Roland Advanced Jet AJ-1000 Operating and maintenance manual

SERVICE NOTES
Contents
4 Adjustment
4-1 SPECIAL TOOLS
............................................... 
4-2 SERVICE MODE ............................................... 
4-3 HOWTO UPGRADE FIRMWARE ............................. 
4-4 HEAD ALIGNMENT ............................................. 
4-5 CAPPING POSITION ADJUSTMENT ......................... 
4-6 LINEAR ENCODER SETUP ................................... 
4-7 PAPER SIDE SENSOR ADJUSTMENT ........................ 
4-8 CALIBRATION (FEEDING DIRECTION) ...................... 
4-9 BELT TENSION ADJUSTMENT ............................... 
4-10 BELT POSITION ADJUSTMENT ............................... 
4-11 NETWORK BOARD INITIALIZE ............................... 
4-12 LIMIT POSITION & MAX SCAN WIDTH INITIALIZE .......... 

5 Supplemental Information
5-1 SENSOR MAP
.................................................. 
5-2 HOWTO REMOVE THE AIR IN THE INK LINE .............. 

6 Troubleshooting
6-1 WHITE FINE LINE / BANDING / MISSING DOT / 
SCRATCHY PRINTING / BLURRED PRINTING
..............
6-2 PARTICULAR COLOR DOES NOT PRINT AT ALL............
6-3 SHIFTING IN PRINTING/COLOR SHIFTING .................
6-4 INK DROPS ONTHE MEDIA ..................................
6-5 VERTICAL BANDING ..........................................
6-6 MISSING DOT OR DEFLECTED-FIRED DOT APPEARS 
WHEN PERFORMING PRINTING WITH LONG DELAY .....
6-7 INK EMPTY MESSAGE APPEARS 
EVEN IF THE INK HAS NOT RUN OUT .......................
6-8 THE INK OR MAINTENANCE LIQUID NEVER COMES
BY PERFORMING FILL INK ....................................
6-9 MOTOR ERROR ................................................
6-10 HEATER TEMPERATURE DOES NOT GO UP ...............
6-11 DRYER TEMPERATURE DOES NOT GO UP ................
6-12 THE BLOWER FAN DOES NOT MOVE .......................
6-13 THE TAKE-UP/FEED OUT UNIT DOES NOT MOVE .........
6-14 ERROR MESSAGE ..............................................
6-15 SERVICE CALL ..................................................

7 Service Activities
7-1 INSTALLATION CHECK LIST
.................................. 
7-2 MAINTENANCE CHECK LIST .................................
7-3 PREPARATION FOR TRANSPORTATION 1 ..................
7-4 PREPARATION FOR TRANSPORTATION 2 ..................
7-5 SPECIFICATIONS ..............................................
4-1
4-2
4-17
4-20
4-29
4-31
4-32
4-35
4-37
4-43
4-55
4-57
7-1
7-15
7-16
7-24
7-35
6-1
6-3
6-3
6-4
6-4
6-4
6-5
6-6
6-7
6-8
6-9
6-10
6-10
6-11
6-11
5-1
5-5
Windows and MS-DOS are registered trademark or trademark of Microsoft Corporation in the United States and/or other countries. First Edition
Unauthorized coplying or transferral, in whole or in part, of this manual is prohibited.
70010-00
1 Structure & Spare Parts
1-1 COVERS .......................................................
1-2 FRAME .........................................................
1-3 CARRIADGE ...................................................
1-4 DRIVE UNIT ....................................................
1-5 BED ............................................................
1-6 CHASSIS .......................................................
1-7 PINCH ROLLER...............................................
1-8 MAINTENANCE LIQUID CARTRIDGE .......................
1-9 WIPER SYSTEM ...............................................
1-10 INK SYSTEM ...................................................
1-11 SUB TANK SYSTEM ...........................................
1-12 DRYER .........................................................
1-13 STAND ..........................................................
1-14 TU UNIT ........................................................
1-15 TU ROLL ........................................................
1-16 ACCESSORIES ................................................
2 Electrical Section
2-1 WIRING MAP ...................................................
2-2 MAIN BOARD ..................................................
2-3 HEAD BOARD ..................................................
2-4 SERVO BOARD ................................................
2-5 HEATER BOARD ...............................................
2-6 PUMP DRIVE BOARD .........................................
2-7 SUB BOARD ...................................................
2-8 MAINTENANCE PARTS LIST .................................
3 Replacement of Main Parts
3-1 HEAD REPLACEMENT ........................................
3-2 WIPER REPLACEMENT .......................................
3-3 CAP TOP REPLACEMENT ....................................
3-4 CARRIAGE MOTOR REPLACEMENT ........................
3-5 SUPPLY PUMP REPLACEMENT .............................
3-6 INK TUBE REPLACEMENT ...................................
3-7 BOARDS REPLACEMENT ....................................
(Main Board / SW Power Supply)
3-8 BATTERY REPLACEMENT ....................................
3-9 CARRIAGE BELT REPLACEMENT ...........................
3-10 ENCODER SCALE REPLACEMENT .........................
3-11 TU BOARD REPLACEMENT ..................................
1-1
1-3
1-5
1-7
1-9
1-11
1-13
1-14
1-15
1-17
1-19
1-20
1-21
1-23
1-25
1-27
2-1
2-3
2-11
2-19
2-26
2-34
2-42
2-54
3-3
3-11
3-13
3-18
3-23
3-30
3-40
3-50
3-53
3-59
3-62

Revision
NO. Date Description of Changes Approval Issued
0 2006.7.4 First Edition Kato Mabuchi

To Ensure Safe Work
About and Notices.
Used for instructions intended to alert the operator to the risk of death
or severe injury should the unit be used improperly.
Used for instructions intended to alert the operator to the risk of injury
or material damage should the unit be used improperly.
* material damage refers to damage or other adverse effects caused
with respect to the home and all its furnishings, as well to domestic
animals or pets.
About the Symbols
The symbol alerts the user to items that must never be carried out (are
forbidden). The specific thing that must not be done is indicated by the design
contained within the circle.
The symbol at left means not to touch.
The symbol alerts the user to things that must be carried out. The specific
thing that must be done is indicated by the design contained within the circle. The
symbol at left means the power-cord plug must be unplugged from the outlet.
The symbol alerts the user to important instructions or warnings. The specific
meaning of the symbol is determined by the design contained within the triangle.
The symbol at left means “danger of electrocution”.
In addition to the and symbols, the symbols shown below are also used.
: Tips and advise before the adjustment.

