Metra Electronics AW-200GM User manual

METRA. THE WORLD’S BEST KITS.™
© COPYRIGHT 2004-2011 METRA ELECTRONICS CORPORATION
APPLICATIONS
1-800-221-0932 metraonline.com
INSTALLATION INSTRUCTIONS FOR PART 99-2001, AW-200GM
WIRING & ANTENNA CONNECTIONS (Sold Separately)
Wiring Harness: Please see www.metraonline.com for specific interface applications
Antenna Adapter: • 40-GM10 GM Antenna Adapter 1988-up
• 40-CR10 Chryler antenna adapter 2002-up
Utility Knife • Phillips Screwdriver • Socket Set
TOOLS REQUIRED
GM multi-kit 1994 - 2008
99-2001
AW-200GM
DA CB
• A) Radio Housing • B) Spacer • C) Equalizer Dummy Plate • D) Shaft Masks
KIT FEATURES
KIT COMPONENTS
• DIN head unit with equalizer provision
See application list inside

99-2001, AW-200GM
Applications
KNOWLEDGE IS POWER
Enhance your installation and fabrication skills by
enrolling in the most recognized and respected
mobile electronics school in our industry.
Log onto www.installerinstitute.com or call
800-354-6782 for more information and take steps
toward a better tomorrow.
Metra recommends MECP
certified technicians
Caution
Metra recommends disconnecting the negative battery terminal before beginning any installation.
All accessories, switches, and especially air bag indicator lights must be plugged in before reconnecting
the battery or cycling the ignition.
*NOTE: Refer also to the instructions included with the aftermarket radio.
Buick
Century 1997-2005
Le Sabre 1995-2005
Park Avenue 1995-2005
Rainier 2004-2007
Regal 1995-2004
Rendezvous 2002-2007
Riviera 1996-1999
Roadmaster 1995-1996
Skylark 1996-1998
Cadillac
Escalade 2003-2006
Chevrolet
Avalanche 2003-2006
Blazer 2002-2005
Cavalier 2000-2005
Colorado 2004-2008
Express Van (full size) 2001-2007
Impala 2000-2005
Malibu 2001-2003
Malibu Classic 2004-2005
Monte Carlo 2000-2005
S-10 2002-2004
Chevrolet (cont.)
Silverado 2003-2006
Silverado Classic 2007
Suburban 2003-2006
Tahoe 2003-2006
Trailblazer 2002-2007
Venture 2000-2005
GMC
Canyon 2004-2008
Denali 2003
Envoy 2002-2007
Savanna 2001-2007
Sierra 2003-2006
Sierra Classic 2007
Sonoma 2002-2004
Yukon/Denali/XL 2003-2006
Hummer
H2 2003-2007
Isuzu
Ascender 2003-2005
I-290/I370 2007-2008
I-280/I350 2006
Oldsmobile
Achieva 1996-1998
Alero 1999-2004
Aurora 1995-2003
Bravada 1998-2001
Bravada 2002-2004
Cutlass 1997-1999
Cutlass Supreme 1995-1997
Eighty-Eight 1994-1999
Intrigue 1998-2002
LSS 1996-1999
Ninety-Eight 1994-1996
Regency 1997-1998
Silhouette 2000-2004
Pontiac
Aztec 2001-2005
Bonneville 2000-2005
Grand Am 2001-2005
Montana 2000-2005
Sunfire 2000-2005

