real living ROCKBRIDGE GBO22-019-2 User manual

ROCKBRIDGE 5PC ALL WEATHER WICKER SET
1 SOFA AND 2 OTTOMAN
ASSEMBLY INSTRUCTIONS
ITEM# : GBO22-019-2 / GBO22-019-2NAVY / GBO22-019-2B
SKU# : 810544462 / 810555261 / 810555287
Need help? We are here for you! 1-888-733-8169 Toll Free
Or email us at customers[email protected],custo[email protected]
[e-mail]

GENERAL BEST PRACTICES FOR ASSEMBLY:
Read all instructions before starting
Clear a flat covered space to begin assembly
Always best to do it with a friend
Note that hardware required is provided for every step
Pay attention to orientation
Number of the hardware corresponds to its letter in the package
Helpful hints provided along the way
WARNINGS:
Use the correct screws as indicated. All screws should be hand tightened until the complete piece is
assembled ( This will make the assembly process much easier ). Once the piece is fully assembled, then go
back and tighten all screws with provided tool.
Keep all children and pets away from assembly area. Children and pets should be supervised when they are in the area of the
product construction.
Keep assembly area at least 6 feet from any obstruction such as a fence, garage, house, overhanging branches, laundry line or
electrical wires.
Some parts may contain sharp edges. When assembling and using this product, basic safety precautions should always be followed
to reduce the risk of personal injury and damage to the product. Please read all instructions before assembly and use.
The sofa and ottomans are not to be used for standing purposes and will not function as a stool or step-ladder. Use on even
surfaces only.
The sofa is used at weight of 600lb (270kg), the ottoman is used at weight of 250lb(113kg). Improper use of
the products or failure to use as directed may result in injury. Not intended for commercial use.
MAINTENANCE
STAIN RESISTANT CUSHIONS CARE —— KEEP THE CUSHIONS IN STORAGE ON RAINY DAYS.
SPILLS: Immediately wipe up the spill using a white damp cloth. Repeat process if necessary until stain is gone.
Allow cushions to air dry.
FABRIC CARE: Hand wash cold, non-chlorine bleach when needed, lay flat to dry. Cool iron if necessary. Do not dry clean.
ALL WEATHER WICKER PRODUCT CARE
Before using, clean the product completely with a soft dry towel. When not in use, wipe free of any dirt or loose objects, wash with a
mild solution of soap and water, rinse thoroughly and dry completely. Do not use strong detergent or abrasive cleaners. Screws can
be loosen over a peirod of usage, please check the screws occasionally and re-tighten if necessary.

PARTS LIST
A1
A2
B
1PC Left Arm 1PC Right Arm 1PC Sofa back
C
H
I
1PC Seat Panel 3PC Seat Cushion 3PC Back Cushion
HARDWARE LIST
D
E
F
12PC Washer 4PC Screw(φ6x20mm) 8PC Screw(φ6x32mm)
G
1PC Allen Wrench

STEP 1
Secure sofa back (B) to left arm (A1) with 2 washers
(D) and 2 screws (E) by using allen wrench (G).
Do not fully tighten now.
STEP 2
Secure right arm (A2) to assembled sofa back (B)
with 2 washers (D) and 2 screws (E) by using allen
wrench (G). Do not fully tighten now.
A1
B
A2
A1
B

STEP 3
Secure seat panel (C) to assembled sofa arms (A1.
A2) with 4 washers (D) and 4 screws (F) by using
allen wrench (G). Do not fully tighten now.
STEP 4
Secure seat panel (C) to assembled sofa back (B)
with 4 washers (D) and 4 screws (F) by using allen
wrench (G). Verify the alignment and adjust, then
tighten all the screws.
A2 C
A1
B
C

STEP 5
Put seat cushions (H) and back cushions (I) on the
sofa. The sofa is assembled.
I
H

PARTS LIST
J
K
L
M
2PC Ottoman Leg 2PC Side Panel 1PC Ottoman Top 1PC Cushion
HARDWARE LIST
D
N
G
12PC Washer 12PC Screw(φ6x30mm) 1PC Allen Wrench
STEP 1
Attached 2 ottoman legs (J) to top (L) by using 4
screws (N) and 4 washers (D) with allen wrench
(G). Do not fully tighten now.
J
L
J

STEP 2
Attached 2 side panels (K) to 2pcs ottoman legs
(J) by using 8 screws (N) and 8 washers (D) with
allen wrench (G). Do not fully tighten now.
STEP 3
Place the ottoman upside down and fully tighten
all screws after making sure it is stable.
Then put cushion (M) on it. Finished!
K
K
J
D N G
J
M