Haws H1117.8HO User manual

APPROVED:
DRAWN:
PART NUMBER
SCALE: SHEET OF
REVISION
DRAWING TYPE: SIZE: A
BY:ECN NO.
DATE:
DATE:
ECN:
REVISED PER
CHK'D.:
Haws Corporation - All Rights Reserved. HAWS and other trademarks used in these materials are the exclusive property of Haws Corporation.
CR
MODEL(S)
1455 KLEPPE LANE
SPARKS, NEVADA 89431
[phone] FAX [phone]
E-MAIL: [email protected]
WEBSITE: WWW.HAWSCO.COM
THIS DOCUMENT IS TRUE AND CORRECT AT TIME OF PUBLICATION. CONTINUED PRODUCT IMPROVEMENTS
MAKE SPECIFICATIONS AND MEASUREMENTS SUBJECT TO CHANGE WITHOUT NOTICE.
FV
06/28/21
1
0510001207.D
H1117.8HO/H1117.8HO2
NA
13
FV 06/28/21
5706
DP
INSTALLATION
5706
2021
FV
CHILD/ADULT
WASTE
ADULT
STANDING
WASTE
A
12 12
DETAIL A
(NOT SUPPLIED)
SMALL BACK
PANEL
LARGE BACK
PANEL (SUPPLIED)
SMALL BACK
PANEL
1-1/4" IPS WASTE
(NOT SUPPLIED)
1-1/4" NPT TRAP
(SUPPLIED)
2X
MTGFR.17 MOUNTING FRAME
REQUIRED - SOLD SEPARATELY
FRAME
FLANGE
WALL FACE
5
2-7/8"
[73mm]
GRILLE
ELECTRICAL
WALL
ADULT
STANDING
BUBBLER
ADULT
STANDING
FOUNTAIN
CHILD/ADULT
BUBBLER
CHILD/ADULT
FOUNTAIN
FLOOR
(4)
[10 2mm]
MOUNTING
FRAME
WIDTH
STUD
SUPPLY STOP AND
3/8" OD TUBING
12
[305mm]
CLEARANCE
41
4
[108mm]
36-3/16
[920mm]
[791mm]
31-1/8
*
1-3/4
[44mm]
*
*
*
*
3
CHILLER SUPPORT TRAY 12
ROUGH-IN
ROUGH-IN
*
NOTES:
1. HOLD ROUGH-IN DIMENSIONS ± 1/8" (3.2mm)
2. WHEN INSTALLING THIS UNIT, LOCAL, STATE, OR
FEDERAL CODES SHOULD BE ADHERED TO. FOR
INSTALLATION DIMENSIONS (LOCATIONS), WASTE
AND SUPPLY REQUIREMENTS OTHER THAN SHOWN,
DIMENSIONS MARKED (*) MUST BE ADJUSTED
ACCORDINGLY.
3 REFER TO MTGFR.17 INSTALLATION DRAWING FOR
FRAME ROUGH-IN DIMENSIONS.
4 REFER TO 5874 SERIES OPERATION AND
MAINTENANCE MANUAL FOR PUSH BUTTON AND
VALVE INSTALLATION/MAINTENANCE INSTRUCTIONS.
