Volvo M3602654 User manual

Instruction No Version Part. No.
8622916 1.0
Antenna kit handsfree, internal antenna
Instruction No Version Part. No.
8622916 1.0
Antenna kit handsfree, internal antenna
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Antenna kit handsfree, internal antenna- 8622916 - V1.0
Page 1 / 10

M3602654
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Antenna kit handsfree, internal antenna- 8622916 - V1.0
Page 2 / 10

INTRODUCTION
Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to
minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available
before starting installation.
Certain steps in the instructions are only presented in the form
of images. Explanatory text is also given for more complicated
steps.
In the event of any problems with the instructions or the
accessory, contact your local Volvo dealer.
1
A8800136
Note the anti-theft radio code (if applicable)
Move the front seats to their rearmost, uppermost positions
Turn the ignition key to position 0
Cars with manual gearboxes: Remove the ignition key
Disconnect the battery negative lead.
Note!
Wait at least five minutes before disassembling the connectors
or removing other electrical equipment.
2
M8502988
Remove the panel in front of the gear selector lever. Pry off the
panel using a weatherstrip tool
Move the gear selector lever to its rearmost position.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Antenna kit handsfree, internal antenna- 8622916 - V1.0
Page 3 / 10

3
M8502991
Remove the panel around the gear selector lever. Press the two
catches and pull up the front edge of the panel.
4
M8503027
Remove the two screws from the dashboard environment panel.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Antenna kit handsfree, internal antenna- 8622916 - V1.0
Page 4 / 10

5
M8503705
Angle the dashboard environment panel outwards so that it is
possible to insert a couple of fingers between the centre console
and the reverse of the dashboard environment panel
Remove the dashboard environment panel. Pull it downward,
maintaining the same angle. Some force is required because the
panel is tightly installed
Disconnect the connectors on the reverse of the dashboard
environment panel. Place the dashboard environment panel to
one side.
Note!
If any of the outer hooks break off, these must be repaired.
The method for this can be found in the Workshop Manual in
the section about the dashboard.
6
M3903036
Remove the screws from the radio bracket
Pull out the bracket with the radio. Pull the lower corner while
pressing downwards
Disconnect the connectors on the radio. Remove the bracket
with the radio.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Antenna kit handsfree, internal antenna- 8622916 - V1.0
Page 5 / 10

7
M8502816
Remove the panel from the right hand end of the dashboard.
8
M8503600
Turn the clips in the rear edge of the panels 90°. Remove the
panels (1) by pulling the rear edge of the panels outwards and
backwards
Remove the two screws (3). Pry the rear edge of the panel (2)
down until the three clips release. Remove the panel
Pull the front edge of the sill moulding (4) for the right hand side
front door backwards. Then pull upwards. Remove the sill
moulding.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Antenna kit handsfree, internal antenna- 8622916 - V1.0
Page 6 / 10

9
D8503430
Remove the rubber strip (1) at the front edge of the door
opening
Remove the A-post panel on the right-hand side. Pull out the
upper edge of the panel to release the two clips
Cut off the clip (2). New clips can be found in the kit
Pull the panel upwards from the lower mounting.
10
D3500908
Fold down the cover (1) by carefully pulling down the front edge
of the cover
Press the catches (2) together. Detach the front edge of the
panel. Remove the panel.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Antenna kit handsfree, internal antenna- 8622916 - V1.0
Page 7 / 10

11
D3500909
Remove the bracket (1) and mirror. First remove the screws (2)
and bend the tabs (3) forward
Detach the clips (4) by pressing the clips inwards. Detach one
side at a time
Pull the bracket downwards so that it releases from the
mountings. Allow the bracket to hang from the wiring.
Installation
12
D3902236
Installation
Install the new antenna. Carefully bend the headlining downward
and slide the antenna backward and inwards. Align the antenna
lugs (1) with the grooves in the bracket (2)
Insert the cable at the inside of the front edge of the headlining.
Route the cable out towards the right-hand A-post
Secure the cable using butyl tape
Reinstall the bracket and rear view mirror
Reinstall the panel. Securely lock the panel using the cover.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Antenna kit handsfree, internal antenna- 8622916 - V1.0
Page 8 / 10

13
M8503137
Route the cable down from the headlining along the right A-post
Tape the cable onto the existing cable harness as illustrated (1).
Warning!
Ensure that the inflatable curtain is not trapped and does not
catch on the antenna cable.
14A
M8503790
14B
M8503798
Fold the right hand carpet back into place at the front seat
Thread the extension cable (1) down between the A-post and
the right hand side of the dashboard. Route the cable at the front
edge of the floor
Route the cable along the front edge of the floor to the left, to the
inside of the centre console.
Applies when installing the carphone
Connect the extension cable (1) to the remaining cable (2) from
the carphone holder.
Illustration B applies to cars with other installed carphone
antennas
Find the joint between the cable for the existing antenna and the
cable from the carphone holder. The antenna cable is routed
along the air ducts (1) and then down under the carpet, where
the cable splice is
Remove the two covers (2) from the front mounting for the seat
to gain access under the carpet
Detach the two cables from each other
Pull the new antenna cable downwards. Connect the antenna
cable where the old cable was disconnected
Remove the old antenna if necessary.
Applies to all models
Connect both connectors (3) at the right A-post to each other
Wrap the foam tape around the connectors to prevent rattling.
Secure the cable using butyl tape.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Antenna kit handsfree, internal antenna- 8622916 - V1.0
Page 9 / 10

15
Applies to cars with the antenna installed later
Connect the connectors to the radio. Reinstall the radio
Connect the connectors to the dashboard environment panel.
Reinstall the dashboard environment panel.
Finishing work
16 Finishing work
Fold the carpet at the right front seat back into position.
Reinstall:
the carpet at the right-hand front seat
the panel for the right end of the dashboard
the A-post panel using new clips from the kit
the right side panel for the centre console
the soundproofing panel on the right-hand side
the sill trim panel for the right-hand front door
the rubber strip in the door frame in the right-hand front door.
17
A8800137
Turn the ignition key to position II
Reconnect the battery negative lead
Program the software according to the service information in
VIDA.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Antenna kit handsfree, internal antenna- 8622916 - V1.0
Page 10 / 10