Fri-Jado GO Combi User guide

Mounting instruction
Changing oven door opening direction
EN (Original Instruction) Revision 03/2023, SW: 0.5.9
GO Combi

2
GO Combi

3
GO Combi
GO Combi mounting instruction, revision 03/2023, SW: 0.5.9
General information 4
Target group....................................................................................... 4
Technical changes............................................................................... 4
More documentation.......................................................................... 4
Warranty ............................................................................................ 4
Permissions......................................................................................... 4
Safety information 5
Before replacement 6
Tools ............................................................................................. 6
Spare parts ......................................................................................... 6
Estimated working time...................................................................... 6
Oven overview 7
Changing the door opening direction 8
Dismounting the oven door ................................................................ 8
Mounting the oven door................................................................... 12
Calibrating the oven door................................................................. 17
Change the oven light ...................................................................... 19
Testing the oven ............................................................................... 19
Table of contents

4
GO Combi
General information
Target group
This document is aimed at service technicians who have been trained in installing and servicing the
oven. The oven must only be installed and serviced by qualified service technicians.
Technical changes
This document is subject to changes without notice.
More documentation
You find more documentation about the oven at our website.
Warranty
You find more information about warranty at our website.
Permissions
Log in as “Technician” (576021) to have the necessary rights to be able to change the oven setup,
use the test functions, update software, etc.

GO Combi mounting instruction, revision 03/2023, SW: 0.5.9 5
GO Combi
Safety information
Read this document before using, installing or servicing the product.
Installation and operation must comply with local regulations and accepted
codes of good practice.
Read the safety instructions in the user manual, installation manual and
service manual before you perform any work on the oven.
All maintenance and repair must be carried out by qualified installation and
service technicians only. Installation and/or service by others than qualified
service technicians may result in injury to the operator and/or damage to the
oven.

6
GO Combi
Before replacement
• Make sure the required tools are available.
• Unpack the spare parts and check if all parts are available.
• Make sure the working area is tidied up, clean and safe to prevent personal injury and damage
to the equipment.
• It is not possible to change oven door opening direction on roll-in ovens.
Tools
• Single-head wrench, 8 mm
• Straight slotted screwdriver
• Heaxagon socket spanner, size 4
• Socket screwdriver, 10 mm
• Pozi drive screwdriver, PZ2
• Loctite AS-43 WM
• Cable ties
Spare parts
None
Estimated working time
The estimated working time is two hours.

GO Combi mounting instruction, revision 03/2023, SW: 0.5.9 7
GO Combi
Oven overview
Oven door with door mounted on the left-hand side
Oven door with door mounted on the right-hand side

8
GO Combi
Changing the door opening
direction
IMPORTANT! All screws must be fastened with Loctite AS-43 WM.
Dismounting the oven door
1. Remove the cover from the upper and lower door hinge.
2. Open the oven door and loosen the inner and middle glass.
3. Loosen the two screws in the oven door frame.
1
1
3

GO Combi mounting instruction, revision 03/2023, SW: 0.5.9 9
GO Combi
4. Remove the wires from the upper rail on the oven door.
5. Press on the connector to loosen the wires using a small flat slotted screwdriver.
6. Pull out the wires.
7. Fasten the inner and middle glass on the oven door.
8. Remove the two screws, the bracket and the drain of the drip tray.

10
GO Combi
9. Remove the two screws and the drip tray
10. Loosen the wires for the LED fixture.
11. Remove the screws from the upper door hinge.
IMPORTANT! Be careful as the door is no longer fastened and might be heavy.
12. Remove the oven door.

11
GO Combi
GO Combi mounting instruction, revision 03/2023, SW: 0.5.9
13. Turn the pins upside down.
14. Turn the door upside down.

12
GO Combi
2. Remove the six hexagon socket spanner screws from the upper and lower door
hinge.
3. Pull out the wires for the door light.
Mounting the oven door
1. Remove the six screws in the cavity frame.
3
3

13
GO Combi
GO Combi mounting instruction, revision 03/2023, SW: 0.5.9
4. Move the upper and lower brackets for the hinges from the left-hand side of the
oven cavity frame to the right-hand side.
5. Remove the blanking plate.
6. Remove the catch.
7. Mount the blanking plate on the right-hand side of the oven cavity frame.
8. Mount the catch on the left-hand side of the oven cavity frame.
9. Switch around the door hinges - the lower hinge to the top and the upper hinge
to the bottom.
10. Mount the three screws on the lower hinge.
87

14
GO Combi
11. Mount the two nuts on the upper hinge while holding the door.
12. Mount the door.
13. Open the oven door and open the inner and middle glasses.
11
11

15
GO Combi
GO Combi mounting instruction, revision 03/2023, SW: 0.5.9
17. Switch around the two silicone plugs - place the one with the hole at the top and
the one without a hole at the bottom.
18. Mount the LED light with the wires pointing upwards.
19. Lead the wires through the upper silicone plug.
14. Fasten the drip tray with the two screws.
15. Fasten the drip tray drain, the gasket, the O-ring and the two screws
16. Adjust the door and make sure it touches the door gasket to avoid steam escaping
from the oven.
20. Fasten the wires in the terminal block.
19
14

16
GO Combi
23. Fasten the inner and middle glasses on the oven door.
24. Mount the hinge covers.
21. Mount the terminal block on the upper rack.
22. Fasten the upper bracket with the two screws.
24
24
22

17
GO Combi
GO Combi mounting instruction, revision 03/2023, SW: 0.5.9
Calibrating the oven door
Calibrating the operator door
1. Close the operator door.
If you are calibrating the operator door on a PassThrough oven,
make sure that the service door also is closed.
2. Touch “Settings”.
3. Touch “Oven setup”
4. Touch “Calibration”.
5. Touch “Calibrate operator door”.
6. Touch “Start calibration”.
7. Follow the steps in the sequence guide on the display.
6
2
3
4 5

18
GO Combi
Calibrating the service door
This section is only relevant on PassThrough oven.
1. Close both the operator door and service door.
2. Touch “Settings”.
3. Touch “Oven setup”
4. Touch “Calibration”.
5. Touch “Calibrate service door”.
6. Touch “Start calibration”.
7. Follow the steps in the sequence guide on the display.
6
2
3
45

19
GO Combi
GO Combi mounting instruction, revision 03/2023, SW: 0.5.9
Change the oven light
Calibrating the operator door
1. Touch “Settings”.
2. Touch “Oven setup”
3. Touch “Oven ligh”.
4. At “Left-hinged operator door” push the bar from “ON” to “OFF”.
5. On PassThrough ovens, at “left-hinged service door” push the bar from “ON” to
“OFF”.
Testing the oven
Run the oven in steam mode to assure that the oven door fit tightly to the gasket. If no
steam is escaping the oven from the oven door, the oven door is mounted correctly.
1
2
34

Fri-Jado B.V.
Blauwhekken 2
4751 XD Oud Gastel
North Brabant
The Netherlands
T: [phone]
M: [email protected]
Fri-Jado France LLC
31 Parc du Golf – CS 90519
350 Avenue JRGG de la Lauzière
13593 Aix-en-Provence Cedex 3
France
T: [phone]
M: fr[email protected]
Fri-Jado UK Ltd.
Ashley House
Ashley Road UB8 2GA
Uxbridge Middlesex
United Kingdom
T: [phone]
M: [email protected]
Fri-Jado Inc.
1401 Davey Road
Suite 100 Woodridge
IL 60517
USA
T: [phone]
M: [email protected]
GO Combi