please
visit our website at www.goldentech.com
I. INTRODUCTION

Companion Owner's Manual: GC240, GC340, GC440
Companion 5
Features and Benefits
Your Golden Companion scooter shipping carton contains an informational DVD that high-
lights the features and benefits of your Companion scooter as well as important safety and
operating instructions. Please view this video and read the Owner's Manual in its entirety
for complete safety and operating instructions.
Control Panel: Easy to read
display features backlit battery
gauge; two horn buttons; the
key switch; and the red button
that turns the headlight and tail-
lights on and off.
Delta Tiller handle: Offers
cushioned hand rests for
comfort and dual throttle con-
trol levers for easy right or
left hand use.
Tiller: Easy to use tiller
offers infinite adjustment
with its angle adjustment
lever and can be adjusted
without bending over.
Automatic Tiller Lock: The tiller
will automatically lock when
folded down completely so that it
does not swing from side to side
during transport.
Off-board charger: The charger
port is located conveniently on the
tiller behind a protective cover.
Seat Swivel: A standard feature,
every Companion scooter seat can
swivel to the left or right for easy trans-
fers or to sit more comfortably at a ta-
ble or desk.
Seat Lift (optional): Your Com-
panion scooter may be equipped
with the seat lift, which will raise
your seat up to 5”. The switch for
the seat lift is conveniently lo-
cated on the tiller.
Slide Seat Mechanism: A standard fea-
ture, every Companion scooter features a
mechanism that allows the seat to slide
forward or backward for easier access to
the tiller and control panel and comfort.
Adjustable Armrests: Your Com-
panion scooter features width, height
and angle adjustable armrests to find
the most comfortable position as well
as to make transfers easier.
Headlights (and tail lights): A
standard feature, the headlights
and taillights feature bright, long-
lasting LED bulbs. The headlight
is angle-adjustable.
Tires: Every Compan-
ion scooter comes with
non-marking, non-
scuffing tires.
Tie-Downs: The tie-downs are important for
transportation. Two (2) tie downs are located
on the front of the scooter, on each side of
the front tire, and two (2) are located at the
rear of the scooter on each side of the anti-tip
wheels. See “IX. TRANSPORTING YOUR
COMPANION.”
I. INTRODUCTION
FIGURE 1. COMPANION II

Companion Owner's Manual: GC240, GC340, GC440
Companion 6
Accessories for the Companion Scooters
A variety of accessories are available for your Golden Companion Scooter*. Please contact
your Authorized Golden Technologies' Dealer for more information.
• Amputee Leg Supports
• Cane Holder Tube
• Cup Holder
• Deluxe Pack N' Go
• Forearm Crutch Holder
• Mirror
• Oxygen Tank Holder
• Quad Cane Holder
• Rear Basket
• Safety Flag
• Scooter Cover
• Touch-up Paint
• Walker Holder
*Some accessories require a mounting bracket or mounting clips. Please check with your
dealer to find out if the accessory you would like to order requires a mounting bracket or
mounting clip.
I. INTRODUCTION

