Bobrick ConturaSeries B-4063 Operating and maintenance manual

In the U.S.A.: BOBRICK WASHROOM EQUIPMENT, INC.
#OMMERCE$RIVE#LIFTON0ARK.EW9ORKs4ELs&!8
(ART3TREET.ORTH(OLLYWOOD#ALIFORNIAs4ELs&!8
In Canada: BOBRICK WASHROOM EQUIPMENT COMPANY
2OLARK$RIVE3CARBOROUGH/NTARIO-2"s/NTARIO%AST4ELs&!8
s-ANITOBA7EST4ELs&!8
©"OBRICK7ASHROOM%QUIPMENT)NC
&ORM.OR0RINTEDIN53!
INSTRUCTIONS FOR INSTALLATION AND MAINTENANCE
Bobrick ConturaSeries®Model B-4063 Recessed Soap Dispenser
INSTALLATION:
5NITISTOBEMOUNTEDINROUGHWALLOPENINGggWIDEXggHIGHXMM-INIMUMRECESSEDDEPTHTOlNISHFACEOFWALLISgg
MM2ECESSEDMOUNTINGBOXISSECUREDWITHFOURXMMSHEETMETALSCREWSNOTFURNISHEDAND"OB+EY
 5NLATCHUNITWITH"OB+EYPROVIDEDBYINSERTINGENDOFKEYINTOSLOTINDOORFACE4ILT"OB+EYUPSOTHATLATCHINGMECHANISMDISENGAGESSOAP
DRAWERANDTILTTOPOFDRAWERFORWARD,IFTDRAWERSLIGHTLYANDPULLDRAWERWHILE"OB+EYISTILTEDUP3LIDEDRAWEROUTUNTILANGLEBRACKETSAT
REAROFSOAPVESSELSTOPAGAINSTDRAWERSTOPS
 4ILTDRAWERUPTOREMOVEFROMMOUNTINGBOX
 0LACEMOUNTINGBOXINWALLOPENINGANDSECURETOFRAMINGWITHMOUNTINGSCREWS
 ./4%5NITISTOBEMOUNTEDWITHTHESOAPVALVEOVERASINKORLAVATORY3PACERSHIMSSHOULDBEUSEDBETWEENMOUNTINGBOXANDFRAMED
WALLOPENINGTOPREVENTDISTORTIONORDAMAGETOCABINETWHENMOUNTINGSCREWSARETIGHTENED
 2EPLACESOAPDRAWERINMOUNTINGBOXANDPUSHBOTTOMOFDRAWERCLOSEDlRSTTHENPUSHTOPOFDRAWERFULLYCLOSEDTOLATCH9OUMAYNEEDTO
MOVEDRAWERSIDETOSIDESLIGHTLYASYOUARECLOSINGTHETOPOFTHEDRAWERTOENABLEITTOENGAGEPROPERLY
MAINTENANCE:
 5NLATCHUNITANDOPENDRAWERUNTILITISSTOPPEDAGAINSTDRAWERSTOPSASDESCRIBEDABOVE
 ./4%)TISNOTNECESSARYTOREMOVEDRAWERFROMMOUNTINGBOXFORRElLLING&ORMAINTENANCEANDCLEANINGPURPOSESTILTDRAWERUPWARDTO
REMOVEITFROMMOUNTINGBOX
 2EMOVEREDPLASTICLIDFROMSOAPVESSELANDlLLWITHSOAPCorrosion-resistant valve dispenses commercially marketed all-purpose
hand soaps.2EPLACEPLASTICLIDONSOAPVESSEL#LOSEDOORFULLYTOLATCH
 #LEANEQUIPMENTOPERATESBETTERLASTSLONGERANDREQUIRESLESSMAINTENANCE7IPETHEUNITDAILYINCLUDINGTHESPOUTUSINGADAMPCLOTH
Never use abrasive cleaners.
 0ERIODICALLYCLEANTHEDISPENSERBYPUMPINGWARMWATERMIXEDWITHSOAPFROMTHEDISPENSERTHROUGHTHEVESSELANDVALVETO mUSHOUT
CONTAMINANTSORDRIEDSOAPRESIDUENever use abrasive cleaners.
 )FTHESOAPVALVEFAILSTOOPERATESATISFACTORILYTHEPROBLEMMAYBECAUSEDBYDRIEDSOAPORDIRTCLOGGINGTHESPOUTORTHESOAPVALVE
4/2%-%$9#LEANSPOUTWITHENDOF"OB+EYANDORmUSHTHEDISPENSERASDESCRIBEDABOVE
 $O NOT DISASSEMBLE THE SOAP VALVE ./4% )F FOR ANY REASON THE VALVE BECOMES NONFUNCTIONAL A NEW SOAP VALVE REPLACEMENT KIT
0ART.OMUSTBEORDERED
7-1/4''
185mm 1/4''
6mm
Ty p.
S
S
S
S
Window
Stainless Steel
Faceplate
Push Button
Valve
6-3/8''
160mm
5-3/4''
145mm
Recessed Cabinet
Finish Face of Wall
7/8''
22mm
3-7/8''
100mm
3-1/2''
90mm
Ty p.
5-3/8''
135mm
1-7/8''
50mm
Ty p.