3
99-2001, AW-200GM
Table of Contents
Dash Disassembly
Buick
Century 1997-2005 5
Le Sabre 1995-2005 6
Park Avenue 1995-2005 6
Rainier 2004-2007 22
Regal 1995-2004 5
Rendezvous 2002-2007 7
Riviera 1996-1999 8
Roadmaster 1995-1996 9
Skylark 1996-1998 10
Cadillac
Escalade/EXT 2003-2006 11
Chevrolet
Avalanche 2003-2006 11
Blazer 2002-2005 12
Cavalier 2000-2005 13
Colorado 2004-2008 14
Express Van (full size) 2001-2002 15
Express Van (full size) 2003-2007 16
Impala 2000-2005 17
Malibu 2001-2003 17
Malibu Classic 2004 17
Monte Carlo 2000-2005 18
Chevrolet (cont.)
S-10 2002-2004 12
Silverado 2003-2006 11
Silverado Classic 2007 11
Suburban 2003-2006 11
Tahoe 2003-2006 11
Trailblazer 2002-2007 19
Venture 2000 20
Venture 2001-2005 21
GMC
Canyon 2004-2008 14
Denali 2003 11
Envoy 2002-2007 22
Savanna 2001-2002 15
Savanna 2003-2007 16
Sierra 2003-2006 11
Sierra Classic 2007 11
Sonoma 2002-2004 12
Yukon/Denali/XL 2003-2006 11
Hummer
H2 2003-2007 23-24
Continued on next page

4
99-2001, AW-200GM
Table of Contents (continued)
Isuzu
Ascender 2003-2005 22
I-290/I370 2007-2008 14
I-280/I350 2006 14
Oldsmobile
Achieva 1996-1998 25
Alero 1999-2004 25
Aurora 1995-2003 26
Bravada 1998-2001 12
Bravada 2002-2004 22
Cutlass 1997-1999 26
Cutlass Supreme 1995-1997 26
Eighty-Eight 1994-1999 27
Intrigue 1998-2002 27
LSS 1996-1999 28
Ninety-Eight 1994-1996 27
Regency 1997-1998 28
Silhouette 2000 20
Silhouette 2001-2004 21
Pontiac
Aztec 2001-2005 29
Bonneville 2000-2005 29
Grand Am 2001-2005 30
Montana 2000 20
Montana 2001-2005 21
Sunfire 2000-2005 30
Kit Assembly
All vehicles-DIN head unit provisions 31
All vehicles-shaft head unit provisions 31

5
Dash Disassembly 99-2001, AW-200GM
Buick Century 1997-2005
Buick Regal 1995-2004
1. Remove the plastic trim piece to the left
of the glove box and (1) Phillips screw
exposed.
2. Unsnap the top edge of the knee
bolster panel.
3. Remove (1) Phillips screw from
the panel.
4. Remove the ashtray cluster and (2)
Phillips screws from each side.
5. Unclip the entire dash trim bezel
and remove.
6. Open doors and unsnap end caps from
each side of dash.
7. Unsnap and remove radio/instrument
cluster panel.
8. Remove (3) screws in order to
remove radio.
Continue to kit assembly

6
Dash Disassembly 99-2001, AW-200GM
Buick Le Sabre 1995-1999
Buick Park Avenue 1995-1999
Buick Le Sabre 2000-2005
Buick Park Avenue 2000-2005
1. Unsnap the climate control trim panel
(from door to door) and remove (4)
Phillips screws exposed.
2. Pop out the a/c vents and remove (1)
Phillips screw exposed in each vent
cavity.
3. Unclip the radio trim bezel and remove.
4. Remove the screws securing the factory
head unit and disconnect the wiring.
Continue to kit assembly
1. Open drivers door and unsnap and
remove dash end cap.
2. Unsnap and remove trim along center
of dash. (One piece on right and
one on left of wheel)
3. Unsnap and remove radio/instrument
bezel.
4. Remove (2) screws in order to
remove radio.
Continue to kit assembly

7
Dash Disassembly 99-2001, AW-200GM
Buick Rendezvous 2002-2007
1. Open center console and remove 2
screws at front of console opening.
(Figure A)
2. Remove liners from cup holders and
storage pocket next to cup holders, then
remove screws. Unsnap and remove
panel. (Figure B)
3. Remove (2) screws from bottom of
radio/climate control bezel, unclip and
remove. (Figure C)
4. Remove (3) 9/32” hex head screws to
remove radio. (Figure D)
Continue to kit assembly
(Figure B)
(Figure C)
(Figure D)
(Figure A)