About the Labels Affixed to the Unit
These labels are affixed to the body of this product.
The following figure describes the location.
Electric charge.
Do not touch when power is on.
Do not recharge, short-circuit,
disassemble the lithium battery, nor
put it into fire.
It may cause heat, explosion and fire.
Put tape around the lithium battery
for insulation for disposal or
preservation.
It may cause heat, explosion and fire.
Turn off the primary power SWs for
the Printer and Dryer before
servicing.
HIGH VOLTAGE,
HANDLING ATTENTION
• Do not touch during power on
Electric shock, Compornents damage
• Do not repair. Replace power unit.
• Do not replace fuse. Can not be recovered.
The wiring terminal untended for connection of the
protective earthing conductor associated with the
supply wiring.
Do not disconnect the cable of this terminal except the
time of replacement.

1 Structure & Spare Parts
1-1 COVERS
1-1
22
6
47
19
11
27
42
21
15
13
20
12
51
2850 24
24
21
30
43
49 25
18
5
46
52
23
48
40
3
17
16
14
52
45
2
44
10
9
7
1
18
9
7
26
36
41
31
32
29
45
34
33
39
37
35
38
4
S3
S4
S6
S3
S3
S3
S12
S8S15
S1
S5
S17
S16
S14
S11
S9
S14
S2
S5
S1
S1
S5
S14
S3
S3
S3
S6
S3
S3 S3
S1
S1
S5
S5
S3 S3
S3
S3
S3
S3
S3
S3
S12
S12
S3
S3
S4
S7
S13
S11
S3
S6
S17
S10
S10
S6

1-1 COVERS
PARTS LIST -Main Parts- PARTS LIST -Su
pp
lemental Parts
-
Parts No. Parts Name Parts No. Parts Name
1 11879116 ABSORBER,CK-7 S1 31029803AS BUSH SET,ROLL 3*5 20 PCS.
2 W700105610 ASSY,PANEL BOARD AJ-1000 S2 31289105AS CUPSCREW SET, M3*6 BC 100 PCS.
3 1000000931 BUSH,HSCPF3H-B-50 S3 31289111AS CUPSCREW SET, M4*6 NI 100 PCS.
4 1000000644 CABLE-ASSY F-COVER AJ-1000 S4 31289112AS CUPSCREW SET,M3*10 NI 100 PCS.
5 1000000818 COVER,FRONT F AJ-1000 S5 31289107 CUPSCREW SET,M3*12 NI 100 PCS
6 1000000827 COVER,INT SW AJ-1000 S6 31289102AS CUPSCREW SET,M3*6 NI 50 PCS.
7 1000000843 COVER,IS AJ-1000 S7 31149601 RING SET,PUSH-ON CS CSTW-3 100 PCS
8 1000000846 COVER,IS L AJ-1000 S8 31019149 SCREW SET,BINDING M2.3*8 3C 100PCS
9 1000000845 COVER,MIDDLE AJ-1000 S9 31019116AS SCREW SET,BINDING M3*6 BC 100 PCS
10 1000000844 COVER,PANEL AJ-1000 S10 31049171AS SCREW SET,CAP M3*12 NI 50 PCS.
11 1000000814 COVER,RAIL AJ-1000 S11 31049170AS SCREW SET,CAP M3*8 NI 50 PCS.
12 1000000815 COVER,RAIL F AJ-1000 S12 31049169AS SCREW SET,CAP M4*8 BC+PW 4*10*0.8 20PC
13 1000000820 COVER,SUBTANK AJ-1000 S13 31089110AS SCREW SET,PAN M3*4 C+PW 100 PCS.
14 1000000338 COVER,SUPPORT BRACKET LL AJ-1000 S14 31019703 SCREW,BINDING P-TIGHT 3*8BC 100P
15 1000000339 COVER,SUPPORT BRACKET LU AJ-1000 S15 31069104 SCREW,CAP M4*6+FL C
16 1000000336 COVER,SUPPORT BRACKET RL AJ-1000 S16 31049156 SCREW,CAP M6*8 BC+FLNGE
17 1000000337 COVER,SUPPORT BRACKET RU AJ-1000 S17 31139104 SCREW,PLAPOINT M4*6 BK FE
18 1000000817 COVER,TOP L AJ-1000
19 1000000816 COVER,TOP R AJ-1000
20 1000001286 COVER,TUBE CHANGE AJ-1000
21 1000000828 COVER,UNDER I/S L AJ-1000
22 1000000833 COVER,UNDER I/S R AJ-1000
23 1000000830 COVER,UNDER PANEL AJ-1000
24 12239406 CUSHION,TM-96-6
25 11959122 DAMPER,OWHF10-2.7NLW
26 22225102 ESCUTCHEON SJ-600
27 1000000932 HANDLE,THA-31-14TAP
28 22325106 HINGE,001
29 22325113 HINGE,006
30 1000000826 HOOK,INT SW AJ-1000
31 1000001029 KEY TOP,D14 DG AJ-1000
32 1000000111 KEY TOP,D14 WH AJ-1000
33 22535287 LABEL,CAUTION CARRIAGE #LA266
34 22535286 LABEL,CAUTION COVER #LA265
35 22535498 LABEL,CLAMP MEDIA SJ-1000#LA716
36 1000000953 LABEL,EMBLEM LOGO ROLAND
37 22535390 LABEL,EMERGENCY STOP #LA496
38 22535460 LABEL,ENERGY STAR COLOR #LA668
39 1000001099 LABEL,HARMFUL FIRE #LA915
40 1000000952 LABEL,SET MEDIA AJ-1000#LA898
41 12399102 MAGNET CATCHER TL-105
42 1000000829 PLATE,COVER LOWER L AJ-1000
43 1000000831 PLATE,COVER LOWER R AJ-1000
44 1000000344 PLATE,COVER PANEL AJ-1000
45 1000000832 PLATE,NUT RECTANGLE AJ-1000
46 1000000821 PLATE,WINDOW COVER F AJ-1000
47 22295299 SHAFT,COVER DAMPER SJ-1000
48 1000000840 SHEET,PANEL AJ-1000
49 1000000825 STAY,COVER DAMPER AJ-1000
50 1000000822 STAY,COVER RAIL F AJ-1000
51 1000000824 STAY,HINGE COVER F AJ-1000
52 1000000823 STAY,STOPPER PLATE COVER AJ-1000
1-2

1-2 FRAME
1-3
32
78
33
59
60
16
28
66
25
470
73 50
48 42
37
53
56
55
41
39
40
31
54
38
10
69
49
52
51
58
14 77
44
46
13
3
72
72
8
75 36
34
29
29
61
71
47
1
45
13
65
68
67
5
12
76
6
63
15
2
40
39
26
17
7
23
24
35
79
64
3021
62
57
11
11
74
19
20
22
43
9
18 27
6
67
S18
S19
S4
S11
S4
S16
S19 S19
S5
S19 S19 S19
S5
S19
S19
S17
S19
S19
S17
S19
S3
S12
S2
S1
S1
S1
S1
S2
S2
S2
S2
S2
S2
S2
S2
S2
S2
S13
S7
S3
S3 S3
S3
S3
S3
S3
S3
S3 S3
S16
S14
S17
S17
S17
S9
S10
S10
S9
S10
S10
S8
S8
S3
S10
S6
S14
S2
S14
S10
S6
S19
S3
S2
S17
S12
S10
S20
S17
S14
S8
S10
S3
S5
S14
S11
S12
S19
S19
S19
S19
S15
S5
S9
S19
S19
S3 S19
S17
S17
S17
S17
S17
S17
S17
S14

