Aaeon PC-3200 User manual

Fanless Panel PCs PC-3200
PC-3200 Series User Manual V1.2 1
PC-3200
VIA Eden Processor-based
Fanless Panel PC with
12.1” TFT-LCD

Fanless Panel PCs PC-3200
PC-3200 Series User Manual V1.2 2
Copyright Notice
This document is copyrighted, 2003. All rights are reserved. The original
manufacturer reserves the right to make improvements to the products described
in this manual at any time without notice.
No part of this manual may be reproduced, copied, translated, or transmitted in
any form or by any means without the prior written permission of the original
manufacturer. Information provided in this manual is intended to be accurate and
reliable. However, the original manufacturer assumes no responsibility for its use,
nor for any infringements upon the rights of third parties, which may result from
its use.
The material in this document is for product information only and is subject to
change without notice. While reasonable efforts have been made in the
preparation of this document to assure its accuracy, AAEON, assumes no
liabilities resulting from errors or omissions in this document, or from the use of
the information contained herein.
AAEON reserves the right to make changes in the product design without notice
to its users.

Fanless Panel PCs PC-3200
PC-3200 Series User Manual V1.2 3
Acknowledgments
Award is a trademark of Award Software International, Inc.
VIA is a trademark of VIA Technologies, Inc.
IBM, PC/AT, PS/2 and VGA are trademarks of International Business Machines
Corporation.
Intel and Pentium are trademarks of Intel Corporation.
Microsoft Windows ® is a registered trademark of Microsoft Corporation.
RTL is a trademark of Realtek Semi-Conductor Co., Ltd.
ESS is a trademark of ESS Technology, Inc.
UMC is a trademark of United Microelectronics Corporation.
SMI is a trademark of Silicon Motion, Inc.
Creative is a trademark of Creative Technology LTD.
All other product names or trademarks are properties of their respective owners.

Fanless Panel PCs PC-3200
PC-3200 Series User Manual V1.2 4
FCC Class B
This device complies with Part 15 FCC Rules. Operation is subject to the
following two conditions: (1) This device may not cause harmful
interference. (2) This device must accept any interference received
including interference that may cause undesired operation.
This equipment has been tested and found to comply with the limits for a Class B
digital device, pursuant to Part 15 of the FCC Rules. These limits are designed to
provide reasonable protection against harmful interference when the equipment is
operated in a residential environment. This equipment generates, uses and can
radiate radio frequency energy. If not installed and used in accordance with this
user's manual, it may cause harmful interference to radio communications. Note
that even when this equipment is installed and used in accordance with this user's
manual, there is still no guarantee that interference will not occur. If this
equipment is believed to be causing harmful interference to radio or television
reception, this can be determined by turning the equipment on and off. If
interference is occurring, the user is encouraged to try to correct the interference
by one or more of the following measures:
• Reorient or relocate the receiving antenna
• Increase the separation between the equipment and the receiver
• Connect the equipment to a power outlet on a circuit different from that to
which the receiver is connected
• Consult the dealer or an experienced radio/TV technician for help
Any changes or modifications made to the equipment
which are not expressly approved by the relevant
standards authority could void your authority to
operate the equipment.

Fanless Panel PCs PC-3200
PC-3200 Series User Manual V1.2 5
Packing List
Before you begin installing your card, please make sure that the following
materials have been shipped:
PC-3200 series Panel PC
CD-ROM
Contains User’s Manual, Drivers and Utilities
Accessories
-Y-shaped adapter for PS/2 mouse and Keyboard
-Power cord: USA type
-Power cord connector (change USA to Germany Type)
-AC/DC power adapter
-DC plug-in housing (female)
-Mounting kits and packet of screws
-Battery Pack (optional)
If any of these items are missing or damaged, contact your
distributor or sales representative immediately.
1. Input voltage rated 18 V ~ 25 Vdc, 3.5 A max
2. Use a 3 V @ 195 mA lithium battery
3. Packing: please carry the unit with both hands, handle with
care

Fanless Panel PCs PC-3200
PC-3200 Series User Manual V1.2 6
4. Maintenance: to properly maintain and clean the surfaces, use
only approved products or clean with a dry applicator
5. CompactFlash: Turn off power before inserting or removing
CompactFlash storage card.