Companion Owner's Manual: GC240, GC340, GC440
Companion 7
Your Golden Companion is a battery-operated personal mobility vehicle. Please exercise
caution and consideration when you are operating it. Driving your Companion carefully and
thoughtfully will help ensure your personal safety and the safety of other people.
NOTE: Before learning to operate your Companion, have your authorized Golden
Technologies, Inc. dealer determine if it is advisable for you to practice getting on and off
your Companion and operating it in the presence of an attendant.
BEFORE GETTING ON YOUR COMPANION
• Check to be certain that the power is turned off. See section V. “Operation” in this
manual. This will eliminate the possibility of accidentally activating the paddle controls
and causing injury to yourself or to others.
• Check to be certain that your Companion’s brake handle is in the engaged position. See
section VII. “Disassembly” in this manual.
• Flip up the armrests.
WARNING: When getting on or off your Companion, keep your weight toward the mid-
dle of the deck. Putting most or all of your weight on the edge of the deck may cause
an unstable condition.
GETTING ON YOUR COMPANION
• Position the seat for safe and easy mounting. See section V. “Operation.”
• Return tiller to full upright position
• Carefully place one foot on the approximate center of the deck and seat yourself
comfortably and securely on the seat.
• Fasten the lap belt, if your scooter is so equipped.
• Flip down or replace the armrests.
GETTING OFF YOUR COMPANION
• Make certain that the power is turned off and the key is removed.
• Return tiller to full upright position
• Flip up or remove the armrests.
• Unfasten the lap belt.
• Carefully place one foot on the ground, transfer your weight to that leg, and slowly come
to a standing position.
• Step away from the scooter.
MAXIMUM WEIGHT
Your Companion has been rated to a maximum payload (operator and anything else being
carried on the Companion) of 300 pounds for the Companion I and 350 pounds for the
Companion II. Exceeding the maximum weight rating will void the warranty.
WARNING: Exceeding the maximum weight rating may result in injury to yourself and
to others.
II. SAFETY

Companion Owner's Manual: GC240, GC340, GC440
Companion 8
DRIVING ON INCLINES
• For maximum stability, lean forward in your Companion’s seat while proceeding up
ramps, inclines, curbs, or any low rise. See figure 1.
• Drive with caution when attempting to negotiate any incline, even handicap access
ramps.
• Always climb or descend an incline by driving straight up or straight down the face of
the slope. See figure 2.
• Do not traverse or drive across the face of an incline in any direction. See figure 3.
• Do not attempt to negotiate an incline that is covered with snow, ice, cut or wet grass,
leaves, or any other potentially hazardous material.
• Do not back down an incline.
• Try to keep your Companion moving when climbing an incline. If you do come to a stop,
restart and accelerate slowly and carefully.
• Do not try to descend or climb a slope whose gradient is greater than recommended.*
WARNING: If, while you are driving down a slope, your scooter starts to move faster than you
feel is safe, release the throttle control lever and allow your Companion to come to a stop. When
you feel that you again have control of your scooter, push the throttle control lever forward and
continue safely down the remainder of the slope.
DRIVING DOWN A DECLINE
• Lower speed setting
• Whenever it is safely possible, drive forward down any ramp, low rise, or incline.
Golden Technologies, Inc. does not recommend that you drive your scooter in reverse down
any incline, ramp, curb, or low rise. Backing down any slope may create a very hazardous
situation.
FIGURE 2. GOING UP AN INCLINE FIGURE 3. TRAVERSING AN INCLINE
II. SAFETY
*Maximum recommended incline is 8°

Companion Owner's Manual: GC240, GC340, GC440
Companion 9
If it is necessary to back down a slope follow one of two procedures.
NOTE: When using either of the following procedures to back down a slope, Golden Technologies,
Inc. strongly advises that you have the assistance of another person.
Procedure 1 - Under Power
1. Set the key switch to the “Off position. See section V. “Operation.”
2. Dismount your Companion.
3. Set the key switch to the “On” position. See section V. “Operation.”
4. While standing alongside your scooter, carefully operate the controls at the lowest speed setting. See section
V. “Operation.”
5. Slowly and carefully back your scooter down the incline.
6. Carefully remount your Companion and resume normal operation.
Procedure 2 - Emergency (No Power)
1. Set the key switch to the “Off” position. See section V. “Operation.”
2. Dismount your Companion.
3. Set the freewheel lever to “Disengaged.”
4. While standing alongside the scooter, carefully manually maneuver it down the slope.
5. When you have reached a level surface at the bottom of the slope, position the freewheel lever in the
engaged position. See section VII. “Disassembly.
6. Carefully remount your Companion and resume normal operation.
WARNING: When your scooter is in freewheel mode, the brake is released. The weight of the scooter on a
slope may cause you to lose control of the scooter. If you do not feel capable of manually controlling your
scooter down the slope, request assistance or do not attempt to use this Procedure.
Motor Braking System
Your scooter is equipped with a system that uses the motor to aid in braking. This Motor Brake system is de-
signed to work when the key is in either the On position or the Off position. When the key is in the On position,
the freewheel is in the engaged position, and the scooter is under power, the motor will help slow down the
scooter as soon as you take your hand off of the throttle lever.
When the key switch is in the off position and the freewheel is in the disengaged position, the motor brake sys-
tem will keep you from pushing the scooter too fast (i.e. down a slope). You may notice this when pushing the
scooter. The scooter will move freely until you reach a certain speed. You will then encounter some resistance as
the motor brake system is activated.
MEDICATION
Always check with your physician to determine if any of the medications you are taking
may affect your judgement and/or your ability to operate your Companion. Also check with your physician
concerning your physical ability to operate a scooter.
WARNING: Do not connect or allow anyone except an authorized Golden Technologies, Inc.
representative to connect any electrical or mechanical device to your Companion. Unauthorized
accessories will void the warranty and may cause injury.
II. SAFETY