1-2 FRAME
PARTS LIST -Main Parts-
Parts No. Parts Name Parts No. Parts Name
1 12359113 ABSORBER TK-2320 53 12139657 GUIDE,INK FUNNEL PE 6-316-03
2 6700109040 ASSY,FEED MOTOR AJ-1000 54 1000000838 HOLDER,DRYER BOARD COVER AJ-1000
3 W700105210 ASSY,HEATER JUNCTION BOARD AJ-1000 55 1000000938 HOLDER,DRYER MID AJ-1000
4 W7001057A1 ASSY,MOTSENS JUNCTION BOARD AJ-1000 56 1000000741 HOLDER,FUNNEL AJ-1000
5 W700105720 ASSY,PINCH ORG BOARD AJ-1000 57 1000000699 HOLDER,I/C CASE SIDE AJ-1000
6 1000000910 ASSY,ROLLER SHAFT R AJ-1000 58 22115121 HOUSING,R-BEARING FRAME FJ-540
7 23415133 ASSY,THERMISTOR CABLE SP-300 59 22485104 KNOB FJ-50
8 W700105220 ASSY,THERMISTOR JC BOARD AJ-1000 60 1000000731 LEVER,CAM PINCH AJ-1000
9 1000001964 ASSY,TUBING 10*400MM AJ-1000 61 1000000733 LEVER,SHAFT AJ-1000
10 1000000727 BASE,AL AJ-1000 62 12399102 MAGNET CATCHER TL-105
11 1000000749 BASE,BED AJ-1000 63 1000000732 PLATE,LEVER LINK AJ-1000
12 1000000917 BASE,PLATE BL-ROLLER L AJ-1000 64 1000001051 SHUTTER,THERMISTOR AJ-1000
13 22355807 BASE,RAIL FJ-540 65 22175521 SPRING,PINCH ROLLER 930 FJ-540
14 22175870 BEARING 10-19ZZ 66 22035161 STAND,LEVER FJ-500
15 12159573 BUSH,80F-0603 67 1000001052 STAY,BAR UNIC AJ-1000
16 12159563 BUSH,80F-1006 68 22715466 STAY,FA-CODER SP-540V
17 1000000611 CABLE-ASSY ALL-THERM AJ-1000 69 1000000738 STAY,FRAME SIDE L AJ-1000
18 1000000627 CABLE-ASSY CLEAN-LIQ AJ-1000 70 1000000735 STAY,FRAME SIDE R AJ-1000
19 1000000613 CABLE-ASSY DRYER JUNC AJ-1000 71 1000000740 STAY,HEATER JUNCTION BOARD AJ-1000
20 1000000614 CABLE-ASSY D-THERM JUNC AJ-1000 72 22715429 STAY,HTR COVER F SJ-1000
21 1000000644 CABLE-ASSY F-COVER AJ-1000 73 1000000934 STAY,MOTSENS JUNCTION AJ-1000
22 1000000581 CABLE-ASSY FEED MOTOR AJ-1000 74 1000000933 STAY,RAIL GUIDE LB AJ-1000
23 1000000609 CABLE-ASSY H-JUNCTION A AJ-1000 75 1000000739 STAY,TERMISTOR BOARD AJ-1000
24 1000000610 CABLE-ASSY H-JUNCTION B AJ-1000 76 1000000737 SUPPORT,BU-ROLLER AJ-1000
25 1000000643 CABLE-ASSY M-COVER R AJ-1000 77 1000000736 SUPPORT,FRAME L AJ-1000
26 1000000608 CABLE-ASSY PP-ORG SENS AJ-1000 78 1000000734 SUPPORT,FRAME R AJ-1000
27 1000000639 CABLE-ASSY SIGNAL JUNC B AJ-1000 79 1000001050 SUPPORT,THERMISTOR AJ-1000
28 23415266 CABLE-ASSY,ESD SJ-1000
29 21745109 COLLAR,LEVER FJ-540
30 13169102 COVER SW R (AVT32344)
31 1000000839 COVER,DRYER JUNCTION AJ-1000 PARTS LIST -Supplemental Parts-
32 1000000819 COVER,FRAME MID B AJ-1000 Parts No. Parts Name
33 1000000927 COVER,INNER I/S TOP AJ-1000 S1 31029101 BUSH,NB-19
34 22025963 COVER,IS COVER SENSOR FJ-540 S2 31289111AS CUPSCREW SET, M4*6 NI 100 PCS.
35 1000001049 COVER,THERMISTOR AJ-1000 S3 31289102AS CUPSCREW SET,M3*6 NI 50 PCS.
36 1000000812 COVER,UNDER CHASSIS AJ-1000 S4 31119904 PIN,SPRING 2.5*8 SUS STRAIGHT 50 PCS
37 1000000813 COVER,UNDER CHASSIS R AJ-1000 S5 31129102 PIPE,POLYCA 4*8*10
38 1000000834 COVER,UNDER DRYER L AJ-1000 S6 31149705 RING,E ETW-7 SUS
39 1000000837 COVER,UNDER DRYER MID L AJ-1000 S7 31159901AS RIVET SET,NYLON P3045W 20 PCS.
40 1000000836 COVER,UNDER DRYER MID S AJ-1000 S8 31409702 SADDLE,LOCKING EDGE LES-1010
41 1000000835 COVER,UNDER DRYER R AJ-1000 S9 31409801AS SADDLE,LOCKING WIRE LWS-0711Z 20
42 12399352 FILTER(E) FRC-45-12-6.5 S10 31409811 SADDLE,LOCKING WIRE LWS-1211Z
43 12399334 FILTER(E),TFC-16-8-13 S11 31019149 SCREW SET,BINDING M2.3*8 3C 100PCS
44 21995124 FLANGE,MOTOR FEED FJ-540 S12 31019116AS SCREW SET,BINDING M3*6 BC 100 PCS
45 1000000851 FRAME,FEED MOTOR AJ-1000 S13 31049170AS SCREW SET,CAP M3*8 NI 50 PCS.
46 1000000730 FRAME,MIDDLE L AJ-1000 S14 31049174AS SCREW SET,CAP M4*15 NI 20 PCS.
47 1000000729 FRAME,MIDDLE R AJ-1000 S15 31049175AS SCREW SET,CAP M4*20 NI 20 PCS.
48 1000000728 FRAME,PINCH LEVER AJ-1000 S16 31049137AS SCREW SET,CAP M4*25 BC 20 PCS.
49 1000000811 FRAME,SIDE L AJ-1000 S17 31049169AS SCREW SET,CAP M4*8 BC+PW 4*10*0.8 20PC
50 1000000810 FRAME,SIDE R AJ-1000 S18 31199701AS SCREW SET,SET WP M3*3 C 20 PCS.
51 21685119 GEAR,S300S10 FJ-540 S19 31049117 SCREW,CAP M4*12 BC+PW 4*9*0.8
52 25095120 GRIT ENCODER TS5217N561 FJ-540 S20 31069104 SCREW,CAP M4*6+FL C
1-4

