Volvo 31265619 User manual

Instruction No Version Part. No.
31265625 1.3 31265619, 30758015, 30758016, 30758017, 30758018, 31330003, 31330004
Side scuff plate
IMG-332637
Instruction No Version Part. No.
31265625 1.3 31265619, 30758015, 30758016, 30758017, 30758018, 31330003, 31330004
Side scuff plate
IMG-332637
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Side scuff plate- 31265625 - V1.3
Page 1 / 16

Equipment
A0000162 IMG-239664 IMG-239660 IMG-239940
IMG-332608
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Side scuff plate- 31265625 - V1.3
Page 2 / 16

IMG-348168
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Side scuff plate- 31265625 - V1.3
Page 3 / 16

INTRODUCTION
Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to
minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available
before starting installation.
Certain steps in the instructions are only presented in the form
of images. Explanatory text is also given for more complicated
steps.
In the event of any problems with the instructions or the
accessory, contact your local Volvo dealer.
Note!
Some steps in these installation instructions are presented
with illustration only.
1
IMG-332193
Applies to all models
Set the ignition key to position 0.
Note!
Wait at least one minute before unplugging the connectors or
removing other electrical equipment.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Side scuff plate- 31265625 - V1.3
Page 4 / 16

2
IMG-332639
Clean the door sills thoroughly on both sides, even underneath.
3
IMG-332640
Clean the door sill panels where the decor panel's cradle is to sit
on both sides using isopropanol.
Wipe dry.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Side scuff plate- 31265625 - V1.3
Page 5 / 16

4
IMG-348161
Applies to vehicles with Drive E
Carefully drill out the rivets.
5
IMG-348163
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Side scuff plate- 31265625 - V1.3
Page 6 / 16

6
IMG-348166
Remove the panel.
Remove the remains of the rivets.
7
IMG-332641
Applies to all models
Take the cradles for one side from the kit.
The cradles are marked out and only fit in one place.
Start with the front cradle on one side.
Remove the protective tape from the two pieces of mounting
tape.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Side scuff plate- 31265625 - V1.3
Page 7 / 16

8
IMG-332642
Align the front edge of the cradle at the rear edge of the joint
between the front and rear door sill panel.
Note!
Ensure that the tape does not adhere yet. At the same time
hook the cradle at the upper edge on the door sill panel with
the hooks.
Press the middle of the pieces of mounting tape.
9
IMG-332648
Drill out the six marked out holes in the cradle using a Ø 6 mm
(15/64") drill bit.
Remove any swarf.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Side scuff plate- 31265625 - V1.3
Page 8 / 16

10
IMG-332649
Take pop rivets from the kit. Rivet the holder to the door sill
panel.
11
IMG-332650
Remove the protective tape from the pieces of mounting tape on
the rear cradle.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Side scuff plate- 31265625 - V1.3
Page 9 / 16

12A
IMG-332651
12B
IMG-332656
Illustration A
Align the lugs at the front edge in the rear cradle in the holes at
the front.
Note!
Ensure that the tape does not adhere yet.
At the same time, hook the holder on top of the door sill panel
using the hooks.
Illustration B
Press the holder onto the pieces of mounting tape.
13
IMG-332658
Drill out the seven marked out holes in the cradle using a Ø 6
mm (15/64") drill bit.
Remove any swarf.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Side scuff plate- 31265625 - V1.3
Page 10 / 16