Kohler Pinoir K-2035 User manual

Installation Guide
Pinoir
TM
Pedestal Lavatories
1015627-X2-A
K-2035
X product numbers are for Thailand (i.e. K-12345X)
 ⌫  
  

1015627-X2-A 2 Kohler Co.
Tools and Materials
We appreciate your commitment to Kohler quality. Please take a few
minutes to review this manual before you start installation. If you
encounter any installation or performance problems, please don’t hesitate
to contact us. Our phone numbers and website are listed on the back cover.
Thanks again for choosing Kohler Company.
Thank You For Choosing Kohler Company
Observe all local plumbing and building codes.
Prior to installation, unpack the new lavatory and inspect it for damage.
Return the lavatory to its protective carton until you are ready to
install it.
These instructions are for installing the lavatory to wood and concrete
construction. For other installations, supply suitable bracing and
fastening devices of sufficient size and strength.
The walls and floor must be square, plumb, and level.
Fixture dimensions are nominal and conform to tolerances in ASME
Standard A112.19.2M.
Before You Begin

Kohler Co. 3 1015627-X2-A
Install the water supplies and drain piping according to the
roughing-in information. Install the supply stops so the handles
will not touch the pedestal when fully open.
Install sufficient backing behind the finished wall to provide a secure
material for the anchoring devices.
Install the hanger according to the roughing-in information.
Carefully lift the lavatory into place on the hanger, and level. You may
need to raise or lower the hanger so the lavatory contacts the wall
evenly.
NOTE: The lavatory must be supported by the hanger.
Locate the two lavatory anchoring holes, and mark the hole locations
on the finished wall.
Carefully position the shroud under the lavatory, and mark the
finished wall at the upper anchoring hole locations.
Carefully remove the shroud and lavatory from the area.
1. Preparation

1015627-X2-A 4 Kohler Co.
2. Install Hanger on the Wall
Drill a 1/4” mounting holes at the marked lavatory mounting locations
on wood-finished wall, or 5/16” on concrete-finished wall and install
anchor into the mounting holes.
Position hanger against the wall. Use screw 3/16” (5 mm.) and washer
to secure the hanger to the finished wall and backing material. Make
sure the hanger is level.

Kohler Co. 5 1015627-X2-A
3. Install the Lavatory
Draw a line connecting the two upper anchoring hole marks on the
wall.
Drill a 1/4” mounting holes at the marked lavatory mounting locations
on wood-finished wall, or 5/16” on concrete-finished wall and install
anchor into the mounting holes.
Install the two upper angle brackets to the wall.
Install the faucet and drain to the lavatory according to the
manufacturer’s instructions.
Carefully set the lavatory on the hanger. Level the lavatory, and
carefully secure the lavatory to the wall with lag bolts and washers.
Tighten until snug.
Connect and tighten the trap to the drain, and complete the water
supply connections to the faucet according to the instructions packed
with the faucet.
Apply six self-adhesive gaskets to the top of the shroud as shown.
CAUTION: Risk of product damage. Do not overtighten the lag
bolts. Overtightening may damage the product.
CAUTION: Risk of product damage. Do not overtighten the
mounting bolts. Overtightening may damage the product.
Secure the shroud to the angle brackets with bolts and washers
so the shroud is snug against the lavatory underside.

เครื่องมือและวัสดุที่ใชสำหรับการติดตั้ง
⌫ ⌫⌫⌫
  ⌦⌫
⌫ 
 ⌫⌫
ขอสังเกตกอนเริ่มการติดตั้ง

 
 
⌫⌫⌫ 
 


 

ขอขอบคุณที่เลือกใชผลิตภัณฑโคหเลอร
 

⌫
   
คูมือการติดตั้ง
อางลางหนาแบบแขวนพรอมขาตั้งลอย รุนพีนัวรK-2035
1015627-X2-A -1 Kohler Co.

1. เตรียมการติดตั้ง
  
 
 ⌦
⌫
  
⌦ 
ขอสังเกต 
⌦ 
 ⌦
⌫
Kohler Co. -2 1015627-X2-A

2. ติดตั้งขอแขวนเขากับผนัง
   ⌦⌫ 
  ⌫ ⌦⌦
      ⌦
  
1015627-X2-A -3 Kohler Co.

ขอควรระวัง ความเสี่ยงซึ่งอาจทำใหสุขภัณฑเสียหาย 
⌫
ขอควรระวัง ความเสี่ยงซึ่งอาจทำใหสุขภัณฑเสียหาย ⌦
⌫
3. ติดตั้งอางลางหนา-ลางมือ
⌦
   ⌦⌫  
 ⌫ ⌦⌦
⌦


   ⌦

 ⌦

 
⌦⌦  

Kohler Co. -4 1015627-X2-A

1015627-X2-A -1 Kohler Co.