1-3 CARRIAGE
1-5
24
46
52
50
30
31
1
46
39
21
10
29
12
48
42
51 13
35
47
22
35
56
7
43
11
54
55
41
25
38
8
34
44
14 58
58
57
37
27
49
9
47
23
32
23
17
6
33
19
26
53
40
20
5
15
36
45
28
16
18
4
S4
S4
S9
S4
S10
S1
S11
S4
S4
S4
S4
S4
S4
S4 S3
S4
S4
S4
S4 S4
S4
S4
S7
S18
S13
S13
S13
S8
S8
S2
S2
S2
S2
S4
S11
S11
S11
S17
S12
S14
S9
S9
S6
S6
S5
S5
S18
S15
S10
S16
S4
S6
S18
S18 S4
S9
S9
S6
S7

1-3 CARRIAGE
PARTS LIST -Main Parts-
Parts No. Parts Name Parts No. Parts Name
1 1000000857 ADAPTER,HEAD BIAS AJ-1000 51 1000000863 SPRING,Z NUT AJ-1000
2 1000000521 ADAPTER,SCREW FLEX AJ-1000 52 1000000854 STAY,ALIGN HEAD AJ-1000
3 1000000522 ADAPTER,TUBE JOINT AJ-1000 53 1000000869 STAY,CARRIAGE BOARD AJ-1000
4 W700105630 ASSY,HEAD FLEX BOARD AJ-1000 54 1000000873 STAY,ENCODER SENS AJ-1000
5 1000001354 ASSY,I/J HEAD SET AJ-1000 55 1000000872 STAY,HOLDER BELT AJ-1000
6 W700105710 ASSY,LINEAR ENCODER BOARD AJ-1000 56 1000000874 STAY,JOINT AUTOCUTTER AJ-1000
7 W700105760 ASSY,PAPERSIDE SENSOR BOARD AJ-1000 57 1000000871 STAY,U/D SENSOR AJ-1000
8 W7001057B0 ASSY,PRINT CARRIAGE BOARD AJ-1000 58 1000000866 STOPPER,Z BUSH AJ-1000
9 1000001254 ASSY,TUBE SJ-RDG4*6 LINK6 AJ-1000
10 1000000852 BASE,CARRIAGE AL AJ-1000
11 1000000862 BASE,HOLDER CARRIAGE AJ-1000
12 1000001283 BASE,Z SLIDE AJ-1000 PARTS LIST -Supplemental Parts-
13 1000000937 BUSH,80F-0805 Parts No. Parts Name
14 12159625 BUSH,S8-296 S1 31029824 BUSH SET,ROLL 6*3 50 PCS
15 1000000655 CABLE-ASSY HEAD HEATER AJ-1000 S2 31289111AS CUPSCREW SET, M4*6 NI 100 PCS.
16 1000000656 CABLE-ASSY HEAD MOTOR AJ-1000 S3 31289109AS CUPSCREW SET,M3*4 NI 100 PCS.
17 1000000657 CABLE-ASSY HEAD ORG AJ-1000 S4 31289102AS CUPSCREW SET,M3*6 NI 50 PCS.
18 1000000616 CABLE-CARD 30P1 310L BB HIGH-V S5 31129102 PIPE,POLYCA 4*8*10
19 1000000617 CABLE-CARD 36P1 4900L BB HIGH-V S6 31299102AS RIVET SET,NYLON P2655B 20 PCS.
20 11769118 CLAMP,FCM2-S6-14 S7 31159901AS RIVET SET,NYLON P3045W 20 PCS.
21 1000000856 COLLAR,ORIGIN HEAD AJ-1000 S8 31409702 SADDLE,LOCKING EDGE LES-1010
22 1000000877 COUPLING,G2J6-5 S9 31409801AS SADDLE,LOCKING WIRE LWS-0711Z 20
23 22025646 COVER,BELT HOLDER EGX-600 S10 31019148AS SCREW SET,BINDING M2.6*4 C 100PCS
24 1000000876 COVER,IJ-CARRIAGE AJ-1000 S11 31019121 SCREW SET,BINDING M3*20 NI 100 PCS
25 1000000878 COVER,PRINT CARRIAGE BOARD AJ-1000 S12 31049170AS SCREW SET,CAP M3*8 NI 50 PCS.
26 1000000879 COVER,SIDE CARRIAGE BOARD AJ-1000 S13 31049174AS SCREW SET,CAP M4*15 NI 20 PCS.
27 1000000769 COVER,TKPO180-2B R100-L115 S14 31089110AS SCREW SET,PAN M3*4 C+PW 100 PCS.
28 12399352 FILTER(E) FRC-45-12-6.5 S15 31199701AS SCREW SET,SET WP M3*3 C 20 PCS.
29 1000000867 FRAME,CARRIAGE SIDE R AJ-1000 S16 31229103AS SCREW SET,TRUSS M2*6 NI 100 PCS
30 1000000868 FRAME.CARRIAGE SIDE L AJ-1000 S17 31019703 SCREW,BINDING P-TIGHT 3*8BC 100P
31 1000000855 GUIDE,HEAD BIAS AJ-1000 S18 31069104 SCREW,CAP M4*6+FL C
32 21655232 HOLDER,BELT EGX-600
33 1000000765 HOLDER,CABLE AJ-1000
34 21655296 HOLDER,CUTTER SJ-1000
35 1000000859 HOLDER,GUIDE Z AJ-1000
36 1000000520 HOLDER,RING O TYPE-E AJ-1000
37 22435106 MOTOR,103-593-1041
38 21575126 NUT,TABLE FJ-540
39 1000000853 PLATE,GND AJ-1000
40 1000000930 PLATE,HEAD HEATER AJ-1000_01
41 1000000865 PLATE,MOTOR HEAD U/D AJ-1000
42 1000000861 PLATE,NUT AJ-1000
43 1000000870 PLATE,ORIGIN CARRIAGE AJ-1000
44 11889107 R-BEARING,D10S6(B3FL)
45 15229506 SENSOR INTERRUPTER,GP1A05A5
46 1000000880 SET-SCREW,BSR4*16
47 1000000864 SHAFT,GUIDE Z AJ-1000
48 1000000860 SHAFT,SCREW M8 AJ-1000
49 1000000790 SPRING,CAP HEAD AJ-1000
50 1000000875 SPRING,SET HEAD BIAS AJ-1000
1-6