5 ROUGH-IN DIMENSIONS FOR FOUNTAIN HEIGHTS:
CHILD WHEELCHAIR HEIGHT: SEE SHEET 3 FIG 1
WASTE: 26-1/4" (667mm)
FOUNTAIN: 24" (610mm)
BUBBLER: 29-7/8" (756mm)
ADULT WHEELCHAIR HEIGHT: SEE SHEET 3 FIG 2
WASTE: 29-1/4" (743mm)
FOUNTAIN: 27" (686mm)
BUBBLER: 32-7/8" (832mm)
ADULT STANDING HEIGHT: SEE SHEET 3 FIG 3
WASTE: 34-3/4" (883mm)
FOUNTAIN: 32-1/2" (826mm)
BUBBLER: 39-3/8" (972mm)
6. REFER TO MODEL H1117.8HO/H1117.8HO2
INSTALLATION DRAWING SHEET 3 OF 3 (ON HAWS
WEBSITE WWW.HAWSCO.COM) FOR PERMISSABLE
BOWL MOUNTING PATTERNS. TWO WHEELCHAIR
HEIGHT FOUNTAINS CANNOT BE MOUNTED SIDE BY
SIDE PER ANSI A117.1
NOTES CONTINUED ON SHEET 3 OF 3
3/8" OD TUBING,
INSULATION, TEE
& FITTING
(SUPPLIED)
INLINE STRAINER,
1/4" OD TUBE X
3/8" OD TUBE
INLET (SUPPLIED)
10 3
4
[272mm]
25
[635mm]
SUPPLY
39
[991mm]
(1 7
16 )
[36mm]
[305mm] [305mm]
1
2
[13mm]
187
8
[480mm]
32
[813mm]
406mm
16"
FRAME FLANGE BUTTS AGAINST
MUST BE INSTALLED SO THAT
IMPORTANT: MOUNTING FRAME
FINISHED WALL FACE.
SENSOR
FROM CHILLER OUTLET
TO
BUBBLER
HEAD
-Vo
+Vo
AC(L)
AC(N)
BLACK WIRE
WHITE WIRE
TRANSFORMER
SENSOR WIRING / SUPPLY PLUMBING
SCHEMATIC
TO PUSH
BUTTON
FOUNTAIN
VALVE
SOLENOID
VALVE
PRESSURE
REGULATOR
2X SHEET METAL
2X MOUNTING CLIP
INSIDE OF FRAME
(SUPPLIED)
SCREW
FRAME
MOUNTING
SCREW
(SUPPLIED)
2X MACHINE
GRILL
(SUPPLIED)
B
DETAIL B
BACK
PANELS
MODEL H1117.8HO SHOWN
MODEL H1117.8HO2 ON SHEET 2
(ROUGH-IN DIMENSIONS APPLY TO BOTH MODELS WITH EXCEPTIONS NOTED ON SHEET 2)
100-277VAC-9VDC
TRANSFORMER
AND DC CABLE
(SUPPLIED)
FROM DIRECT
CONTACT WITH WATER
MUST BE PROTECTED
13
LOCATE AND INSTALL
SENSOR
EYE
ELECTRICAL
9VDC SOLENOID VALVE
TRANSFORMER 13
13
(SUPPLIED)
HCR8
CHILLER
REQUIRED -
SOLD
SEPARATELY
5
*
5
*
5
*
5
*
5
*
REGULATOR
CONNECT 3/8" PUSH-TO-CONNECT TEE
TO 3/8" X 1/4" REDUCER THEN TO 1/4"
DIAMETER OUTLET TUBE ON HCR8
3
3
WITHIN WALL ACCESS
SURFACE
LINE
WATER CHILLER
(SUPPLIED)
4
1415°

SENSOR
SOLENOID VALVE
PRESSURE REGULATOR
FROM CHILLER OUTLET
TO BUBBLER
HEAD
SENSOR WIRING / SUPPLY PLUMBING
SCHEMATIC
SENSOR
SOLENOID VALVE
PRESSURE REGULATOR
TO BUBBLER
HEAD
POWER SPLITTER
CABLE
-Vo
+Vo
AC(L)
AC(N) BLACK WIRE
WHITE WIRE
TRANSFORMER
APPROVED:
DRAWN:
PART NUMBER
SCALE: SHEET OF
REVISION
DRAWING TYPE: SIZE: A
BY:ECN NO.
DATE:
DATE:
ECN:
REVISED PER
CHK'D.:
Haws Corporation - All Rights Reserved. HAWS and other trademarks used in these materials are the exclusive property of Haws Corporation.
CR
MODEL(S)
1455 KLEPPE LANE
SPARKS, NEVADA 89431
[phone] FAX [phone]
E-MAIL: [email protected]
WEBSITE: WWW.HAWSCO.COM
THIS DOCUMENT IS TRUE AND CORRECT AT TIME OF PUBLICATION. CONTINUED PRODUCT IMPROVEMENTS
MAKE SPECIFICATIONS AND MEASUREMENTS SUBJECT TO CHANGE WITHOUT NOTICE.
