Hunter Products PAW PATROL ZPV002 User manual

OPERATION MANUAL
ZPV002 CUSTOMISABLE 6V RIDE ON
ITEM: 4233 PAW PATROL
AGE: 3 years +
MAXIMUM USER WEIGHT: 20 kgs
MADE IN CHINA

(1) Battery: Enclosed lead-acid battery (6V, 4.5AH)
(2) Loading limitation: 20kg.
(3) Power: input 240V.
(4) Duration of the battery: around one hour functioning with 8-12 hours charging.
The vehicle can be used 1 hour.
(5) Size: 70*35*42.5 cm
(1) Before using it for the first time, lift up the seat and connect the main wire to
the battery wire (with RED to RED, BLACK to BLACK) any wrong connection
may cause short circuit or other faults.
(2) The charge socket is under the sterrning wheel, with charge indentification.
(3) Charge the battery if the vehicle runs slower than normal.
(4) Don’t charge the battery for over 15 hours each time.
(5) Charge the battery fully if you will store it for a long time, then charge it every 3
month, in this way you can extent the lifetime of the battery.
(6) It is normal that the power charger and the battery jar become warmer while the
battery is on charging.
1. The use of informaton:
2. Specification：
1
FOR ANY PRODUCT ENQUIRIES OR ISSUES PLEASE CONTACT HUNTER PRODUCTS
AT WWW.ELECTRICRIDEON.COM.AU OR TOLL FREE HELP LINE 1800 224 094.

2
FOR ANY PRODUCT ENQUIRIES OR ISSUES PLEASE CONTACT HUNTER PRODUCTS
AT WWW.ELECTRICRIDEON.COM.AU OR TOLL FREE HELP LINE 1800 224 094.
3. Precautions:
WARNING:
ADULT ASSEMBLY REQUIRED.
Read entire instructions carefully before assembling this product.
WARNING: ASSEMBLY
· Keep these instructions for future reference.
· Prior to assembly, this package contains small parts: hardware which is a
choking hazard and may contain sharp edges and sharp points. Keep product
away from children until assembled.
· Ensure working area is free of danger, always dispose packaging material in
such a way that it may not cause any harm.
Plastic bags can be dangerous. To avoid suffocation keep plastic bags away
from babies and children.
· To prevent serious injury, children must not use the equipment until completely
assembled.
· Spare parts exhange should be operated by an adult, because the battery is very
heavy and the internal acidic electrolyte, if any leakage should avoid touch the
liquid, and need a professional disposition. If accidental with the electrolyte, it is
timely at least 15 minutes rinse with cold water and seek medical treatment.
IMPORTANT - MUST READ CAREFULLY
WARNING: USE
TO AVOID SERIOUS INJURY: Continuous adult supervision is required while this
vehicle is in operation.
· To reduce the risk of injury, adult supervision is required. DO NOT leave the
child play vehicle alone to avoid accidents.
· NEVER use in or near roadways, near motor vehicles, on or near steep inclines
or steps, swimming pools or other bodies of water and dangerous place, always
wear shoes, and NEVER allow more than 1 rider.
· NEVER allow children to ride at night.
· Instruct children on proper use of this product and to sit properly when driving.
DO NOT RIDE VEHICLE STANDING UP.
· It is recommended that the rider always wears safety equipment such as fitted
helmet when riding the vehicle.
· Ride-on toys should be used with caution since skill is required to avoid falls or
collisions which may cause injury to the user or others.
· The vehicle is intended for use on flat, level surfaces.
· DO NOT ride the vehicle indoors. It is intended for outside use ONLY. Interior
floors can be damaged by riding the vehicle indoors.
· DO NOT tow objects behind the vehicle or overload the vehicle as doing so will
· NOT to be used in traffic.
cause damage.

3
FOR ANY PRODUCT ENQUIRIES OR ISSUES PLEASE CONTACT HUNTER PRODUCTS
AT WWW.ELECTRICRIDEON.COM.AU OR TOLL FREE HELP LINE 1800 224 094.
4. Fused tube:
5. Trouble shooting:
When the car cannot move ,please check the fuse is fusing or not.
Problem
The vehicle does not move
The vehicle begins to run slow
The vehicle runs erratically
The charger feels warm when in
use
The gears sound very loud and/or
are making a grinding noise.
Possible Solutions
· Charge the battery. (Charge battery after each use.)
NOTE: vehicle will be cut off electricity during charging.
· Check all electrical connections.
· Check all switch whether "on" position.
· Check foot switch or manual button is stuck down so
that can not press.
· The fuse may have been activated due to excessive
weight or weight or rough driving conditions. Wait at
least 10~20 seconds, and the vehicle will reset itself.
· Check is whether there is debris stuck wheels.
· Charge the battery. (Charge battery after each use.)
· Only allow one rider at a time.
DO NOT exceed child weight limit: 20kg
· Drive on level ground.
· Battery may be old or not accepting a full charge.
The battery will last from 1 to 3 years depending on
care, use and environment.
Replace with 6Volt 4.5 Ah battery only.
· Check is whether there is debris stuck wheels.
· There may be a problem with the fuse, or you may
have a damaged battery.
· This is normal.
· The gears may be broken.