1-4 DRIVE UNIT
1-7
17
26
38
44
18 51
11
37
47
42
7
49
10
3
6
9
12
55 3
4
1
29
33
48
22
210
43
50
51
30
27
46 32
31
12
13
55
4
4
6
8
56 12
9
50
24
19
41
28 23
40
2
10
912
56
54
14
21
15 45
37
45
35 36
39
52
25
5
25
53
16
20
25
34
S15 S12
S1
S5
S3
S9
54
S10
S16
S16
S7
S16
S13
S8
S2
S2 S7
S15
16
14
S16
S16
S16
S16
S16
S16
S6
S6
S6
S6
S6
S6 S6
S6
S6
S6
S6
S6
S16
S16
S4
S4
S6
S4
S4
S12
S12 S12
S3
S12
S6
S6
S2
S2
S12
S2
S9
S7
S9
S9
S16
S8
S10
S15
S10
S14
S14
S14
S11
S5
S11
S16

1-4 DRIVE UNIT
PARTS LIST -Main Parts-
Parts No. Parts Name Parts No. Parts Name
1 12359113 ABSORBER TK-2320 51 1000000896 STAY,RAIL GUIDE AJ-1000
2 22805542 ASSY,PULLEY T79P2S16 SJ-1000 52 1000000850 STAY,SUPPORT DRIVE SHAFT AJ-1000
3 W700105330 ASSY,PUMP FLEX A BOARD AJ-1000 53 1000000767 STAY,TUBE AJ-1000
4 W700105340 ASSY,PUMP FLEX B BOARD AJ-1000 54 22135441 STOPPER,LINEAR SCALE FJ-540
5 6700049030 ASSY,SCAN MOTOR SJ-1045EX 55 22245124 STOPPER,SHAFT SQUARE SJ-1000
6 22355807 BASE,RAIL FJ-540
7 1000000848 BASE,SCAN MOTOR AJ-1000
8 1000001046 BASE,SHAFT SQUARE AJ-1000
9 22845171 BASE,SHAFT SQUARE SJ-1000 PARTS LIST -Supplemental Parts-
10 22175815 BEARING F8-16ZZ Parts No. Parts Name
11 1000000889 BELT,150S2M3768LW-C S1 31049155AS CAP-SCREW,3*12NI WSH 3*6*0.5
12 12529104 BUSH,80F-1410 S2 31049117 CAP-SCREW,4*12 NI WSH 4*9*0.8
13 1000001068 BUSH,80F-1610 S3 31379101 CLAMP,FLAT CABLE FCS-50P
14 1000000635 CABLE-ASSY SCAN MOTOR AJ-1000 S4 31289111AS CUPSCREW SET, M4*6 NI 100 PCS.
15 1000000622 CABLE-CARD 40P1 3750L BB HIGH-V S5 31289107 CUPSCREW SET,M3*12 NI 100 PCS
16 11769118 CLAMP,FCM2-S6-14 S6 31289102AS CUPSCREW SET,M3*6 NI 50 PCS.
17 1000001285 COVER,FEED MOTOR AJ-1000 S7 31129102 PIPE,POLYCA 4*8*10
18 1000000841 COVER,INNER R AJ-1000 S8 31149704AS RING SET,E-RING ETW-6 SUS 100 PCS
19 1000000769 COVER,TKPO180-2B R100-L115 S9 31299102AS RIVET SET,NYLON P2655B 20 PCS.
20 12399352 FILTER(E) FRC-45-12-6.5 S10 31409702 SADDLE,LOCKING EDGE LES-1010
21 12399334 FILTER(E),TFC-16-8-13 S11 31409811 SADDLE,LOCKING WIRE LWS-1211Z
22 21685149 GEAR,H235S20(B8)T2 S12 31049174AS SCREW SET,CAP M4*15 NI 20 PCS.
23 22135602 GUIDE,CABLE FJ-500 S13 31049137AS SCREW SET,CAP M4*25 BC 20 PCS.
24 1000000387 GUIDE,CABLE POM AJ-1000 S14 31199704AS SCREW SET,SET WP M3*8 BC 20 PCS.
25 1000000766 GUIDE,HEAD FLEXCARD AJ-1000 S15 31239103AS SCREW SET,W-SEMS M3*8 BC+PW 50PCS
26 1000000282 HOLDER,IDLE PULLEY AJ-1000 S16 31069104 SCREW,CAP M4*6+FL C
27 21655131 HOLDER,LINEAR SCALE CJ-70
28 1000000553 L-BEARING,SSR15XW2GE+3620LY
29 1000000901 PLATE,GUIDE CABLEVEYOR AJ-1000
30 22055316 PLATE,LINEAR SCALE CJ-70
31 22055679 PLATE,MOTOR C9M SJ-1000
32 21565105 P-ROLLER FD8S3(B15L30)
33 21975163 PULLEY,T79P2S16(B27C45.5)
34 1000000893 RAIL,CABLE AJ-1000
35 1000000897 RAIL,CABLE R AJ-1000
36 1000000895 RAIL,CABLE UPPER AJ-1000
37 1000000890 RAIL,GUIDE AJ-1000
38 1000000898 RAIL,LINEAR SCALE AJ-1000
39 11519113 RING,O 1AS-6
40 15229506 SENSOR INTERRUPTER,GP1A05A5
41 1000000894 SHAFT,SQUARE AJ-1000
42 22295286 SHAFT,Y DRIVE PULLEY SJ-1000
43 22295287 SHAFT,Y IDLE PULLEY SJ-1000
44 1000000892 SHEET,LINEAR SCALE AJ-1000
45 1000000899 SHEET,RAIL CABLE AJ-1000
46 22175122 SPRING,BACK UP PNC-960
47 22175157 SPRING,C P-ROLLER CM-500
48 22715431 STAY,GEAR COVER SJ-1000
49 1000000849 STAY,PRINT ORIGIN SENS AJ-1000
50 22715341 STAY,RAIL CABLE RIGHT FJ-540
1-8

1-5 BED
1-9
25
32
20
5
5
28
25
8
6
11
23 8
2
126 27
28
16
29
23
8
19
3
8
4
16
30
30
29
12
13
10
9
22
17
14
14
15
31
77
7
21
18
18
24 24
S3
S7
S8
S13
S3
S7
S3
S3
S3
S3
S1
S1
S1
S13
S6
S6
S5
S5
S5
S12
S12
S4
S3
S8 S2
S12
S2
S8
S15
S4
S5 S12
S14
S13
S13
S8
S9
S9
S11
S10
S12
S5
S12
S9
S3
S3
S12
S12
S5
S5
S5