1-1/2''
40mm
1/8''
3mm S
S
S
Latch Release
Recommended Mounting Height Off Floor
For Universal / Barrier-Free Design
49" 1245mm
Rough Wall Opening
MMWIDE
MMHIGH
MMMINIMUM
RECESSEDDEPTH
QA033011

VALVE REPLACEMENT INSTRUCTIONS
TO REMOVE VALVE:
 5NLATCHUNITANDOPENDRAWERFROMMOUNTINGBRACKETASDESCRIBEDININSTALLATIONINSTRUCTIONS
 2EMOVEREDPLASTICLIDANDEMPTYSOAPVESSEL
 0LACEMMCLOSEDENDWRENCHPROVIDEDINSIDESOAPCONTAINERANDOVERTHELARGECOLLARNUTATREAROFSOAPVALVEANDLOOSENUNTILFACE
OFVALVECANROTATE
 7HILEHOLDINGTHECOLLARNUTINPLACEWITHTHEWRENCHUNSCREWSOAPVALVEFROMTHEFRONTOFTHEUNITBYROTATINGCOUNTERCLOCKWISE
TO INSTALL VALVE:
! /.5.)437)4(2/5.$(/,%).3/!0#/.4!).%2
 0ULLBACKmATRUBBERWASHERATREAROFSOAPVALVEFACETOEXPOSE
THETWOPLASTICTABS
 #UTPLASTICTABSOFFREAROFSOAPVALVEFACEmUSHWITHINDICATED
SURFACESEE&IGURE
 -OVEmATRUBBERWASHERBACKTOITSINITIALPOSITION-AKESUREmAT
EDGEOFWASHERISEVENWITHTOPOFVALVEFACE
 (OLDTHECOLLARNUTWITHTHEMMCLOSEDENDWRENCH-AKE
SURETHENOTCHINTHECOLLARNUTISFACINGTOWARDTHEFRONTOFTHE
DISPENSERANDPOSITIONNUTBEHINDSOAPVALVEHOLEINSIDEDISPENSER
 3CREWNEWSOAPVALVEINTOCOLLARNUTCLOCKWISEUNTILREAROFVALVE
FACEHITSTHEFRONTOFTHESOAPCONTAINER
 0USHTHESOAPVALVEINTOTHERECTANGULARRECESSINTHEFACEOFTHESOAPCONTAINERWITHSPOUTFACINGDOWNWARD
 4IGHTENCOLLARNUTWITHWRENCHUNTILTIGHTENOUGHSOTHATVALVEWILLNOTLEAKAROUNDSEALATFRONTOFUNIT
" /.5.)437)4(315!2%4/06!,6%(/,%).3/!0#/.4!).%2
 (OLDTHECOLLARNUTWITHTHEMMCLOSEDENDWRENCH-AKESURETHENOTCHINTHECOLLARNUTISFACINGTOWARDTHEFRONTOFTHEDISPENSER
ANDPOSITIONNUTBEHINDSOAPVALVEHOLEINSIDEDISPENSER
 3CREWNEWSOAPVALVEINTOCOLLARNUTCLOCKWISEUNTILREAROFVALVEFACEHITSTHEFRONTOFTHESOAPCONTAINER
 0USHTHESOAPVALVEINTOTHERECTANGULARRECESSINTHEFACEOFTHESOAPCONTAINERWITHSPOUTFACINGDOWNWARD
 4IGHTENCOLLARNUTWITHWRENCHUNTILTIGHTENOUGHSOTHATVALVEWILLNOTLEAKAROUNDSEALATFRONTOFUNIT
REFILL-INDICATOR WINDOW REPLACEMENT INSTRUCTIONS SEE&IGURE:
 5NLATCHUNITANDREMOVEDRAWERFROMMOUNTINGBOXASDESCRIBEDININSTALLATIONINSTRUCTIONS
 2EMOVEREDPLASTICLIDANDEMPTYSOAPVESSEL
 2EMOVECOLLARNUTFROMBACKOFRElLLINDICATORWINDOWINSIDEOFVESSELUSINGPLIERSORMMCLOSEDENDWRENCH
 2EMOVERElLLINDICATORWINDOWANDSEALFROMFACEOFDRAWER
 !SSEMBLENEWRElLLINDICATORWINDOWANDSEALTOFACEOFDRAWERBYREVERSINGABOVEPROCEDURE#OLLARNUTISTOBETIGHTENEDSO 
THATWINDOWWILLNOTLEAKAROUNDSEALATFRONTOFUNIT
INSTRUCTIONS FOR INSTALLATION AND MAINTENANCE
Bobrick ConturaSeries®Model B-4063 Recessed Soap Dispenser
PART NAME PART NO.
6ALVE2EPLACEMENT+IT 
#OLLAR.UTFOR6ALVE 
2ElLL)NDICATOR7INDOWWITH.UT 
#OLLAR.UTFOR7INDOW 
2ED0LASTIC,ID 
"OB+EY 
REPLACEMENT PARTS LIST
Plastic Tabs
to be Cut Off
Flush with this Surface
Plastic Tab (2)
Flat Rubber Washer
(moved back to
expose plastic tabs)
Latch Angle
Mounting Box
4063-83
4063-181
BobKey Slot
Angle Brackets
4112-79
305-127
4112-19
4063-48
Drawer Stops
24-17
Mounting
Screws (4)
FIGURE 1
FIGURE 2