4
FOR ANY PRODUCT ENQUIRIES OR ISSUES PLEASE CONTACT HUNTER PRODUCTS
AT WWW.ELECTRICRIDEON.COM.AU OR TOLL FREE HELP LINE 1800 224 094.
6. How to charge:
NOTE:
(1) To assure the safety, battery charging and replaced only done by an
adult.
(2) Remove and insert battery with the correct polarity (+ and -).
(3) First using, fully charger at least 10hours, normal recharging
8~10hours after every using, but NEVER charge over 15hours.
(4) CHECK the charger, battery and plug before every charging,
DO NOT use if it is broken.
DO NOT upside down the battery when charging.
(5) DO NOT open or decompose the battery and charger, ONLY USE the
type battery and charger recommended for the unit.
(6) DO NOT short-circuit battery terminals.
(7) DO NOT recharge non-rechargeable battery.
(8) DO NOT mix old and new or different type of batteries.
(9) DO NOT dispose of battery in fire as it may leak or explode.
(10) Exhausted battery is to be removed from the toy.
(11) When vehicle is not used for an extended time, remove battery to
prevent possible leakage and damage to the unit.
Charge the battery once per three months to extend the lifetime of the
battery.

5
FOR ANY PRODUCT ENQUIRIES OR ISSUES PLEASE CONTACT HUNTER PRODUCTS
AT WWW.ELECTRICRIDEON.COM.AU OR TOLL FREE HELP LINE 1800 224 094.
7.Parts:
Vechilce Body*1 Steering Wheel*1
Wheel Hub*4
Rearview Mirror*2 Wheel*3
M4*30 Screw for
Steering Wheel*1
Driving Wheel*1
M4 Nut for
Steering Wheel*1
Spacer*7
Wheel Cap*4
M8 Nut*4 Charger*1
Spanner*2

6
FOR ANY PRODUCT ENQUIRIES OR ISSUES PLEASE CONTACT HUNTER PRODUCTS
AT WWW.ELECTRICRIDEON.COM.AU OR TOLL FREE HELP LINE 1800 224 094.
8. Exploded diagram:
7
8
9
10 11
Spacer*7
Wheel hub*4
Wheel cap*4 M4*30 screw for steering wheel*1 M4 Nut for steering wheel*1
12
12
12
1
2
5 6
3
4
Vehicle body*1 Driving wheel*1 Steering wheel*1 Rearview mirrorl*2 Wheel*3 M8 NUT*4
Spanner*2

④ ⑤
④
⑧
7
FOR ANY PRODUCT ENQUIRIES OR ISSUES PLEASE CONTACT HUNTER PRODUCTS
AT WWW.ELECTRICRIDEON.COM.AU OR TOLL FREE HELP LINE 1800 224 094.
③
①
②
9. How to install:
12
12

FOOT SWITCH
CHARGE HOLE
FORWARD/BACKWARD SWITCH
10.Operation:
8
FOR ANY PRODUCT ENQUIRIES OR ISSUES PLEASE CONTACT HUNTER PRODUCTS
AT WWW.ELECTRICRIDEON.COM.AU OR TOLL FREE HELP LINE 1800 224 094.
⑥
④
⑧
9. How to install:

Our goods come with guarantees that cannot be excluded under the Australian Consumer Law.
You are entitled to a replacement or refund for a major failure and for compensation for any other
reasonably foreseeable loss or damage. You are also entitled to have the goods repaired or
replaced if the goods fail to be of acceptable quality and the failure does not amount to a major
failure.
Where a failure does not amount to a major failure, we are entitled to choose between providing
you with a repair, replacement or refund. To obtain compensation, you would need to provide
documentary evidence of the loss or damage suffered, and documentary evidence that such loss
or damage was a reasonably foreseeable consequence of a failure by us to comply with a
consumer guarantee under the Australian Consumer Law. Such evidence may include
photographs, statutory declarations, receipts or reports (e.g. from your doctor), depending on the
loss or damage.
In addition to all rights and remedies to which you may be entitled under the Competition and
Consumer Act 2010 (Commonwealth) and any other relevant legislation, the manufacturer
warrants this product to be free from defects in materials or workmanship for a period as stated
on the packaging from the date of purchase.
In order to claim under this warranty, you will need to bring the product to the store of purchase,
along with proof of purchase (typically this will be a receipt). Any cost incurred by you in bringing
the product to the service desk will be borne by you. We will then, at our option, either repair or
replace the product, or refund your money and take back the product.
Our liability under this manufacturer’s warranty is subject to us being satisfied that a defect was
caused by defective workmanship or materials, and was not caused by or substantially
contributed to by other factors, or circumstances beyond our control, including (but not limited to)
defective installation, maintenance or repair, alteration or modification of the product in any
manner not recommended by the manufacturer or any neglect, misuse or excessive use.
The benefits conferred by this manufacturer’s warranty are in addition to all rights and remedies
conveyed by the Competition and Consumer Act 2010 (Commonwealth), and any other statutory
rights to which you may already be entitled, and this warranty does not exclude, restrict or modify
any such rights or remedies that are implied by law.
HUNTER PRODUCTS
Level 2, 424 Warrigal Road Moorabbin 3189
Ph: 1800 224 094
Email: [e-mail]
9
FOR ANY PRODUCT ENQUIRIES OR ISSUES PLEASE CONTACT HUNTER PRODUCTS
AT WWW.ELECTRICRIDEON.COM.AU OR TOLL FREE HELP LINE 1800 224 094.

Our products are suitable for the following standard:
GB6675
ASTM-F963
EN71 AND EN62115
090216