1-5 BED
PARTS LIST -Main Parts- PARTS LIST -Supplemental Parts-
Parts No. Parts Name Parts No. Parts Name
1 1000000760 APRON,B AL AJ-1000 S1 31289111AS CUPSCREW SET, M4*6 NI 100 PCS.
2 1000000763 APRON,B UNDER AJ-1000 S2 31289112AS CUPSCREW SET,M3*10 NI 100 PCS.
3 W700105770 ASSY,FAN JUNCTION BOARD AJ-1000 S3 31289102AS CUPSCREW SET,M3*6 NI 50 PCS.
4 6700109020 ASSY,G-ROLLER AJ-1000 S4 31409702 SADDLE,LOCKING EDGE LES-1010
5 1000000761 ASSY,HEATER MODULE BED AJ-1000 S5 31409811 SADDLE,LOCKING WIRE LWS-1211Z
6 1000000928 ASSY,HEATER MODULE PLATEN AJ-1000 S6 31019124 SCREW SET,BINDING M3*35 NI 50 PCS
7 23415133 ASSY,THERMISTOR CABLE SP-300 S7 31049170AS SCREW SET,CAP M3*8 NI 50 PCS.
8 1000000749 BASE,BED AJ-1000 S8 31049174AS SCREW SET,CAP M4*15 NI 20 PCS.
9 22175870 BEARING 10-19ZZ S9 31089110AS SCREW SET,PAN M3*4 C+PW 100 PCS.
10 22115106 BEARING HOUSING A 211-106 S10 31199701AS SCREW SET,SET WP M3*3 C 20 PCS.
11 1000000750 BED, AJ-1000 S11 31199704AS SCREW SET,SET WP M3*8 BC 20 PCS.
12 1000000636 CABLE-ASSY FAN JUNC AJ-1000 S12 31019703 SCREW,BINDING P-TIGHT 3*8BC 100P
13 1000000642 CABLE-ASSY PAPER SENS AJ-1000 S13 31049117 SCREW,CAP M4*12 BC+PW 4*9*0.8
14 22165165 COLLER S14 31069104 SCREW,CAP M4*6+FL C
15 1000000755 COUPLING,SHAFT FEED AJ-1000 S15 31179106 SCREW,JACK UP SP-500
16 1000000764 FAN,A35577-55ROL
17 1000000757 G-ROLLER,FD28.015S10 H150 AJ-1000
18 31279106 LABEL,CAUTION HOT SURF NO.778
19 1000000751 PLATE,SHUTTER L AJ-1000
20 1000000748 PLATE,SHUTTER R AJ-1000
21 15099115 SENSOR-INTERRUPTER GP2A25NJ
22 1000000756 SHAFT,FEED AJ-1000
23 1000000758 SHUTTER,GRIT AJ-1000
24 21625104 SHUTTER,PLATE SHUTTER SJ-1000
25 1000000747 SHUTTER,PLATEN AJ-1000
26 1000000745 SPACER,BED LOWER AJ-1000
27 1000000746 SPACER,BED UPPER AJ-1000
28 1000000753 SPRING,BED HEATER AJ-1000
29 1000000762 STAY,CABLE GUIDE FAN AJ-1000
30 1000001007 STAY,FAN CONTROL AJ-1000
31 1000000759 STAY,PLATEN HEATER AJ-1000
32 1000000754 STAY,P-SENSOR AJ-1000
1-10

1-6 CHASSIS
1-11
3
38
34
59
47
44
36
47 2
63
4
7
60
58
55
15
1
23
59 36
54
61
5
62
8
6
46
51
52
56
36
59
47
35
45
32
13
14
37
41
43
42
25
28
30
21
18
22
24
39
48
17
27
16
26
20
11
10
33
31
57
9
12 19
29 40
50
57
49
53
S7
S7
S7
S7
S7
S7
S7
S7
S7
S7
S7
S7
S7
S7
S8
S8
S8
S8
S1
S1
S6
S6
S6 S6
S9
S9
S8
S9
S5
S9
S5
S2
S2
S2 S10
S2
S10
S5
S7 S7
S7
S9
S9
S8
S7
S9
S5
S10
S7
S7 S6
S3
S6
S11
S3
S7
S4