Companion Owner's Manual: GC240, GC340, GC440
Companion 10
Please use your Golden Companion scooter often and allow it to expand the horizons of your daily life.
The more mobility your Golden Companion brings to you, the happier you will be, and the more
satisfied we at Golden Technologies, Inc. will be! But as with all things, especially motor operated
vehicles, observing a few rules and safety considerations will help ensure safe scooter operation. So
please follow the rules below.
NOTE: Please remember that while on your Golden Companion, you are a
motorized pedestrian. You must observe and obey all pedestrian rules and
regulations for the locale in which you are riding.
RULES FOR USE AND OTHER SAFETY CONSIDERATIONS
• Read completely and understand this owner’s manual before assembling, operating,
transporting, or disassembling your Golden Companion.
• Always operate your Golden Companion with thought, care, and safety.
• Do not attempt to use your Companion on an escalator. Always use an elevator.
• Do not carry passengers under any circumstances.
• Do not mount or dismount your Golden Companion unless the brake is engaged.
• Always make sure that the key switch is set to “Off” before mounting or dismounting
your scooter.
• Do not back your Golden Companion down an incline or across an uneven surface.
• Do not turn your scooter suddenly at full speed.
• Always make sure the seat is locked forward before operating your Companion.
• Always come to a full stop before changing direction from forward to reverse or from
reverse to forward.
• Do not operate your Companion where you could not safely or legally walk.
• Do not climb ramps or curbs that exceed your scooter’s capacity.
• Always approach curbs and inclines straight on.
• Always turn on your scooter’s lights when operating near traffic, at night, and in any
• poorly lit area.
• Always be aware of and careful near mechanical pinch points especially when
assembling and disassembling your scooter.
• Never sit on your Companion when it is being transported.
• Always fasten down your Companion securely with an approved tie-down system while
transporting your scooter.
• Never operate your vehicle if it is not functioning properly.
• Always use caution when driving on soft or uneven surfaces such as grass, gravel. Also
use caution on decks where there is no railing.
• Never drive on the roadway, except when you must cross the street.
• Always cross streets at intersections and use crosswalks or the most direct route,
making sure that your path is clear and that you are visible to motor traffic.
• Never drive your Companion up or down a step or curb that is higher than the ground
clearance on the spec page.
• Never back up or down a step or curb.
• Do not drive your Companion in icy or salted conditions.
• Never operate your Companion while you are under the influence of alcohol.
II. SAFETY