Fanless Panel PCs PC-3200
PC-3200 Series User Manual V1.2 7
Safety & Warranty
1. Read these safety instructions carefully.
2. Keep this user's manual for later reference.
3. Disconnect this equipment from any AC outlet before cleaning. Do not use
liquid or spray detergents for cleaning. Use a damp cloth.
4. For plug-in equipment, the power outlet must be installed near the equipment
and must be easily accessible.
5. Keep this equipment away from humidity.
6. Put this equipment on a reliable surface during installation. Dropping it or
letting it fall may cause damage.
7. The openings on the enclosure are for air convection. Protect the equipment
from overheating. DO NOT COVER THE OPENINGS.
8. Make sure the voltage of the power source is correct before connecting the
equipment to the power outlet.
9. Position the power cord so that people cannot step on it. Do not place
anything over the power cord.
10. All cautions and warnings on the equipment should be noted.
11. If the equipment is not used for a long time, disconnect it from the power
source to avoid damage by transient over voltage.
12. Never pour any liquid into an opening. This may cause fire or electrical shock.
13. Never open the equipment. For safety reasons, the equipment should be
opened only by qualified service personnel.

Fanless Panel PCs PC-3200
PC-3200 Series User Manual V1.2 8
14. If one of the following situations arises, get the equipment checked by
service personnel:
a. The power cord or plug is damaged.
b. Liquid has penetrated into the equipment.
c. The equipment has been exposed to moisture.
d. The equipment does not work well, or you cannot get it to work
according to the users manual.
e. The equipment has been dropped and damaged.
f. The equipment has obvious signs of breakage.
15. DO NOT LEAVE THIS EQUIPMENT IN AN UNCONTROLLED
ENVIRONMENT WHERE THE STORAGE TEMPERATURE IS
BELOW -20° C (-4°F) OR ABOVE 60° C (140° F). IT MAY DAMAGE
THE EQUIPMENT.
16. CAUTION: DANGER OF EXPLOSION IF BATTERY IS
INCORRECTLY REPLACED.REPLACE ONLY WITH THE SAME OR
EQUIVALENT TYPE RECOMMENDED BY THE MANUFACTURER,
DISCARD USED BATTERIES ACCORDING TO THE
MANUFACTURER'S INSTRUCTIONS.
The sound pressure level at the operator's position according to IEC 704-1:1982 is
no more than 70 dB (A).
DISCLAIMER: This set of instructions is given according to IEC 704-1.
AAEON disclaims all responsibility for the accuracy of any statements contained
herein.

Fanless Panel PCs PC-3200
PC-3200 Series User Manual V1.2 9
Contents
Copyright Notice....................................................................2
Acknowledgments..................................................................3
FCC Class B...........................................................................4
Packing List ...........................................................................5
Safety & Warranty..................................................................7
General Information..................................................................... 11
Introductions........................................................................12
General Specifications:........................................................13
LCD Specifications..............................................................17
Dimensions ..........................................................................18
System Setup................................................................................19
A Quick Tour of the Panel PC..............................................20
Installation Procedures.........................................................22
Running the BIOS Setup Program.......................................23
Installing System Software..................................................24
Hardware Installation and Upgrading..........................................27
Introduction..........................................................................28
Installing the 2.5" Hard Disk Drive (HDD).........................28
Installing the battery pack....................................................33
Panel Mounting Installation.................................................34
Jumper Settings and Connectors..................................................35
Jumpers and Connectors......................................................36
Jumpers and switch..............................................................37
Locating jumpers and switch...............................................38

Fanless Panel PCs PC-3200
PC-3200 Series User Manual V1.2 10
Connectors ...........................................................................39
CMOS Clear for External RTC (J5).....................................41
COM-port interface (J2, J3, J4) ...........................................42
VGA interface......................................................................45
Watchdog Timer Configuration (J4)....................................45
Wake on LAN select (J1).....................................................46
BIOS Installation .........................................................................47
Award BIOS setup ...............................................................50
Standard CMOS Features setup...........................................51
Advanced BIOS Features setup...........................................52
Advanced Chipset Features setup........................................53
Integrated Peripherals ..........................................................54
Power Management Setup ...................................................55
PnP/PCI Configurations.......................................................56
PC Health Status ..................................................................57
Frequency/Voltage Control..................................................58
Load Optimized Defaults.....................................................59
Set Password........................................................................60
Save & Exit Setup................................................................62
Exit Without Saving.............................................................62
Drivers Installation.......................................................................63