1-6 CHASSIS
PARTS LIST -Main Parts-
Parts No. Parts Name Parts No. Parts Name
1 13429701 AC INLET SUP-J15G-E 51 1000000922 LABEL,SW DRYER AJ-1000#LA883
2 W700105130 ASSY,AC JUNCTION BOARD AJ-1000 52 1000000923 LABEL,SW PRINTER AJ-1000#LA882
3 6700105020 ASSY,HEAD BOARD AJ-1000 53 31279191 LABEL,WARNING FUSE REPLACE #347
4 W700105110 ASSY,HEATER CONTROL BOARD AJ-1000 54 22055565 PLATE,NET CARD FJ-540
5 1000000559 ASSY,MAIN BOARD AJ-1000 55 13129171 POWER-SW AJ8201B
6 22805353 ASSY,NETWORK BOARD FJ-500 56 1000000538 POWER UNIT,ZWD225PAF-0524/J
7 6700105010 ASSY,SERVO BOARD AJ-1000 57 21475147 SHEET,COATING SEAL FJ-540
8 W700105620 ASSY,SIGNAL JUNCTION BOARD AJ-1000 58 1000000806 STAY,AC INLET AJ-1000
9 15009101 BATTERY CR2032 59 22715327 STAY,CHASSIS FAN FJ-540
10 23475201 CABLE,CARD 6P1 255L BB FJ-540 60 1000000809 STAY,COVER SERVO AJ-1000
11 1000000634 CABLE-ASSY CLEAN-EXIST AJ-1000 61 1000000808 STAY,MAIN BOARD AJ-1000
12 1000000629 CABLE-ASSY DANCER JUNC AJ-1000 62 1000000807 STAY,SIGNAL BOARD AJ-1000
13 1000000624 CABLE-ASSY DC-POWER A AJ-1000 63 1000000097 ZWS240PAF-36/J
14 1000000625 CABLE-ASSY DC-POWER B AJ-1000
15 1000000575 CABLE-ASSY DRYER-AC AJ-1000
16 1000000631 CABLE-ASSY FEED JUNC AJ-1000
17 1000000632 CABLE-ASSY G-ENC JUNC AJ-1000
18 1000000574 CABLE-ASSY GND AJ-1000 PARTS LIST -Supplemental Parts-
19 1000000638 CABLE-ASSY HEAD FAN AJ-1000 Parts No. Parts Name
20 1000000628 CABLE-ASSY HEAD POWER AJ-1000 S1 31029101 BUSH,NB-19
21 1000000637 CABLE-ASSY HEATER POWER AJ-1000 S2 31029106 BUSH,SQUARE SB-6025
22 1000000572 CABLE-ASSY LIVE AJ-1000 S3 31329601AS CLAMP SET,INSULOK T-18S 100 PCS.
23 1000000573 CABLE-ASSY NEUTRAL AJ-1000 S4 31379111 CLAMP,CABLE CKS-13-H
24 1000000576 CABLE-ASSY PRINTER-AC A AJ-1000 S5 31379101 CLAMP,FLAT CABLE FCS-50P
25 1000000577 CABLE-ASSY PRINTER-AC B AJ-1000 S6 31289111AS CUPSCREW SET, M4*6 NI 100 PCS.
26 1000000630 CABLE-ASSY SERVO POWER AJ-1000 S7 31289102AS CUPSCREW SET,M3*6 NI 50 PCS.
27 1000000633 CABLE-ASSY SIGNAL JUNC A AJ-1000 S8 31409702 SADDLE,LOCKING EDGE LES-1010
28 1000000578 CABLE-ASSY SW POWER AC AJ-1000 S9 31409811 SADDLE,LOCKING WIRE LWS-1211Z
29 1000000618 CABLE-CARD 24P1 1050L BB HIGH-V S10 31019124 SCREW SET,BINDING M3*35 NI 50 PCS
30 23475197 CABLE CARD 25P1 105L BB FJ-540 S11 31209118 SPACER,WPCS-12S-4.0
31 1000000619 CABLE-CARD 25P1 225L BB HIGH-V
32 1000000620 CABLE-CARD 26P1 950L BB HIGH-V
33 1000000621 CABLE-CARD 28P1 300L BB HIGH-V
34 1000000804 CHASSIS,AJ-1000
35 1000000805 COVER,CHASSIS AJ-1000
36 1000000012 FAN,109R0624H459
37 12399351 FILTER(E) FRC-40-12-6.5 FJ-540
38 12399352 FILTER(E) FRC-45-12-6.5
39 12399353 FILTER(E) TFT-081813N F-540
40 12399331 FILTER(E),FPC-31-12
41 1000000542 FUSE,5X20 0217005MXP 5.0A/250V
42 1000000541 FUSE,5X20 021702.5MXP 2.5A/250V
43 1000000543 FUSE,5X20 02173.15MXP 3.15A/250V
44 22535257 LABEL,CAUTION VOLTAGE #LA167
45 1000000925 LABEL,DISCONNECT AJ-1000#LA896
46 31279116 LABEL,EARTH MARK-1 NO.E-580
47 31279121 LABEL,FLASH-LIGHTING NO.E-582
48 22535117 LABEL,POWER CM-500 NO.893
49 22535444 LABEL,READ MANUAL #LA637
50 1000001042 LABEL,STANDARD #LA909
1-12

1-7 PINCH ROLLER
PARTS LIST -Main Parts- PARTS LIST -Supplemental Parts-
Parts No. Parts Name Parts No. Parts Name
1 21775105 CAM,PINCH ROLLER SHAFT SJ-1000 S1 31289102 CUPSCREW SET,M3*6 NI 50 PCS.
2 22195133 FRAME,PINCH SJ-1000
3 22145216 LEVER,PINCH ROLLER FJ-540
4 22055549 PLATE,PINCH ROLL LEVER FJ-540
5 21565105 P-ROLLER FD8S3(B15L30)
6 1000000900 SPRING,PINCH 2000 AJ-1000
7 22715260 STAY,PINCH SPRING 2 FJ-500
1-13
71
2
3
4
5
6
S1

1-8 MAINTENANCE LIQUID CARTRIDGE
PARTS LIST -Main Parts- PARTS LIST -Supplemental Parts-
Parts No. Parts Name Parts No. Parts Name
1 1000000521 ADAPTER,SCREW FLEX AJ-1000 S1 31289102AS CUPSCREW SET,M3*6 NI 50 PCS.
2 1000000522 ADAPTER,TUBE JOINT AJ-1000 S2 31409811 SADDLE,LOCKING WIRE LWS-1211Z
3 W700105530 ASSY,CARTRIDGE IC BOARD AJ-1000 S3 31049170AS SCREW SET,CAP M3*8 NI 50 PCS.
4 W700105750 ASSY,CLEANING JUNCTION BOARD AJ-1000 S4 31019703 SCREW,BINDING P-TIGHT 3*8BC 100P
5 1000000524 ASSY,NEEDLE AJ-1000 S5 31049117 SCREW,CAP M4*12 BC+PW 4*9*0.8
6 6700109010 ASSY,PUMP SUPPLY AJ-1000 S6 31069104 SCREW,CAP M4*6+FL C
7 1000001252 ASSY,TUBING SET 6*55MM AJ-1000
8 1000000742 BASE,WIPE LIQUID SUPPLY AJ-1000
9 1000000691 BOARD,CARTRIDGE SIDE AJ-1000
10 1000000654 CABLE-ASSY C-LIQ EMPTY AJ-1000
11 1000000653 CABLE-ASSY C-LIQ IC AJ-1000
12 1000000652 CABLE-ASSY C-LIQ MOTOR AJ-1000
13 1000000651 CABLE-ASSY C-LIQ P-SENS AJ-1000
14 1000000640 CABLE-ASSY C-MOTOR JUNC AJ-1000
15 1000000641 CABLE-ASSY C-SIGNAL AJ-1000
16 1000000693 FRAME,CARTRIDGE B AJ-1000
17 1000000743 FRAME,WIPE LIQUID SUPPLY AJ-1000
18 1000000520 HOLDER,RING O TYPE-E AJ-1000
19 15099115 SENSOR-INTERRUPTER GP2A25NJ
20 1000000690 SPRING,PLATE CARTRIDGE AJ-1000
21 1000000744 STAY,SENSOR WIPE LIQUID AJ-1000
22 1000000694 STOPPER,CARTRIDGE AJ-1000
1-14
22
17
21
19
16
3
22
9
20 20
20
20
8
5
4
14
15
10
12
11 13
6
7
2
18
1
S1
S1
S1
S3
S1
S4
S1
S1
S6
S1
S1
S4 S4
S1
S5
S5
S2