Companion Owner's Manual: GC240, GC340, GC440
Companion 11
The rapid development of electronics, especially in the area of communications, has
saturated our environment with electromagnetic (radio) waves that are emitted by television
transmitters, cellular phones, citizen’s band radios (CBs), amateur radios (ham radios),
wireless computer links, microwave transmitters, paging transmitters, etc. These
electromagnetic (EM) waves are invisible and increase in strength the closer one gets to the
source of transmission. When these energy waves act upon electrical devices and cause
them to malfunction or to function in an erratic or uncontrolled manner, they are referred to
as Electromagnetic Interference (EMI) or Radio Frequency Interference
(RFI).
EMI/RFI AND YOUR COMPANION
All electrically powered vehicles, including scooters are susceptible to Electromagnetic
Interference/Radio Frequency Interference (EMI/RFI). This interference could result in
abnormal, unintended movement of your Golden Companion.
WARNING: Unintended movement or brake release could cause an accident or injury.
The FDA has determined that each make and model of scooter can resist EMI/RFI to a
certain level. The higher the level of resistance, the greater the degree of protection from
EMI/RFI—measured in volts per meter (V/m). The FDA has also determined that current
technology is capable of providing 20 V/m of resistance to EMI/RFI, which would provide
useful protection against common sources of interference. This product has been tested and
has passed at an immunity level of 20 V/m.
EMI/RFI RECOMMENDATIONS
• Do not turn on or use hand-held personal electronic communication devices such as
cellular phones, walkie-talkies, and CB radios while your scooter is turned on.
• Be aware of any nearby transmitters (radio, television, microwave, etc.) on your intended
route and avoid operating your scooter close to any of those transmitters.
• Turn off the power if your Companion is going to be in a stationary position for any
length of time.
• Be aware that adding accessories or components or modifying your scooter may make it
more susceptible to EMI/RFI.
• If unintended movement or brake release occurs, turn your scooter off as soon as it is
safe to do so.
• Report all incidents of unintended movement or brake failure to Golden Technologies,
Inc. Technical Service at [phone].
WARNING: Turn off your scooter as soon as it is safely possible if unintended or
uncontrollable motion occurs or if unintended brake release occurs.
III. EMI/RFI

Companion Owner's Manual: GC240, GC340, GC440
Companion 12
FOR YOUR RECORDS
Please fill in your Companion’s information below. This information will be useful in the
event that you ever need to contact Golden Technologies, Inc. concerning your scooter.
Your Companion
Model ________________ Serial Number (under carpet—right rear)
Date of Purchase __________________ Body Color
Options_________________________________________________________________
Place of Purchase________________________________________________________
Name___________________________________________________________________
Company________________________________________________________________
Address_________________________________________________________________
_________________________________________________________________________
Please remember to fill in and return your warranty registration card in the back of this
manual.
ARMREST WIDTH
ADJUSTMENT KNOBS
SEAT ROTATION LEVER
TILLER
ADJUSTMENT
LEVER
CONTROL PANEL
BRAKE HANDLE
TILLER
HANDGRIP
FIGURE 4. YOUR GOLDEN COMPANION
REMOVABLE CARPET
IV. YOUR GOLDEN COMPANION
HEADLIGHT
SEAT SLIDE LEVER
ARMREST HEIGHT
ADJUSTMENT KNOB
ARMREST ANGLE
ADJUSTMENT SCREW
TIE DOWN

