Aseptico Command Air ADC-08CF User manual

P.O. Box 1548 Woodinville, WA 98072-1548
1-800-426-5913 * 425-487-3157 * Fax: [phone]
email: [email protected] * Internet: www.aseptico.com
P/N 420173
Rev. A
06/00
OPERATION AND
MAINTENANCE MANUAL
ADC-08CF
NSN: 6520-01-456-5406

Page 2
TABLE OF CONTENTS
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Purpose . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Performance Characteristics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Items Furnished . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Operation Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Stool Set-Up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Collapsing the Stool . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Cleaning & Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Parts Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
TABLE OF ILLUSTRATIONS
Figure 1 - Back Support Position . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Figure 2 - Fitting Cross Member Into Stop Channel . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Figure 3 - Leg Height Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Figure 4 - Parts Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

Page 3
PERFORMANCE CHARACTERISTICS:
Dimensions
Stool- Folded: 19” x 20” x 8.5”
Extended: 22” x 20” x (Max Height: 32” Min Height: 29”)
Soft carrying case: 19” x 21” x 9”
Mil. spec case: 25.5” x 24” x 19”
Mil. spec case volume: 6.73 Cu. Ft.
Weight
One (1) stool only: 14 lbs.
One (1) stool in soft carrying case: 16.5 lbs.
Two (2) stools & soft cases in mil. spec. case: 60 lbs.
Range of Positions
Minimum Seat Height: 19”
Maximum Seat Height: 22”
ITEMS FURNISHED
Two (2) ADC-08CF Command Air Portable Dental Stools
Two (2) Soft padded carrying case with handles
One (1) Mil-spec hard shell case
One (1) Operation and Maintenance Manual
PURPOSE:
Aseptico ADC-08CF Command Air Portable Operator Stools provide seating for a doctor and
an assistant during field dentistry and medical treatment. The padded seats and backrests make
these stools comfortable for extended use, while the folding design and light weight ensure
maximum portability. The ADC-08CF Stools are built with high strength steel frames and rugged
vinyl coverings, allowing for long term deployment.

Page 4
STOOL SET-UP:
1. Remove the stool from its carrying case and
swivel the back support to the upright position.
(Fig. 1)
2. Turn the ADC-08CF Stool upside down and set
on the edge of an elevated flat surface such as a
table or counter top. Scissor the leg frame so
that the frame cross member lines up with the
stop channel at the rear of the stool on the
underside. Fit the frame cross member into the
channel and push firmly into place. (Fig. 2)
3. Extend the legs to the proper height by pulling
the adjustable legs out of the frame. The
adjustable legs are marked with a red height
indicating dot. Pull the leg out until the red dot
is just exposed and rotate until red dot is in line
with the holes in the frame tube. The spring
loaded adjustment pin should then pop through
the frame hole and lock leg into place. (Fig. 3)
Repeat for all other legs.
4. Once you have set the legs to the proper height,
turn the ADC-08CF Stool upright and set on a
hard, flat surface for use.
COLLAPSING THE STOOL:
Reverse the set-up procedure to collapse stool for
packing. When collapsing the stool, depress spring
loaded adjustment pin and turn adjustable leg 90
degrees before pushing leg into frame. This will
prevent the legs from stopping at every adjustment
interval.
CLEANING AND MAINTENANCE:
The stool upholstery and frame may be wiped down
with water or a mild detergent solution. Sterilize
using a bleach/water solution.
Figure 1 - Backrest Positioning
Figure 2 - Securing Leg Frame
Figure 3 - Leg Height Adjustment
MAKE SURE ALL LEGS ARE
EXTENDED TO THE SAME HEIGHT.
NEVER SIT ON THE EDGE OF THE
SITTING SURFACE. ALWAYS SIT IN
THE CENTER OF THE SEAT.
WARNING

Page 5
PARTS LIST
Item Part Number Quantity
1Caster, 2-1/2” Hard Rubber 730267 4
2Adj. Leg Assy, inside L 330265 1
3Adj. Leg Assy, inside R 330266 1
4Adj. Leg Assy, outside L 330267 1
5Adj. Leg Assy, outside R 330268 1
6Leg, outside L 460834-08 1
7Leg, outside R 460835-08 1
8Leg Assy, inside 330269-08 1
9Leg stop 460432-08 1
10 Hinge, seat to leg 460829-08 2
11 Back Support Assy. 330080 1
12 Backrest Cushion Assy. 330074 1
13 Seat Cushion Assy. 330073 1
14 Endcap, 1"O.D. black 510204 2
15 Plug, 5/8" hole 510263 1
16 Spacer, .750 O.D. coved 510261 2
17 C/S, 5/16-18x1 ¾" S/S 510378 2
18 C/S, ¼-20x2 ¼" BtnSoc S/S 510440 2
19 C/S, ¼-20x1 ¼" BtnSoc S/S 510295 2
20 Nut, ¼-20 nyloc S/S 510296 3
21 Woodscrew, #10x1" flthd 510264 3
22 Spacer, 0.615"O.D.x1.0L Al 460894-08 2
23 C/S, 10-32x1” Flthd Soc S/S 510439 8
Not Shown Case, grey carrying 410093 1
Not Shown Case Mil-Spec 410104 1

Page 6
PARTS DIAGRAM
Aseptico AEU-08CF
Command Air Portable Dental Stool
Figure 4 - Parts Diagram

Page 7
NOTES

P.O. Box 1548 Woodinville, WA 98072-1548
1-800-426-5913 * 425-487-3157 * Fax: [phone]
email: [email protected] * Internet: www.aseptico.com