1-9 WIPER SYSTEM
1-15
* For transportation
61
14
28
44
60
51
59 50
10 29
66
6927
30
41
43
45
32
24
49
39
31
35
58 65
556
55
36
57
46
16
12 38
38 7
15
26
15
33
40
42
40
4
15
15
16
47
49 15
12
362
19
20
8
34
54
68
18
43
43
48
45
13
21
22
923
37
6
9
53 11
53
53
23
24
67
47
48
17
52
47
63
64
25
S6
S14
S11
S17
S10
S7
S6
S10
S2
S7
S9
S9
S7
S7
S12
S9
S1
S8
S8
S5
S13
S4
S5
S5
S5
S5
S5
S5
S5
S5
S5
S5
S5
S5
S5
S5
S5
S5
S5
S5 S5
S15
S15
S4 S10
S18
S18
S11
S7 S5
S5 S9
S15
S3
S16
S5
S7
S5
S5
S7

1-9 WIPER SYSTEM
PARTS LIST -Main Parts-
Parts No. Parts Name Parts No. Parts Name
1 1000000521 ADAPTER,SCREW FLEX AJ-1000 51 1000000780 SHAFT,SLIDE CAPTABEL AJ-1000
2 1000000522 ADAPTER,TUBE JOINT AJ-1000 52 1000001056 SHEET,HEAD PROTECTION AJ-1000
3 1000000519 ADAPTER,TUBE PLUG AJ-1000 53 22165185 SPACER,ROLLER PIX-30
4 1000000985 ASSY, CAP-TOP AJ-1000 54 22175308 SPRING,BELT TENSION EGX-20
5 1000002081 ASSY, CAP-TOP SET AJ-1000 55 1000000790 SPRING,CAP HAED AJ-1000
6 1000001253 ASSY,TUBING SET 6*780MM AJ-1000 56 1000000779 SPRING,SET CAPSTATION AJ-1000
7 W700105790 ASSY,WIPE BOARD BOTTOM AJ-1000 57 1000000773 STAY,HOLD CAP TOP AJ-1000
8 W700105780 ASSY,WIPE BOARD TOP AJ-1000 58 1000000802 STAY,HOLD TUBE AJ-1000
9 W7001057C0 ASSY,WIPE FLEX BOARD AJ-1000 59 1000000786 STAY,IDLE PULLEY CAP AJ-1000
10 1000000781 BASE,BOTTOM CAP AJ-1000 60 1000000799 STAY,JOINT BASE SLIDE AJ-1000
11 1000000778 BASE,CAP SLIDE AJ-1000 61 1000000801 STAY,WASTE FLUID CAP LOWER AJ-1000
12 22355673 BASE,Y SLIDE PIX-4 62 1000000800 STAY,WASTE FLUID CAP UPPER AJ-1000
13 1000000785 BELT,340P2M4-530 63 1000002052 STAY,WIPE BOARD BTM AJ-1000
14 1000000783 BELT,638P2M4-530 64 1000002051 STAY,WIPE BOARD TOP AJ-1000
15 1000000796 BUSH,80F-0503 65 1000000772 TABLE,CAP TOP AJ-1000
16 12159565 BUSH,B-S8-23 66 1000000794 TRAY,WIPE UNDER AJ-1000
17 1000000647 CABLE-ASSY SLIDE MOTOR AJ-1000 67 1000001041 WASHER,OILES 80W-08
18 1000000648 CABLE-ASSY SLIDE ORG AJ-1000 68 1000000795 WIPER,HEAD AJ-1000
19 1000000650 CABLE-ASSY WIPE MOTOR AJ-1000 69 1000000793 WIPER,SCRAPER AJ-1000
20 1000000649 CABLE-ASSY WIPE ORG AJ-1000
21 1000000646 CABLE-ASSY W-MOTOR JUNC AJ-1000
22 1000000645 CABLE-ASSY W-ORG JUNC AJ-1000
23 23475154 CABLE-CARD 12P 400L BB PARTS LIST -Supplemental Parts-
24 1000000774 CAM,CAP AJ-1000 Parts No. Parts Name
25 1000000771 CASE,CAP TOP AJ-1000 S1 31029820 BUSH SET,ROLL 3*2 50 PCS
26 1000000803 COVER,CAP B AJ-1000 S2 31029101 BUSH,NB-19
27 1000000792 COVER,FRONT WIPE AJ-1000 S3 31329601AS CLAMP,INSULOK T-18S
28 1000000782 COVER,INNER L CAP AJ-1000 S4 31289112AS CUPSCREW SET,M3*10 NI 100 PCS.
29 1000000789 COVER,INNER R CAP AJ-1000 S5 31289102AS CUPSCREW SET,M3*6 NI 50 PCS.
30 1000000798 COVER,TKP0130-1B R18L17SET S6 31299102AS RIVET SET,NYLON P2655B 20 PCS.
31 1000000776 FRAME,SIDE L CAP AJ-1000 S7 31409702 SADDLE,LOCKING EDGE LES-1010
32 1000000777 FRAME,SIDE R CAP AJ-1000 S8 31409811 SADDLE,LOCKING WIRE LWS-1211Z
33 21685144 GEAR,S53S5(B15) FJ-540 S9 31019121 SCREW SET,BINDING M3*20 NI 100 PCS
34 1000000935 GEAR,WORM G80D20+R1 S10 31049170AS SCREW SET,CAP M3*8 NI 50 PCS.
35 1000000936 GEAR,WORM W80SU R1+B S11 31049174AS SCREW SET,CAP M4*15 NI 20 PCS.
36 1000000797 HOLDER,CAP CASE AJ-1000 S12 31199701AS SCREW SET,SET WP M3*3 C 20 PCS.
37 1000000520 HOLDER,RING O TYPE-E AJ-1000 S13 31199704AS SCREW SET,SET WP M3*8 BC 20 PCS.
38 21655130 HOLDER,SHAFT F MDX-3 S14 31239103AS SCREW SET,W-SEMS M3*8 BC+PW 50PCS
39 1000000791 HOLDER,WIPER AJ-1000 S15 31019703 SCREW,BINDING P-TIGHT 3*8BC 100P
40 22435106 MOTOR,103-593-1041 S16 31049117 SCREW,CAP M4*12 BC+PW 4*9*0.8
41 1000000788 PLATE,BASE CABLEVEYOR CAP AJ-1000 S17 31069104 SCREW,CAP M4*6+FL C
42 1000000865 PLATE,MOTOR HEAD U/D AJ-1000 S18 31139104 SCREW,PLAPOINT M4*6 BK FE
43 12569118 PULLEY BEARING S19 31249952 WASHER SET,POLYSLIDER 2.6*5*.5 CUT 20PCS
44 21975131 PULLEY,T16P2S4+GEAR S120
45 1000000784 PULLEY,T35P2S5(B6)
46 21975132 PULLEY,WD8.18 S7.5
47 11519108 RING,O DO1127G0
48 15229506 SENSOR INTERRUPTER,GP1A05A5
49 1000000775 SHAFT,CAP LIFT AJ-1000
50 1000000787 SHAFT,DRIVE PULLEY CAP AJ-1000
1-16