8
Dash Disassembly 99-2001, AW-200GM
Buick Riviera 1996-1999
1. Unsnap left side panel exposing (1)
Phillips screw to remove.
2. Remove (1) Phillips screw and unsnap
right side panel to expose (1) Phillips
screw beneath panel and remove.
3. Unsnap underside of overhanging dash
to unsnap (6) plastic rivets and
remove panel.
4. Remove (5) hex head screws now
exposed under overhang.
5. Unsnap bottom edge of trim bezel, then
while holding overhang up, unsnap and
remove trim bezel by removing any
necessary harnesses.
6. Remove (3) Phillips screw to remove
climate control.
7. Remove (2) Phillips screws to remove
rear support and (3) 9/32” hex head
screws to remove radio.
Continue to kit assembly

9
Dash Disassembly 99-2001, AW-200GM
Buick Roadmaster 1995-1996
1. Unclip dash panel sides and remove.
2. Unclip panel below steering column
and remove.
3. Remove (2) 7 mm screws above
instrument cluster.
4. Set parking brake, turn car on, and
move shifter to the lowest gear. Tilt
steering wheel down then unsnap
entire instrument cluster/radio panel
and remove.
5. Remove (3) 7 mm screws to
remove radio.
Continue to kit assembly

10
Dash Disassembly 99-2001, AW-200GM
Buick Skylark 1996-1998
1. Remove (6) 9/32” screws inside
glove box.
2. Under glove box and drivers knee
bolster, remove (2) plastic panels by
turning (2) 1/4 turn fasteners per side.
3. Remove (4) 9/32” screws revealed.
(2 per side).
4. Unsnap panel from driver’s side to
passenger’s side.
5. Remove (3) 9/32” screws to
remove radio.
Continue to kit assembly

11
Dash Disassembly 99-2001, AW-200GM
1. Unsnap and remove dash bezel.
2. Remove (3) 9/32” screws and
remove radio.
Continue to kit assembly
Cadillac Escalade 2003-2006
Chevrolet Avalanche 2003-2006
Chevrolet Silverado/Classic 2003-2007
Chevrolet Suburban 2003-2006
Chevrolet Tahoe 2003-2006
GMC Sierra/Classic 2003-2007
GMC Yukon/Denali/XL 2003-2006

12
Dash Disassembly 99-2001, AW-200GM
Chevrolet Blazer 2002-2005
Chevrolet S-10 2002-2004
GMC Sonoma 2002-2004
Oldsmobile Bravada 1998-2001
1. Remove (2) 9/32” hex-head screws
from the knee bolster panel.
2. Pull down on the panel and remove the
9/32” hex-head screws exposed on the
bottom of the dash trim bezel.
3. Remove (1) Phillips screw above the
instrument cluster.
4. Unclip the dash trim bezel and remove.
5. Remove (2) 9/32” hex-head screws
securing the factory head unit and
disconnect the wiring.
Continue to kit assembly

13
Dash Disassembly 99-2001, AW-200GM
Chevrolet Cavalier 2000-2005
1. Open drivers door and remove fuse
panel on end of dash.
2. Open passenger door and remove panel
on end of dash.
3. Remove (1) Phillips screw from each
side exposed.
4. Remove (3) screws from top of glove
box liner.
5. Remove (2) screws from the top-left
corner of the glove box cavity.
6. Remove (1) Phillips screw from the
defroster duct.
7. Remove the ductwork and (1) Phillips
screw exposed.
8. Remove the dash pad and (3) Phillips
screws exposed at the top of the radio
trim bezel.
Continue to kit assembly

