Aseptico ADC-08 User manual

P.O. Box 1548 • Woodinville, WA 98072-1548
1-800-426-5913 • 425-487-3157 • Fax: [phone]
email: [email protected] • Internet: www.aseptico.com
OPERATION AND
MAINTENANCE MANUAL
Portable Dental Stool
Item ADC-08

Page 2
TABLE OF CONTENTS
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Purpose . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Performance Characteristics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Items Furnished . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Operation Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Stool Set-Up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Collapsing the Stool . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Cleaning & Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Parts Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
TABLE OF ILLUSTRATIONS
Figure 1 - Back Support Position . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Figure 2 - Fitting Cross Member Into Stop Channel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Figure 3 - Leg Height Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Figure 4 - Parts Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

Page 3
PERFORMANCE CHARACTERISTICS:
Dimensions
Stool- Folded: 19” x 20” x 8.5”
Extended: 22” x 20” x (Max Height: 32” Min Height: 29”)
Soft carrying case: 19” x 21” x 9”
Weight
One (1) stool only: 14 lbs.
One (1) stool in soft carrying case: 16.5 lbs.
Range of Positions
Minimum Seat Height: 19”
Maximum Seat Height: 22”
ITEMS FURNISHED
One (1) ADC-08 Portable Dental Stool
One (1) Soft padded carrying case with handles
One (1) Operation and Maintenance Manual
PURPOSE:
Aseptico ADC-08 Portable Operator Stools provide seating for a doctor or an assistant during
field dentistry and medical treatment. The padded seats and backrests make these stools
comfortable for extended use, while the folding design and light weight ensure maximum
portability. The ADC-08 Stools are built with high strength steel frames and rugged vinyl
coverings, allowing for long term use.

Page 4
Figure 1 - Backrest Positioning
Figure 2 - Securing Leg Frame
Frame
cross member Restraining strap
Stop channel
Figure 3 - Leg Height Adjustment
Spring loaded
adjustment pin
Red dot
Adjustable leg
Frame tube
STOOL SET-UP:
1. Remove the stool from its carrying case and
swivel the back support to the upright position.
(Fig. 1)
2. Turn the ADC-08 Stool upside down and set on
the edge of an elevated flat surface such as a
table or counter top. Scissor the leg frame so
that the frame cross member lines up with the
stop channel at the rear of the stool on the
underside. Fit the frame cross member into the
channel and push firmly into place (Fig. 2). Wrap
restraining strap over the top of the cross
member and snap into place. Ensure that the
strap retains the frame cross member firmly into
the stop channel.
3. Extend the legs to the proper height by pulling
the adjustable legs out of the frame. The
adjustable legs are marked with a red height
indicating dot. Pull the leg out until the red dot
is just exposed and rotate until red dot is in line
with the holes in the frame tube. The spring
loaded adjustment pin should then pop through
the frame hole and lock leg into place. (Fig. 3)
Repeat for all other legs.
4. Once you have set the legs to the proper height,
turn the ADC-08 Stool upright and set on a hard,
flat surface for use.
COLLAPSING THE STOOL:
Reverse the set-up procedure to collapse stool for
packing. When collapsing the stool, depress spring
loaded adjustment pin and turn adjustable leg 90
degrees before pushing leg into frame. This will
prevent the legs from stopping at every adjustment
interval.
CLEANING AND MAINTENANCE:
Although bleach, when diluted to <10% and wiped
clean immediately could be used, it is not
recommended. The use of barrier covers and mild
cleaning solutions is recommended as the primary
asepsis approach on chair and stool upholstery
instead of relying on chemicals. The use of barriers
greatly extends the life of chair and stool upholstery
and can be replaced between patients.
MAKE SURE ALL LEGS ARE
EXTENDED TO THE SAME HEIGHT.
NEVER SIT ON THE EDGE OF THE
SITTING SURFACE. ALWAYS SIT IN
THE CENTER OF THE SEAT.
WARNING

Page 5
NOTES

Page 6
23 22
21
20
19
18
17
1615
14
13
12
11
10
9
8
7
6
54
3
2
1
24
PARTS DIAGRAM
Aseptico ADC-08
Portable Dental Stool
Figure 4 - Parts Diagram

PARTS LIST
Item Part Number Quantity
1Caster, 2” dual wheel 730210 4
2Adj. Leg Assy, inside L 330265 1
3Adj. Leg Assy, inside R 330266 1
4Adj. Leg Assy, outside L 330267 1
5Adj. Leg Assy, outside R 330268 1
6Leg, outside L 460834-08 1
7Leg, outside R 460835-08 1
8Leg Assy, inside 330269-08 1
9Leg stop 460432-08 1
10 Hinge, seat to leg 460829-08 2
11 Back Support Assy. 330080 1
12 Backrest Cushion Assy. 330074 1
13 Seat Cushion Assy. 330073 1
14 Endcap, 1"O.D. black 510204 2
15 Plug, 3/4" hole 510263 1
16 Spacer, .750 O.D. coved 510261 2
17 C/S, 5/16-18x1 ¾" S/S 510378 2
18 C/S, ¼-20x2 ¼" BtnSoc S/S 510440 2
19 C/S, ¼-20x1 ¼" BtnSoc S/S 510295 2
20 Nut, ¼-20 nyloc S/S 510296 3
21 Woodscrew, #10x1" flthd 510264 3
22 Spacer, 0.615"O.D.x1.0L Al 460894-08 2
23 C/S, 10-32x1” Flthd Soc S/S 510439 8
24 Strap, Retaining ADC-08 461954 1
Not Shown Case, grey carrying 410093 1
Page 7

P.O. Box 1548 • Woodinville, WA 98072-1548
1-800-426-5913 • 425-487-3157 • Fax: [phone]
email: [email protected] • Internet: www.aseptico.com
P/N: 420127
Rev. D
ECO 12356
06/2010
WARRANTY
PRINTED IN THE USA
Aseptico warrants its products against defects in material or workmanship for a
period of two (2) years, from date of original invoice. Some handpieces are
warranted for one year under the same conditions. Other handpieces and
expendable components, such as air turbines and light bulbs, are covered by shorter
warranty periods, or have no warranty. Aseptico's sole obligation under product
warranty is (at its sole option and discretion) to repair or replace any defective
component or product in part or whole. Aseptico shall be the sole arbiter of such
action.
In the event of alleged defect under warranty, the purchaser is to notify Aseptico's
Customer Service Department promptly. Customer Service will provide instructions,
usually directing that the product be returned for service. Shipment to Aseptico and
the cost thereof is always the responsibility of the purchaser.
Accidental misuse, inappropriate installation, or failure to perform directed
maintenance voids the warranty.
Aseptico does not assume, under this warranty, any risks or liabilities arising from the
clinical use of its products, whether or not such use involves coincidental utilization of
products manufactured by others.