Volvo 30721673 User manual

Instruction No Version Part. No.
30681858 1.2 30721673, 30681835, 31439123, 31439132
Upper attachment panel with hooks
IMG-257996
Instruction No Version Part. No.
30681858 1.2 30721673, 30681835, 31439123, 31439132
Upper attachment panel with hooks
IMG-257996
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Upper attachment panel with hooks- 30681858 - V1.2
Page 1 / 7

Equipment
A0000162 IMG-239660 IMG-239681
IMG-257984
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Upper attachment panel with hooks- 30681858 - V1.2
Page 2 / 7

IMG-213320
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Upper attachment panel with hooks- 30681858 - V1.2
Page 3 / 7

INTRODUCTION
Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to
minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available
before starting installation.
Certain steps in the instructions are only presented in the form
of images. Explanatory text is also given for more complicated
steps.
In the event of any problems with the instructions or the
accessory, contact your local Volvo dealer.
1
IMG-257664
Take the left-hand rail (marked LH with the holes for attachment
at the upper edge) and place the rear section in the hole for the
rear load securing eyelet.
Align it carefully and make marks for the two rear holes using a
scriber.
2
IMG-257666
Align the front end of the rail carefully and make marks for the
two front holes using a scriber.
Remove the rail.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Upper attachment panel with hooks- 30681858 - V1.2
Page 4 / 7

3
IMG-257665
Note!
Make sure not to drill through the bracket that lies directly
against the side panel's rear side.
Take a Ø6 mm (15/64 ") drill bit and install a drill stop of 3 mm
(1/8 ").
Drill four holes through the side panel.
Remove any swarf.
4
IMG-257667
Clean the marked surfaces using a mild, not etching, cleaning
agent and wipe dry.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Upper attachment panel with hooks- 30681858 - V1.2
Page 5 / 7

5
IMG-257663
Remove the seven protective films from the tape on the rear
side of the rail.
6
IMG-257668
Align the rail, without the tape adhering, so that the four screws
can be screwed into the side panel. The screws are self tapping
and there may be some resistance when installing.
When the screws have engaged the threads, tighten and press
the tape along the entire rail.
Repeat all steps for the other side.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Upper attachment panel with hooks- 30681858 - V1.2
Page 6 / 7

7
IMG-257669
Install the hooks by inserting them in the upper edge (1) and
then downwards (2) until they lock in the rail.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Upper attachment panel with hooks- 30681858 - V1.2
Page 7 / 7