Dura Trel Estate Trellis 11157 Installation guide

Model# 11157
Estate Trellis
W221122-A5080
*W201121-A2040*
*W201121-A2040*
*W201121-A2040*
*W201121-A2040*
*W201121-A2040*
*W201121-A2040*
QUESTIONS? COMMENTS? CONTACT US!
115 Vision Parkway 1-877-258-6020
P.O. Box 122 www.dura-trel.com
Sheboygan Falls, WI 53085 [e-mail]
Assembly Instruction Manual
Please read instructions thoroughly before beginning assembly.
Check boxes carefully for contents listed. Some parts are packaged inside of others.
Assemble on a clean, flat, non-abrasive surface to prevent scratching.
In the event of missing or damaged parts please call or email our customer service department at
the contact info below.
Tools Required
-Battery or Electric Drill (#2 phillips bit)
-Tape Measure
-PVC, Super or Crazy Glue

94"
58"
12"
Estate Trellis - Page 2

Lay out one right post (part 2). Starting at bottom
(end with hole 6” from post end), insert
horizontal cross rails from shortest to longest
(part 3-14) Part number 3,4,8 & 12 have a stop to
each part and they should face down toward the
narrow side.
Slide left post (part 1) over corresponding support
and cross rails.
Starting with center hole, insert 84” vertical rail
(part 15) through cross rails.
1
2
3
Estate Trellis - Page 3

Insert one 74” vertical rail (part 16) through
cross rails on either side of the center rail (part
15).
Insert 45½” vertical rails (part 17) through
cross rails on either side of part 16.
Insert 17½” vertical rails (part 18) through
cross rails on either side of part 17.
4
5
6
Estate Trellis - Page 4

To secure directly to wall, slide 6” screw through
clear screw backer. Insert screw through pre-
drilled hole in post and into wall. To set trellis
away from wall, place the spacer tube between
trellis and wall. After securing, snap screw cap
over screw backer.
(NOTE: The wall mounting screws included will
not fasten to stone, brick or concrete walls.)
Using ¾" painted screws, screw together trellis.
Be sure that all parts are fully inserted into
posts before securing.
9
7
Using PVC, super or crazy glue, glue post caps
onto posts and arrowhead caps onto vertical
rails.
8
Estate Trellis - Page 5

Warranty Statement
20 Year Guarantee
Please call manufacturer direct with questions concerning missing or defective parts at Toll Free:
877-258-6020.
Dura-trel, Inc. products are warranted to be free from manufacturing defects resulting in delaminating,
peeling, flaking, corroding, cracking, crazing, or extreme amounts of fading or bleaching causing the
PVC to change to its natural color for a period of 20 years from the date of purchase.
Normal weathering is defined as exposure to sunlight and extremes of weather and atmosphere which
will cause any colored surface to gradually fade.
CONDITIONS NOT COVERED BY THIS WARRANTY:
A. Physical abuse, misuse, neglect, or improper storage.
B. Improper installation or installation not in strict adherence to the instructions written by Dura-Trel,
Inc.
C. This warranty does not apply if materials are painted, varnished, or coated with any substance.
D. Dura-Trel, Inc. is not responsible for damages to product during shipping.
E. Damage attributable to atmospheric pollutants, hail, lightning, hurricane, tornado, wind borne
objects, earthquake, fire, mildew, casualty, act of God, building or ground settlement, or subjection to
stress or weight.
CLAIMS AND REMEDIES:
If a Dura-Trel, Inc. product is determined to have a manufacturing defect which is covered by this
warranty, Dura-Trel, Inc. will replace the material containing the defect (labor not included) F.O.B from
the point of manufacture. Dura-trel, Inc. will not be responsible for any cost incurred in the removal or
reinstallation of the product.
Important: All claims must be sent to the following address and should describe the defect claim.
Dura-Trel, Inc., P.O. Box 122, Sheboygan Falls, WI 53085
Dura-Trel, Inc. reserves the right to discontinue or change its design and/or color. If the original color
or style is not available, Dura-Trel, Inc. shall have the right to substitute a product designated by Dura-
Trel, Inc.
Dura-Trel, Inc. shall not be liable for any incidental, special, or consequential damages arising out of the
use of these products.
Estate Trellis - Page 6