Antunes DC-12C User manual

P/N 1011441 Rev. A 12/16
Display Cabinet
owner’s manual
Model DC-12C
Manufacturing Numbers:
9500716
www.antunes.com

DC-12C DISPLAY CASE
2P/N 1011441 Rev. A 12/16
OWNER INFORMATION
Fill in the information below and have it handy when
calling Antunes Technical Service for assistance. The
serial number is on the specification plate located on
the rear of the unit.
Purchased From:
Date of Purchase:
Model No.:
Serial No.:
Mfg. No.:
Network ID Number:
Use only genuine Antunes replacement parts in this
unit. Use of replacement parts other than those sup-
plied by the manufacturer will void the warranty.
IMPORTANT! Keep these instructions for future reference. If the unit
changes ownership, be sure this manual accompanies the equipment.
Warranty Information
Please read the full text of the Limited Warranty in this
manual.
If the unit arrives damaged, contact the carrier imme-
diately and file a damage claim with them. Save all
packing materials when filing a claim. Freight damage
claims are the responsibility of the purchaser and are
not covered under warranty.
The warranty does NOT extend to:
• Damages caused in shipment or damage as result
of improper use.
• Installation of electrical service.
• Normal maintenance as outlined in this manual.
• Malfunction resulting from improper maintenance.
• Damage caused by abuse or careless handling.
• Damage from moisture into electrical components.
• Damage from tampering with, removal of, or
changing any preset control or safety device.
General
This manual provides the safety, installation, and
operating procedures for this unit. Please read this
manual prior to installing and operating the unit.
This unit is manufactured from the finest materials
available and assembled to our strict quality standards.
This unit has been tested at the factory to ensure
dependable trouble-free operation.
Service/Technical Assistance
If you experience any problems with the installation or
operation of your unit, contact your Authorized Service
Agency.

DC-12C DISPLAY CASE
3
P/N 1011441 Rev. A 12/16
SPECIFICATIONS
A
B
C
Dimensions
Model & Mfg. No. Height
(A)
Width
(B)
Depth
(C)
DC-12C
9500716
20.64”
(524.34 mm)
12.3”
(312.57 mm)
12.3”
(312.57 mm)

DC-12C DISPLAY CASE
4P/N 1011441 Rev. A 12/16
Location
When placing the display case into service, pay atten-
tion to the following guidelines:
• Do NOT block or cover any openings on the unit.
• Keep away from heated surfaces.
1. Place the display case in the required position.
2. Load product into the display case. Insert appro-
priate card into the display card holder.
Unpacking
1. Open the large box. It contains:
• DC-12C Display Case
• Owner’s Manual
2. Remove the foam inserts from the box.
3. Carefully remove the display case from the large
box.
4. Remove the shelves from the display case.
5. Remove the display card holder and plastic clip
from the display case.
6. Wash, rinse, and sanitize the shelves and the dis-
play card holder at 3-compartment sink. Allow to
air dry.
7. Clean the exterior and interior walls of the display
case with a clean sanitizer soaked towel sprayed
with Glass & Multi-Surface cleaner solution.
8. Next, wipe the exterior and interior of the display
case with a clean sanitizer-soaked towel. Allow to
air dry.
9. Reinstall the shelves.
10. Attach the display card holder to the top of the
display case. Secure with the plastic clip.
NOTE: If any parts are missing or damaged, con-
tact Antunes Customer Service IMMEDIATELY at
1-877-392-7856 (North America only), or
630-784-1000.
INSTALLATION
Figure 1. DC-12C Display Case

DC-12C DISPLAY CASE
5
P/N 1011441 Rev. A 12/16
Stick-on
Bumper
Display
Case Cylinder
Display
Card Holder
Plastic Pin
Door
Flaps
Shelf
Door Flap
Retainers
Plastic Clip
Shelf
Shelf
Shelf Rest
Shelf Rest
Shelf Rest
INSTALLATION (CONTINUED)
Figure 1. DC-12C Display Case Components

DC-12C DISPLAY CASE
6P/N 1011441 Rev. A 12/16
Daily Cleaning
Follow these steps to clean the Display Case.
1. Remove food product from the display case
and store properly.
2. Remove the shelves from the display case.
Remove the crumbs from the shelves with a
clean, sanitizer-soaked towel and dispose the
crumbs into the trash receptacle.
3. Take the shelves to the 3-compartment sink
to wash with hot water and an approved all
purpose cleaning solution. For heavier soils,
pre-spray an approved heavy duty degreaser
solution prior to washing.
4. Rinse the shelves with clean, hot water at the
3-compartment sink.
5. Sanitize the shelves with Sanitizer solution for
one minute and allow to air dry.
6. Using a clean, sanitizer-soaked towel; sweep
crumbs out of the display case and empty into
the trash receptacle.
7. Spray and wipe the interior and exterior walls
with an approved all purpose cleaning solution
and a clean, sanitizer-soaked towel. For heavy
soils, scrub the display case walls with non-
scratch pad that will not damage the display
case surfaces.
8. Clean the vinyl access flaps with a clean, san-
itizer-soaked towel sprayed with an approved
all purpose cleaning solution.
NOTE: Do NOT use an abrasive or non-abrasive
pad (NO-SCRATCH Pad) on the vinyl access flaps
due to potential scratching.
9. Rinse the interior and exterior walls and the
vinyl access flaps with a separate, clean sani-
tizer-soaked towel.
10. Spray the interior and exterior walls and the
vinyl access flaps with sanitizer solution and
allow to air dry.
10. Reinstall the shelves and load food product.
MAINTENANCE

DC-12C DISPLAY CASE
7
P/N 1011441 Rev. A 12/16
REPLACEMENT PARTS
7
9
5
4
3
1
6
8
1
3
3
1
1 7001362 Shelf Rest Kit 1
3 7001363 Acrylic Round Shelf Kit 1
4 7001364 Door Flap Kit 1
5 7001365 Plastic Clip Kit 1
6 7001366 Door Flap Retainer Kit 1
7 7001367 Bumper, Stick-on Kit 1
8 7001368 Plastic Clip (Door Flap) Kit 1
9 7001369 Display Card Holder Kit 1
Item Part No. Description Qty.

[phone]
[phone]
[phone] [phone]
[phone]
[phone]
Limited Warranty
This Display Case has a 90 day warranty from date of purchase. This warranty does not cover misuse/abuse, dam-
age due to dropping, or damage resulting from improper maintenance. The warranty for this Display Case does not
cover travel time or mileage. Contact the Technical Service Department at [phone], [phone] (toll free
in the U.S.), or T[email protected] for any warranty issues.