Companion Owner's Manual: GC240, GC340, GC440
Companion 13
Specification GC240 GC340 GC440
Length 42.5 in. 45.8 in. 47.5 in.
Width 23.5 in. 23.5 in. 24 in.
Tires Solid Solid Solid
Front 9 in. 9 in. 10 in.
Rear 9 in. 10 in. 10 in.
Weight capacity 300 lbs. 350 lbs. 350 lbs.
Ground clearance 3.5 in. 3.5 in. 4 in.
Ground level to top of seat lowest/highest position 22 in./25 in. 23 in./26 in. 23 in./26 in.
Height from deck to top of seat lowest/highest position 16.5 in./19.5 in. 16.5 in./19.5 in. 16.5 in./19.5 in.
Space between rear shroud and front tire cover (front cowl) 12.5 in. 15 in. 15 in.
Space between rear shroud and tiller 16 in. 18 in. 19 in.
Space between front of seat forward/back position and tiller 11 in./14 in. 14 in./17 in. 15 in./18 in.
Weight of front/back half 45 lbs./43 lbs. 47 lbs./47 lbs. 62 lbs./47 lbs.
Weight of seat with arms 19 lbs. 19 lbs. 19 lbs.
Length of wheelbase (axle-axle) 30 in. 35 in. 35 in.
Height of unit with tiller down and seat post lowest position 18 in. 18.5 in. 21 in.
Height of unit with tiller down and seat post highest position 19.5 in.
Maximum speed* 5.0 mph
Operating range* 19.9 miles
Turning radius 39 in.
Batteries (2) Type U-1
Weight 122 lbs.
with batteries 166 lbs.
Freewheel mode Yes
Electronic speed control Yes
Maximum Curb Climbing 2.25 in.
Brakes Electromechanical Park Brake and Motor Brake
Charger Off-board
Rear-wheel drive Sealed transaxle Motor, 24 VDC
Warranty See Warranty
20 in. 21 in.
5.5 mph 5.4 mph
20.9 miles 18.6 miles
40.4 in. 53.5 in.
Type U-1 Type U-1
128 lbs. 144 lbs.
172 lbs. 188 lbs.
Yes Yes
Yes Yes
3.75 in. 3.75 in.
IV. YOUR GOLDEN COMPANION
*At 220-lb. user weight. Actual range and speed will vary with user weight and terrain.

Companion Owner's Manual: GC240, GC340, GC440
Companion 14
CONTROLS
Speed Adjustment Dial
• The speed adjustment dial allows you to preselect the maximum top speed of your
Golden Companion. See figure 5.
• Turn the dial counterclockwise to operate your scooter at the lowest speed level.
• Turn the dial clockwise to increase the operational speed of your scooter.
• We recommend that you select a speed setting at which you feel comfortable, safe, and
in control of your Companion.
Key Switch
This switch turns the power on and off to your Companion. See figure 5.
• Insert the key into the key switch.
• Turn the key 90 degrees clockwise to turn on your scooter’s power.
• Turn the key back to the vertical position to turn off your scooter’s power.
NOTE: Always make certain that the key is removed from the key switch before
getting on or off your Golden Companion or before lowering the tiller com-
pletely.
DC VOLTAGE METER
KEY SWITCH
FIGURE 5. CONTROL PANEL
SPEED ADJUSTMENT DIAL
V. OPERATION
HORN
HORN LIGHT
THROTTLE
CONTROL LEVER
POWER INDICATOR LED

Companion Owner's Manual: GC240, GC340, GC440
Companion 15
Power Indicator LED
When the power to your Companion is turned on, the Power Indicator LED (Light Emitting
Diode) will light up. See figure 5. This LED is used for diagnosing operational problems that
may arise. Please see the Diagnostics section of this manual.
Horn Button
Press this button to sound the horn. See figure 5.
Light Switch Button
This button operates your Companion’s lighting system. See figure 5.
• Press the button once to turn on your scooter’s lights.
• Press the button a second time to turn off the lights.
NOTE: The lights on your Companion are for safety purposes only! They were
designed for you to be seen and not for driving at night.
Delta Tiller Throttle Control Lever
The Delta Tiller enables you to use only one hand (either the right or left) to operate both the
speed and the direction of the Companion. This self-centering lever system controls your
Companion’s speed (up to the maximum speed set by the speed adjustment dial) and its
forward and reverse direction. See figure 5.
To drive forward use either of the following:
• Use your right hand fingers to pull back on the right side of the throttle control lever.
• Use your left thumb to push the left side of the throttle control lever.
NOTE: Always bring your Companion to a full stop before changing direction
from forward to reverse, or from reverse to forward.
To drive in reverse use either of the following:
• Use your left hand fingers to pull back on the left side of the throttle control lever.
• Use your right thumb to push the right side of the throttle control lever.
When the throttle control lever is completely released, it automatically returns to the center
“stop” position and engages your scooter’s brakes, bringing you to a complete stop. You will
hear a “click” when the brake engages.
V. OPERATION

