Antunes DC-14R User manual

P/N 1011439 Rev. A 12/16
Display Cabinet
owner’s manual
Model DC-14R
Manufacturing Numbers:
9500706
www.antunes.com

DC-14R DISPLAY CASE
2P/N 1011439 Rev. A 12/16
OWNER INFORMATION
Fill in the information below and have it handy when
calling Antunes Technical Service for assistance. The
serial number is on the specification plate located on
the rear of the unit.
Purchased From:
Date of Purchase:
Model No.:
Serial No.:
Mfg. No.:
Network ID Number:
Use only genuine Antunes replacement parts in this
unit. Use of replacement parts other than those sup-
plied by the manufacturer will void the warranty.
IMPORTANT! Keep these instructions for future reference. If the unit
changes ownership, be sure this manual accompanies the equipment.
Warranty Information
Please read the full text of the Limited Warranty in this
manual.
If the unit arrives damaged, contact the carrier imme-
diately and file a damage claim with them. Save all
packing materials when filing a claim. Freight damage
claims are the responsibility of the purchaser and are
not covered under warranty.
The warranty does NOT extend to:
• Damages caused in shipment or damage as result
of improper use.
• Normal maintenance as outlined in this manual.
• Malfunction resulting from improper maintenance.
• Damage caused by abuse or careless handling.
General
This manual provides the safety, installation, and
operating procedures for this unit. Please read this
manual prior to installing and operating the unit.
This unit is manufactured from the finest materials
available and assembled to Roundup’s strict quality
standards. This unit has been tested at the factory to
ensure dependable trouble-free operation.
Service/Technical Assistance
If you experience any problems with the installation or
operation of your unit, contact your Authorized Service
Agency.

DC-14R DISPLAY CASE
3
P/N 1011439 Rev. A 12/16
SPECIFICATIONS
A
B C
Dimensions
Model & Mfg. No. Height
(A)
Width
(B)
Depth
(C)
DC-14R
9500706
18.5”
(470 mm)
14.25”
(362 mm)
22”
(559 mm)

DC-14R DISPLAY CASE
4P/N 1011439 Rev. A 12/16
Location
When placing the display case into service, pay atten-
tion to the following guidelines:
• Do NOT block or cover any openings on the unit.
• Keep away from heated surfaces.
1. Place the display case in the required position.
2. Load product into the display case. Insert appro-
priate card into the display card holder.
Unpacking
1. Open the large box. It contains:
• DC-14R Display Case
• Three shelves
• Owner’s Manual
2. Remove the foam inserts from the box.
3. Carefully remove the display case from the large
box.
4. Perform the Daily Cleaning steps found in the
Maintenance section of this manual.
NOTE: If any parts are missing or damaged, con-
tact A.J. Antunes Customer Service IMMEDIATELY
at 1-877-392-7856 (North America only), or
630-784-1000.
INSTALLATION
Figure 1. DC-14R Display Case

DC-14R DISPLAY CASE
5
P/N 1011439 Rev. A 12/16
Daily Cleaning
Follow these steps to clean the Display Case.
1. Remove food product from the display case
and store properly.
2. Remove the shelves from the display case.
Remove the crumbs from the shelves with a
clean, sanitizer-soaked towel and dispose the
crumbs into the trash receptacle.
3. Wash the shelves in hot water with an
approved all purpose cleanser. For heavier
soils, pre-spray with a heavy duty degreaser
solution prior to washing.
4. Rinse the shelves with clean, hot water.
5. Sanitize the shelves with an approved
sanitizer solution for one minute and allow to
air dry.
6. Using a clean, sanitizer-soaked towel; sweep
crumbs out of the display case and empty into
the trash receptacle.
7. Spray and wipe the interior and exterior walls
of the display case with an approved all pur-
pose cleanser applied to a clean, sanitizer-
soaked towel. For heavy soils, scrub the dis-
play case walls with non-scratch pad that will
not damage the display case surfaces.
8. Rinse the interior and exterior walls of the
display case with a separate, clean sanitizer-
soaked towel.
9. Spray the interior and exterior walls of the dis-
play case with Sanitizer solution and allow to
air dry.
10. Reinstall the shelves and load food product.
MAINTENANCE

DC-14R DISPLAY CASE
6P/N 1011439 Rev. A 12/16
REPLACEMENT PARTS
8
5
14
13
13
11 13 12 13
3
14 9 15 147
1
10 16
4
6
3
15
14
1 0022223 Base Weldment 1
2 0507331 Frame Cabinet Rear Door 1
3 0013223 Door Assembly 1
4 0900340 Front Curved Acrylic Panel 1
5 0507333 Clip, Acrylic Mounting 2
6 0900339 Side Acrylic Panel RH 1
7 0900338 Side Acrylic Panel LH 1
8 2100285 Rubber Head Screw Bumper 4
9 218K456* Shelf Rest 12
10 0900341 Shelf, Top 1
11 0900342 Shelf, Middle 1
12 0900343 Shelf, Bottom 1
13 308K104* 8-32 X .38 LG Truss Head S.S. 1
14 308K105* 8-32 X .5 LG Truss Head S.S. 1
15 308K145* Nut, Hex Acorn #08-32 Low Crown 1
16 3100176 10-24 X .38 LG 4
Mach Screw Fillister S.S
* Available in packages of 10 (ten)
Item Part No. Description Qty.

DC-14R DISPLAY CASE
7
P/N 1011439 Rev. A 12/16
NOTES

[phone]
[phone]
[phone] [phone]
[phone]
[phone]
Limited Warranty
This Display Case has a 90 day warranty from date of purchase. This warranty does not cover misuse/abuse, dam-
age due to dropping, or damage resulting from improper maintenance. The warranty for this Display Case does not
cover travel time or mileage. Contact the Technical Service Department at [phone], [phone] (toll free
in the U.S.), or T[email protected] for any warranty issues.