NRS Healthcare P23117 User manual

1
USER INSTRUCTIONS
DUO WALKING TROLLEY
GENERAL SAFETY WARNING
Please make sure that you read and follow these
instructions carefully. Failure to do so can result
in injury. Keep these instructions in a safe place
for future reference.
P23117 Turquoise Blue P23129 Pebble Grey
MAXIMUM USER WEIGHT
20st
127kg
1.0 INTENDED USE
For use as a lightweight household trolley, for the transfer of items around the home, for users with reduced
mobility. The product is height adjustable and has been designed to allow a natural walking gait. The upper
and lower trays will each take a load of up to 5 kg (11 lbs).
2.0 SAFETY
1. Do not use the trolley to transfer to or from a
seated position.
2. The maximum load weight for the trolley trays
must not be greater than 5 kg (11 lbs).
3. We strongly recommend using a non-slip mat
and lidded drinks container for transporting food
and drink on the trolley. Refer to Section 11.0 for
recommended products.
4. Do not use the trolley if you see or suspect a
fault or if any part of the product is damaged.
5. Make sure that all of the trolley legs are at the
same height
1
9
6
4
3
2
8
5
7
3.0 UNPACKING
Remove the packaging and check all parts carefully.
Contact your supplier immediately if parts are
missing or damaged and do not try and assemble.
Contents:
1. Handles x 2
2. Top Tray x 1
3. Rear Legs (Slider Ferrules) x 2
4. Frame x 1
5. Bottom Tray x 1
6. Front Legs (Wheeled) x 2
7. Handle Screws x 4
8. E-Clip Fasteners x 4
9. Allen Key x 1

2
4.0 ASSEMBLY
4.1 Fitting the Front Legs (Wheeled):
FRONT
FRONT
BACK
FRONT
BACK
BACK
1. Insert the front legs into the frame and secure
with 2 x E-Clips.
Warning: The front legs must be positioned as
labelled. Failure to install the legs correctly will
compromise the stability of the trolley.
4.2 Fitting the Rear Legs (Slider Ferrules):
8
1. Insert the rear legs into the frame and secure
with 2 x E-Clips.
2. Use the front and rear leg height adjustment
markers to make sure that all legs are adjusted
to the same height.
3. Refer to Section 4.6 for the correct height
adjustment for the user.
4.3 Fitting the Handles:
1. Insert the handles into the frame.
Note: The handles must face the rear of the
trolley.
2. Align the four handle holes with the four holes
in the frame.
3. Insert the 4 x handle screws and tighten using
the Allen key.
Note: You must use all four of the handle screws
provided.
4. Make sure the handles are fully secure by trying
to push and pull the handles apart / together.
5. Use the Allen key to check the handle screws
are still tight and re-tighten if necessary.
4.4 Fitting the Bottom Tray:
1. Place the bottom tray onto the bottom side rails
of the frame, then push the tray forward until it
clips into position
2. Check the tray is fully secure before use.

3
4.5 Fitting the Top Tray:
1. Place the top tray onto the top side rails of the
frame, then push down on the tray until it clips
into position.
2. Make sure that the tray is fully secure before
use.
4.6 Height Adjustment:
4.6.1 Check Trolley Height:
When the trolley is correctly adjusted, the handles
will line up with the users wrists.
1. To check the height, the user should stand
behind the trolley with their arms relaxed by
their side.
Note: Make sure that the user is wearing their
normal indoor footwear before checking the
height.
2. To check the height, the user should stand
behind the trolley with their arms relaxed by
their side.
Note: Make sure that the user is wearing their
normal indoor footwear before checking the
height.
4.6.2 Adjust Trolley Height
If the trolley handles do not line up with the users
wrists, the legs must be adjusted as necessary.
1. To adjust the trolley height, remove the E-Clips,
securing the legs.
2. Adjust each leg to the applicable height and
replace the e-clips.
3. Use the front and rear leg height adjustment
markers to make sure that all legs are adjusted
to the same height.
4. Refer to Section 4.1. Make sure that the front legs
have been re-installed in the correct orientation.
5.0 USING THE DUO WALKING TROLLEY
The Duo Walking Trolley has been designed to slide
forward when under minimal load.
A
B
A
B
1. Use as a normal household trolley pushing the
trolley in front of you (Action A).
2. To stop the trolley the user should push down
the trolley handles (Action B).
3. The trolley can be used as a meal table. When
seated, pull the trolley towards you using the
lower part of the trolley frame. Do not pull the
trolley towards you using the handles, this can
cause the trolley to tip.
4. To stop items from slipping during use, it is
recommended that you use a non-slip mat on
the top tray (refer to Section 11.0 for details).
6.0 CLEANING
1. Remove the trays for cleaning.
2. Wipe clean the trays and frame using a soft,
non-abrasive cloth with a mild detergent or
disinfectant.
3. Make sure wheels and slider ferrules are free
from accumulated debris.

4
7.0 MAINTENANCE
1. Check slider ferrules at regular intervals for
damage, wear or the accumulation of dirt.
Replacement slider ferrules can be purchased
from one of our websites (see details below).
2. Refer to Section 8.0 for details of the available
spares.
3. Check the trolley legs and frame for damage at
regular intervals.
Warning: Do not use the trolley if the legs or
frame are damaged in any way.
4. Please contact your supplier if you require
assistance with the maintenance of the trolley.
Incorrect adjustments can result in serious
injury.
8.0 ACCESSORIES & SPARE PARTS
Upper Tray N43188 x 1
Lower Tray N43199 X 1
E-Clips N43218 X 4
Slider Ferrules N43229 X 2
For more details please visit one of our websites or
call Customer Services (see details below).
9.0 PRODUCT DISPOSAL
This product should be thoroughly cleaned prior to
disposal.
This product is manufactured from metal and plastic
and can be disposed of through Local Authority
Household Waste and Recycling Centres or through
Local Trade Waste Collectors.
10.0 PRODUCT GUARANTEE
NRS Healthcare guarantee this product for a period
of 24 months, from the date of purchase, against
faulty materials and workmanship.
This guarantee does not cover abuse, interference
or tampering with any part of the products. Issues
arising from fair wear & tear and customer misuse
are not covered.
This guarantee covers domestic use only. If the
product is used in commercial or semi-commercial
settings such as care homes, schools, rental or
communal accommodation etc, the guarantee is
valid for one year only. Consumable parts are also
guaranteed for one year only.
Any guarantee issued by NRS Healthcare does not
a󰀨ect your statutory rights.
11.0 REFERENCED PRODUCTS
NRS recommends the following products for use
with the Duo Walking Trolley.
Figure 1: Non-Slip Mat (F17628)
Figure 2: Thermo Mug (N05564)
Figure 3: Shaped Spouted Lid (M18886)
NRS HEALTHCARE Sherwood House,
Cartwright Way, Forest Business Park, Bardon
Hill, Coalville, Leicestershire, LE67 1UB, UK.
NRS HEALTHCARE 4C Altona Road, Blaris
Industrial Estate, Lisburn, Co Antrim,
Northern Ireland BT27 5QB
Tel: Customer Services: [phone] Email: [email protected]
NRS Healthcare is a leading supplier of community equipment and daily living aids.
Please visit one of our websites to view our full range of products:
www.healthcarepro.co.uk or www.completecareshop.co.uk
P23117-UI-5 09-10-2023