Companion Owner's Manual: GC240, GC340, GC440
Companion 16
DC Voltage Meter
This meter (see figure 5) shows the amount of voltage in your Companion’s batteries.
• Green indicates a full charge on the batteries.
• Yellow indicates caution and approximately a one-half charge of the batteries.
• Red indicates that the batteries have less than one-half of a charge remaining. See
section X. “Care and Maintenance” for instruction concerning charging the batteries.
NOTE: Your scooter will automatically turn itself off if the battery output falls
to or below 17.5 VDC.
Finger Tip Tiller Adjustment Lever
The Tiller on your Companion scooter employs a pneumatic piston to provide you with
infinite tiller angle settings for your driving comfort.
• Use one hand to grasp a handgrip.
• Pull on the release lever and position the tiller at a comfortable and safe operating angle.
• Release the tiller adjustment lever. It will automatically lock the tiller at the selected
angle.
CONTROL OPTIONS
Golden Technologies, Inc. has made provision for the individual needs and abilities of the
operators of the Golden Companion.
Your authorized Golden Technologies, Inc. dealer can reverse the throttle control lever
controls so that when you pull on the left side of the lever, your scooter will move in the
forward direction, and when you pull on the right side of the lever your scooter will move in
the reverse direction.
SEATING CONTROLS
Armrest Height Adjustment
1. Loosen “Armrest Height Adjustment Knob” until you can pull it outward. See figure 6.
Note: The knob is retained in its housing with a spring.
2. While keeping the knob pulled, raise or lower the armrest to the desired position then re-
lease the knob. After releasing the knob, you may have to raise or lower the armrest un-
til it aligns with the nearest locking position.
3. Tighten the height adjustment knob.
V. OPERATION

Companion Owner's Manual: GC240, GC340, GC440
Companion 17
Armrest Width Adjustment
To adjust the armrest width:
1. Loosen the adjustment knobs at the
rear of the seat. See figure 6.
2. Slide the armrests in or out to the
desired width. See figure 7.
3. Tighten the adjustment knobs.
Seat Height Adjustment
To adjust the seat height:
1. Remove the seat by raising the lever
and lifting the seat straight up.
2. Set the seat aside.
3. Remove the bolt, nut, and washer that
hold the seat post in the seat pedestal.
See figure 8.
4. Position the seat post at the desired
height while aligning the holes in the
seat post and the seat pedestal.
5. Reinstall and tighten the nut, bolt,
and washer. The bolt must be installed
from the back of the pedestal, with the
nut and washer to the front of the
scooter.
6. Raise the lever when placing the seat
back on the seat post.
Seat Rotation Lever
The seat can be rotated through 360° and
locked at any 45° position.
1. Pull up on the seat rotatation lever
and rotate the seat to the desired
position. See figure 4.
2. Release the handle to lock the seat at
any 45° position.
Flip-up Armrests
Pull up on the end of either armrest to flip
it up for easy transfer on and off your
Golden Companion. See figure 9.
Armrest Angle
To increase the armrest angle, turn the
armrest angle screw clockwise. See figure
6. To decrease the armrest angle, turn the
armrest angle screw counterclockwise.
FIGURE 6. ARMREST ADJUSTMENTS
FIGURE 9. FLIP-UP ARMRESTS
FIGURE 8. SEAT HEIGHT
V. OPERATION
FIGURE 7. ARMREST WIDTH
ARMREST ADJUSTMENT
KNOBS
ARMREST ANGLE
ADJUSTMENT

