Backyard Creations 5SGZ2021-NN User manual

SKU# 272 2094
Model # 5SGZ2021-NN
CAUTION
This is NOT a permanent structure.
The canopy top should never be left on during periods of extended or heavy rain
nor any inclement weather where high winds or wind gusts can occur.
If left up, damage to the gazebo and surroundings can occur.
If you have questions or concerns, do not return to store. Please call toll free
888-445-4533.
FREMONT 10' X 10' ROOF STYLE GARDEN HOUSE

Table of Contents
Safety Information
Table of Contents .......
....... ........... ...............................2
Safety Information .......
................................................2
Part List..........................................................................3
Assembly .................................................................4~11
Care Instructions
Before using, wipe with a clean, dry cloth. Do not use bleach or solvents. Treat the frame with one-step liquid wax for maximum protection
against UV light and salty damp air. Wash the canopy with a mild solution of soap and water, rinse throughly, air dry completely..
Please properly tighten all hardware and perform periodic inspections during usage for cracked welds.
Care Instructions .......................................................2
WARNING:
of any foreign
WARNING: This garden house Gazebo is NOT a permanent structure and is designed for sunshade and privacy and must be used under
normal weather conditions. We recommend removal of the fabric canopy in windy conditions as gazebos catch wind similar to umbrellas. You
must however completely disassemble the unit prior to any severe weather conditions such as thunderstorm, hurricane, and/or heavy wind and
rain. Failure to remove the fabric canopy or disassemble the unit will cause the gazebo to have structure damage or even structural collapse.
CAUTION: Always install on level ground utilizing tie down cords and ground stakes. Do not permanently anchor unit to wood deck or
CAUTION: Garden house fabrics are water resistant but not water proof and may leak during precipitation. Fabrics will fade from direct
exposure to sunlight.
CAUTION: Keep all children and pets away from assembly area.
Begin assembly not less than 6 feet from any obstruction such as fence, garage, house, overhanging branches, clothes line or electrical wires.
Some parts may contain sharp edges, wear protective gloves if necessary. At least two are recommended for safe assembly.
concrete surface.
2/8

Part Illustration Quantity
A
B
C
D
E
F
G
H
AA
BB
CC
DD
EE
8
4
4
4
4
1
1
16
8
16
24
16
1+1
8
FF/GG
4
Part List
Cross beam
Joint
Corner post
Corner roof tube
Middle roof tube
Roof hub
Canopy Fabric
Guide rope
Bolt (M6x15)
Washer(M6)
Nut
Ground stake
Wrench
Bolt (M6x30)
HH
FF GG
Bolt (M6x50)
3/8

Step 1 Assembling Cross Beams
A
EE
EE EE
A
B
A
A
A
ABB
CC
DD DD
DD DD
Slide cross beams (A) into the joint (B). Align these beams to the joint properly.
Secure the cross beams to the joint with bolts (CC), washers (EE) and nuts (DD) using wrenches
(FF) and (GG). Fully tighten all bolts and nuts.
A
A
A
A
C
AA A
AA
AA AA
A
A
A
A
C
CC
C
C
C
Step 2 Erecting the main frame
*Team work is needed.
*Ladder is needed.
Keep the four holes at the top of each corner post facing towards you.
Link each two corner post with one each complete cross beam (A+A)
with bolts (AA) using wrench (GG).
Repeat this process until the whole main frame is up.
EE
A
4/8

D
Step 3 Attaching Corner Roof Tubes
click!
F
D
D
D
D
D
Put the ladder at the center of the frame. Identify the corner receivers on the roof hub (F).
At the top of the ladder, hold the roof hub (F) in the air with the four corner receivers pointing to
the four corners of the main frame.
Snap the corner roof tubes (D) into the four corner receivers.
Attach the other end of each corner roof tube (D) to the U-bracket (1) at the top of each corner post (C)
with bolt (BB) and nut (DD).
BB DD
C
A
A
C
F
D
D
1
5/8

click!
B
Step 4 Attaching Middle Roof Tubes
Snap middle roof tubes (E) into the remainingreceivers of the roof hub (F).
Attach the other end of each middle roof tube (E) to the U-bracket (2) of each joint (B)
with bolt (BB) and nut (DD) using wrenches (FF) and (GG).
E
E
E
E
F
E
BB DD
2
C
AA
D
E
E
A
A
6/8

G
Step 5 Putting on the Canopy Fabric
3
4
E
D
Place the canopy fabric on the roof frame.
Open the canopy fabric and pull the corner pockets (3) to the corners of the roof frame.
Cover the end of each corner roof tube (D) with one pocket (3) .
Cover the end of each middle roof tube (E) with one pocket (4).
7/8

HH
H
H
HH
H
C
H
HH
HH
HH
Step 6 Staking and Anchoring the Gazebo
Carefully adjust the position of the gazebo and make sure four corner posts are standing upright.
Hammer one ground stake (HH) through the hole at the bottom of each corner post (C)
into ground.
Secure one end of each guide rope (H) to the loop (5) in the corner of the canopy fabric. Measure
out from post to the longest possible distance to best use the length of the tie-down cord) and
secure the cord to ground at 45 degrees.
H
C
H
5G
G
Customer Service：
Supplier: Pacific Casual L.L.C.
Address: 1060 Avenida Acaso, Camarillo, CA 93012
TEL: [phone]
(7:30
8/8