Dura Trel Hartford Arbor User manual

3
Hartford Arbor
Lay out one outside vertical rail (part 5). Insert
one 16” rail (part 7) into center hole. Insert free
end of 16” rail through center hole of one
middle vertical rail (part 6). Insert free end of
the 16” rail into center hole of another outside
vertical rail (part 5).
On each end of assembly, slide vertical rails
through one center cross rail
(part 4). Slide center cross rails all the way to
16” rail.
On each end of assembly, insert one 16” rail
through middle vertical rail and into outside
vertical rails. The vertical rails will need to be
flexed to slide 16” into open holes.
Slide center cross rails away from middle 16”
rail. Center cross rails should be centered
between 16” rails.
1
2
3
4

Hartford Arbor
4
Insert free ends of vertical rails into
corresponding holes of each top/bottom
cross rail (part 3).
Lay out one right post (part 2). Insert cross
rails of assembly into corresponding holes of
right post. Slide left post (part 1) onto
corresponding holes of assembly. Be sure top
of posts with 3 pilot holes are at same end of
arbor panel.
Using eight 1½" screws, screw together arbor
panel. Be sure that all parts are fully inserted
into the posts before securing.
REPEAT steps 1-7 for second arbor panel.
5
6
7

Hartford Arbor
5
Using only one arbor top half from step 8,
slide two arbor top connector tubes (part 9)
into one end of arbor top half. Connector
tubes should be inserted half way (up to
black mark)
Lay out one arbor top arch half
(part 8). Insert four 36¾” rails
(part 11) into arch half. Slide another arch
half over 36¾” rails.
Using four 1½” screws, screw together arbor
top half. Be sure that all parts are fully
inserted before securing.
REPEAT using remaining two arbor top arch
halves and four 36¾" rails.
9
Using six ¾" screws, fasten both connector
tubes to arch halves. Be sure connector
tube is only inserted half way (up to black
mark).
8
10

Hartford Arbor
6
Connect two arbor halves by inserting
connector tubes into one end of remaining
arbor top half.
Slide one decorative knuckle (part 10) over
each connector tube and arch half. Slide
the knuckle up to the screws fastened in
step 10.
13
Using six ¾" screws, fasten arch halves to
each connector tubes to complete arbor
top.
11
12

Hartford Arbor
7
Slide one decorative knuckle (part 10) over
each connector tube and post end. Slide the
knuckle down to the screws fastened in step
14.
Insert one arbor top connector tube (part 9)
into end of each post with three pilot holes.
Connector tube will insert half way, resting
on cross rail (at black mark).
Using three ¾" screws per post, fasten
connector tubes to posts. .
16
Join posts with arbor top by inserting
connector tubes into free ends of arbor top.
Using three ¾" screws per post, fasten arbor
top to connector tubes.
14
15

Ground Anchor
Installation Layout
Hartford Arbor
8
ARBOR INSTALLATION
Option 1
Slide one 24” steel u-channel ground anchor
(part 12) into bottom of each post. Slide
ground anchor until it meets bottom cross
rail. Using 1” self-tapping white-head screw
fasten post to ground anchor.
Using ground anchor installation layout
drawing, dig holes approximately 16” deep.
Set arbor in holes and level. Back fill with
soil removed from holes. For permanent
installation fill with cement.
Option 2
Using ground anchor installation layout
drawing, pound ground anchors into ground
according to dimensions. When pounding
into ground, use block of wood to prevent
ground anchor from bending.
Slide arbor over ground anchors. Using 1”
self-tapping white-head screw fasten post to
ground anchor.
Option 3
Using ground anchor installation layout
drawing, dig holes 16” deep according to
dimensions. Fill with cement and place
ground anchors in wet cement. Be sure that
ground anchors are straight and in
accordance with dimension of ground
anchor installation layout drawing. Allow
cement to dry. NOTE: There is very little
room for error with this installation method.
Slide arbor over ground anchors. Using 1”
self-tapping white-head screw fasten post to
ground anchor.
17