Companion Owner's Manual: GC240, GC340, GC440
Companion 18
V. OPERATION
Freewheel Mode
Your Golden Companion is equipped with a
freewheel lever that can set your scooter in or
out of freewheel mode. The freewheel lever
engages your park brake.
To disengage the brake and put your scooter
in freewheel mode:
Push the brake handle in the direction of
“disengage” on the label. See figure 11.
To engage the brake and take your scooter
out of freewheel mode:
Push the brake handle in the direction of
“engage” on the label. See figure 10.
Pushing the scooter too quickly in freewheel
will cause the motor to act as a generator
causing the scooter to become difficult to
push. Freewheel slowly.
FIGURE 11. FREEWHEEL LEVER (DISENGAGED)
FIGURE 10. FREEWHEEL LEVER (ENGAGED)
WARNING: Do not sit in or attempt to move your Companion unless the frame and
rear carriage are securely engaged. Accidental separation of the frame from the rear
carriage may occur and cause injury or damage.
WARNING:
Never set your Companion in freewheel mode when it is on an incline.
Never disengage the brake handle while you are operating your Companion.
Always make certain that your scooter brake is engaged before inserting the key into
the key switch.

Companion Owner's Manual: GC240, GC340, GC440
Companion 19
MOUNTING
NOTE: For your first driving sessions, make certain that your Golden
Companion starts out on a level surface and that you will continue driving on
a level surface.
To Get on Your Companion
1. Stand behind your Companion.
2. Make certain that the freewheel lever is in
engaged position. See figure 10.
3. Pull up on the seat rotate lever. See figure 4.
• This lever is normally located on the
right-hand side of the seat, but your
Companion may be configured to have
the lever positioned on either side of
the seat.
• Once the lever is pulled up and held in the “up” position, the
seat can be freely rotated.
• Release the lever to lock the seat into one of the eight preset locking positions.
5. Make certain that the seat is positioned for safe and easy mounting.
6. Position yourself in the seat.
7. Use the seat rotate lever to position the seat so that it is locked in the fully forward
direction.
8. Fasten your lap belt, if your Companion is so equipped.
9. Place the key into the key switch.
10.Rotate the key to the on position. See figure 13.
BASIC DRIVING
1. Make certain that you are seated safely and properly on your Golden Companion.
2. Turn the speed control dial fully counterclockwise to its slowest setting.
3. Insert the key into the key switch—if you have not already done so.
4. Turn the key clockwise to the “On” position. See figure 13.
5. Place your hands on the handgrips.
• If you wish to drive forward, pull back on the right side of the throttle control
lever (or push the left side of the throttle control lever forward.)
• If you wish to drive in reverse, pull back the left side of the throttle control lever
(or push the right side of the throttle control lever forward.)
6. Pull on the throttle control lever to gently accelerate your Companion.
7. Release the throttle control lever to allow your Companion to come gently to a full stop.
8. Practice these two basic functions until you feel that you have control of your scooter.
FIGURE 12.
VI. RIDINGYOUR COMPANION
FIGURE 13.

Companion Owner's Manual: GC240, GC340, GC440
Companion 20
Steering
Steering your Golden Companion is easy and logical.
1. With both hands on the handgrips of the tiller (see figure 4.), turn the tiller to the right to
travel to the right.
2. With both hands on the handgrips of the tiller (see figure 4.), turn the tiller to the left to
travel to the left.
3. Make certain to maintain sufficient clearance when turning your scooter so that the
rear wheels will clear any obstacle.
NOTE: Turning your scooter too sharply at too high a speed may create a
situation where one of the rear wheels will leave the ground and the possibility
of tipping the scooter. Avoid this danger at all times by decelerating and
steering a wide arc around corners and obstacles.
Steering in a Tight Spot
If you must steer in a tight spot, such as entering a doorway or when turning around:
1. Bring your Companion to a full stop.
2. Set speed at the lowest setting.
3. Turn the tiller to the direction in which you wish to drive.
For more information on dealing with obstacle and tight spots, see “Control Through Tight
Spots” on the next page.
Steering in Reverse
Backing up your Companion requires attention to what you are doing.
1. Use your right fingers to push the throttle control lever or use your left fingers to pull
back on the throttle control lever. See figure 5.
2. Turn the tiller to the left to drive in reverse to the left.
3. Turn the tiller to the right to drive in reverse to the right.
NOTE: Your Companion’s speed in reverse is fifty percent of the speed set at the
speed control dial.
VI. RIDINGYOUR COMPANION