FV
06/28/21
1
0510001207
H1117.8HO/H1117.8HO2
NA
23
FV 06/28/21
5706
DP
INSTALLATION
5706
2021
FV
ELECTRICAL
FLOOR
3
100-277VAC-9VDC
TRANSFORMER
AND DC CABLE
(SUPPLIED)
FROM DIRECT
CONTACT WITH WATER
MUST BE PROTECTED
13
LOCATE AND INSTALL
SENSOR
EYE
ELECTRICAL
9VDC SOLENOID VALVE
TRANSFORMER 13
13
CONNECT 3/8" PUSH-TO-CONNECT TEE
TO 3/8" X 1/4" REDUCER THEN TO 1/4"
DIAMETER OUTLET TUBE ON HCR8
WITHIN WALL
ACCESS
LINE
WATER CHILLER
MODEL H1117.8HO2 SHOWN
MODEL H1117.8HO ON SHEET 1
(SEE SHEET 1 FOR APPLICABLE ROUGH-IN DIMENSIONS)
SENSOR
EYE
13
REGULATORS
CHILLER
HCR8
POWER SPLITTER CABLE13
1415°

FIGURE 1.
ADULT STANDING/CHILD WHEELCHAIR
FIGURE 2.
ADULT STANDING/ADULT WHEELCHAIR
FIGURE 3.
ADULT STANDING/ADULT STANDING
NOTES:
7 FIGURES 1 AND 2 ARE REVERSIBLE. CAN BE RIGHT OR LEFT SIDE HIGH.
8 USE SHADED HOLES TO MOUNT BOWLS AT INDICATED POSITIONS BASED
ON COMBINATION SELECTED (FIGS. 1 THRU 3).
9. REFER TO SHEET 1 OF 3 NOTE 5. FOR INSTALLED FOUNTAIN DIMENSIONS.
SCREW
11
10
11
SELECTED (SHOWN BY DARKENED HOLES). HOLE COMBINATION SHOWN (INSET)
INSERT 5/16"-18 PANEL NUT RETAINERS FROM OPPOSITE SIDE AT LOCATONS
11
7
8 (TYPICAL)
BOWL MOUNTING PATTERNS
10
TO CHANGE FOUNTAIN MTG. SCREW LOCATIONS: FIRST REMOVE SCREWS
AND THEN SQUEEZE CLIPS ON NUT RETAINER TO POP OUT. SNAP INTO
NEW POSITIONS AND RE-ASSEMBLE SCREWS.
IS FOR REF. ONLY
BOWL MOUNTING DETAIL
ALIGN HOLES IN CHILLER SUPPORT TRAY WITH HOLES IN FRAME
AND FASTEN WITH #10 SHEETMETAL SCREWS.
12
APPROVED:
DRAWN:
PART NUMBER
SCALE: SHEET OF
REVISION
DRAWING TYPE: SIZE: A
BY:ECN NO.
DATE:
DATE:
ECN:
REVISED PER
CHK'D.:
Haws Corporation - All Rights Reserved. HAWS and other trademarks used in these materials are the exclusive property of Haws Corporation.
CR
MODEL(S)
1455 KLEPPE LANE
SPARKS, NEVADA 89431
[phone] FAX [phone]
E-MAIL: [email protected]
WEBSITE: WWW.HAWSCO.COM
THIS DOCUMENT IS TRUE AND CORRECT AT TIME OF PUBLICATION. CONTINUED PRODUCT IMPROVEMENTS
MAKE SPECIFICATIONS AND MEASUREMENTS SUBJECT TO CHANGE WITHOUT NOTICE.
FV
06/28/21
1
0510001207
H1117.8HO/H1117.8HO2
N/A
33
FV 06/28/21
5706
DP
INSTALLATION
5706
2021
FV
REFER TO 1RKHO.H & 2RKHO.H OPERATION AND MAINTENANCE INSTRUCTIONS FOR TRANSFORMER
AND SENSOR SETUP.
13
7
MAXIMUM ADJUSTABLE RANGE IS 15° FROM PARALLEL TO BACK OF WALL.
14