Pet Gear PG5727CH User manual

INSTRUCTION MANUAL
“The Other Door®” Steel Crate
PG5727CH/PG5736CH/PG5742CH
To see our full line of products, visit us online at: www.petgearinc.com
CUSTOMER SERVICE HELP DESK
[email protected]
Toll-Free 877-752-9123 - Eastern Standard Time 8am-3pm, Monday through Friday
For The ON-THE-GO Pet™

THE OTHER DOOR STEEL CRATE • PG5727CH/PG5736CH/PG5742CH
2
PARTS LIST
CRATE ASSEMBLY
Step 1. Remove from box.
Step 2. Place crate on ground as shown, so
the PET GEAR logo on the bottom (black part)
is facing toward you. (Figure A.)
Top Locks.
One on each side.
Crate
Wheels
Handle
A. B.
Check that you have all the parts shown BEFORE assembling your product.
If any parts are missing, call Customer Service.
Logo
Step 3. Lift top up to a ninety degree angle. (Figure B.)

THE OTHER DOOR STEEL CRATE • PG5727CH/PG5736CH/PG5742CH 3
CRATE ASSEMBLY
Step 4. Pull the top back so that the side wiring
is extended. (Figure C.)
Step 5. Lift left side up to a ninety degree
angle. (Figure D.)
D.
E.
C.
Base
Step 6. Lift right side up to a ninety degree angle.
(Figure E.)

THE OTHER DOOR STEEL CRATE • PG5727CH/PG5736CH/PG5742CH
4
CRATE ASSEMBLY
Step 7. Flip bottom base and sides ninety degrees toward
the top so the crate is on its side. (Figure F.)
Step 8. Align the interlocking panels (top
panel) and (side panel). See Figure G.
Repeat this on the other side panel.
Step 9. Set crate right side up.
Step 10. Install top lock near the handle. Place lock
as shown in Figure H. Put lock into plastic lock
holder and push down. (Figure I.) Repeat step with
opposite side.
Note: Do not apply excessive force.
Recheck Steps 8 and 9 if lock closes hard.
G.
H.
I.
F.

THE OTHER DOOR STEEL CRATE • PG5727CH/PG5736CH/PG5742CH 5
CRATE ASSEMBLY
USING BUNGEE CORDS
Some of our models now come with bungee cords attached to the bottom of the crate.
These cords help to keep the crate shut when folded.
Step 12. Fasten latch on the left back cage
as shown in Figure K. Repeat on right side.
Note: Do not apply excessive force.
Lift cord up from the
bottom center of the
crate and pull out
toward the sides. Pull cords up from bottom,
around the sides of the crate,
and fasten around the top lock.
J.
K.
Step 11. Latch the locks. Extend the lock downward, then lift up to lock the lock in place (Figure J). If bottom part
does not latch repeat steps 8-11. Pull up lightly on the lock to make sure lock is fastened.
Top lock.

6
RECONNECTING “THE OTHER DOOR”
THE OTHER DOOR STEEL CRATE • PG5727CH/PG5736CH/PG5742CH
These are the necessary steps to reconnect “The Other Door” back onto your steel crate.
Step 1. Place crate with wire side on
the oor (Figure A).
De-clip top and ip down (Figure B).
Step 3. Lay door at as shown
in Figure E. Make sure door
guides are aligned with their
tracks (Figure E) and slide
door into track.
Step 2. Align door at an angle with screw side
facing the crate, as shown in Figure C. Make sure
plastic knobs on both sides are near tracks so
that when the door is straightened, knobs will
click inside tracks and be re-attached (Figure D).
Bottom
Top
Plastic Knob
Door Guide
B.
C.
D.
E.
A.

AVOIDING SUFFOCATION HAZARDS
SETTING UP THE CRATE
Never use plastic shipping bags or other plastic lm as pad covers not sold and intended for that purpose.
They can cause suffocation. This product is not intended for commercial use.
THIS PRODUCT REQUIRES ADULT ASSEMBLY.
Be sure the crate is completely set up before use.
Always follow the instructions in the product instructions to set up the crate.
Before each use, inspect this product for damaged hardware, loose joints, missing parts, or sharp edges.
Do not use the crate if any parts are missing or broken.
Call PET GEAR at 1-877-752-9123 for replacement parts. Use only PET GEAR replacement parts.
Visit our website www.petgearinc.com to view or download the product instructions.
Do not substitute parts.
USING THE CRATE
Remove collar and leashes while using this product. The crate is for playing or sleeping.
When used for playing, never leave pet unattended and always keep pet in view. When used for
sleeping, you must still provide the supervision necessary for the continued safety of your pet.
Always keep the crate away from hazards in the area that may injure your pet.
DO NOT leave pet in product for prolonged periods of time.
DO NOT ATTEMPT TO MOVE CRATE WHEN YOUR PET IS INSIDE.
THE OTHER DOOR STEEL CRATE • PG5727CH/PG5736CH/PG5742CH 7

THE OTHER DOOR STEEL CRATE • PG5727CH/PG5736CH/PG5742CH
WARNING!
REPLACEMENT PARTS
Use only PET GEAR replacement parts.
Please have your model number ready before calling.
You can also request parts: http://www.petgearinc.com/main.asp?sel=2
FOR PETS ONLY.
Not intended to be used as a restraining device for aggressive or dangerous animals that dig, chew or paw
aggressively. Do not leave your pet unattended. PET GEAR is not liable for any damage caused by aggressive,
destructive, immature or untrained animals. Do not use near an open or exposed ame. Failure to follow these
warnings and the instructions could result in serious injury or death.
PO Box 99∙West Rutland, VT∙05777∙877-752-9123∙www.petgearinc.com
8