14
Dash Disassembly 99-2001, AW-200GM
Chevrolet Colorado 2004-2008
GMC Canyon 2004-2008
Isuzu I-290/I-370 2007-2008
Isuzu I-280/I-350 2006
1. Unsnap and remove the entire panel
surrounding the radio and A/C controls.
(Figure A)
2. Remove (3) 9/32”screws securing the
radio to remove. (Figure B)
Continue to kit assembly
(Figure B)
(Figure A)

15
Dash Disassembly 99-2001, AW-200GM
Chevrolet Express Van 2001-2002
GMC Savanna 2001-2002
1. Unsnap and remove small trim panel
below steering column. (Figure A)
2. Unsnap radio/climate/instrument panel.
(Figure B)
3. Move shift lever to first gear position.
4. Rotate panel counterclockwise to lift
over steering column and remove.
5. Remove (3) 9/32” hex head screws to
remove radio. (Figure C)
Continue to kit assembly (Figure A)
(Figure B)
(Figure C)

16
Dash Disassembly 99-2001, AW-200GM
Chevrolet Express Van 2003-2007
GMC Savanna 2003-2007
1. Remove (2) 10 mm bolts from below
knee bolster under steering column
and remove panel. (Figure A)
2. Remove (2) 10 mm bolts from panel
below passenger dash airbag and
remove panel. (Figure B)
3. Remove (2) 10 mm nuts from inside
center pocket between power outlets.
(Figure C)
4. Unsnap and remove radio and
instrument cluster panel. (May not be
necessary to completely remove radio
and instrument cluster panel to
access radio.)
5. Remove (3) 9/32” bolts to remove radio.
(Figure D)
Continue to kit assembly
(Figure B)
(Figure A)
(Figure C)
(Figure D)

17
Dash Disassembly 99-2001, AW-200GM
Chevrolet Impala 2000-2005
Chevrolet Malibu 2001-2003
Chevrolet Malibu Classic 2004-2005
1. Unclip each side of the dash trim bezel
(fuse access) and remove (1) Phillips
screw exposed on each side.
2. Remove (2) Phillips screws under the
instrument cluster.
3. Unclip the trim panel above the pedals.
(It is not necessary to remove the panel
it can be left hanging).
4. Remove (2) Phillips screws from the
knee panel.
5. Unclip the knee panel and remove (1)
phillips screw exposed on the right
side of the steering column.
6. Unclip and remove the entire dash
trim bezel.
Continue to kit assembly
1. Unsnap and remove radio bezel.
2. Remove (3) bolts and remove radio.
Continue to kit assembly

18
Dash Disassembly 99-2001, AW-200GM
Chevrolet Monte Carlo 2000-2005
1. Unclip the trim panel above the pedals.
(It is NOT necessary to remove the
panel it may be left hanging).
2. Remove (2) 9/32” screws from the knee
panel and unclip the panel.
3. Unsnap the driver’s side fuse panel
cover and remove (1) 9/32” screw.
4. Open the glove box and remove (1)
9/32” screw from the upper left corner.
5. Remove (3) 9/32” screws securing the
factory radio and disconnect the wiring.
Continue to kit assembly

19
Dash Disassembly 99-2001, AW-200GM
Chevrolet Trailblazer 2002-2009
1. Remove (2) Phillips screws inside
instrument cluster.
2. Remove (1) Phillips screw under climate
controls to the left of the power outlet.
3. Remove (2) 7 mm hex heads from
under steering column and lower the
panel. Remove (3) Phillips screws
around steering wheel.
4. Unsnap and remove bezel. (Use caution
pulling over hazard switch.) Remove (3)
7 mm hex head screws to remove radio.
Continue to kit assembly

20
Dash Disassembly 99-2001, AW-200GM
Chevrolet Venture 2000
Oldsmobile Silhouette 2000
Pontiac Montana 2000 (Except SV6)
1. Remove the ashtray and (1) phillips
screw exposed in the ashtray cavity.
2. Remove (1) Phillips screw from the
cigarette lighter compartment.
3. Remove (2) Phillips screws securing
the factory head unit and disconnect
the wiring.
Continue to kit assembly