human care Levanto User manual

Levanto
Part no. 20000170
User Manual

Contents
User Manual (EN)
Safety Instructions 3
Symbols 3
Intended Use 3
Product Benefits 3
Warnings 4
General Care and Use 5
Components 6
Technical Specifications 7
Product Label 8
Product Symbols 8
Understanding the Components 9
Usage Warnings 13
Usage Guidelines 14
Product Care 16
Troubleshooting 17
Maintenance 17
Service Checklist 18

www.humancaregroup.com 3
User Manual
Intended Use
Levanto
The Levanto is an electric sit-to-stand device
that encourages a natural standing motion
and is designed for standing, sitting, dressing,
toileting and balance training for users with low
core strength.
The Levanto can be used for transfer from the
following:
- To/from a wheelchair
- To/from a toilet
- To/from a bed/stretcher
Human Care’s products are continuously being
developed and updated and we reserve the
right to make design changes without prior
notice.
Important!
You must read the user manual for your
device prior to usage. Keep this booklet
and information handy for future use.
Symbols
Safety Instructions
WARNING symbol indicates a potentially
hazardous situation which, if not avoided,
could result in serious injury to the user
or damage to property and/or the device
itself.
INFORMATION symbol indicates
recommendations and information for
proper, trouble-free usage.
WEIGHT CAPACITY symbol indicates
maximum user weight for the product. Do
not exceed this weight in any circumstance.
CE MARKING symbol indicates product
meets requirements of EC directives.
RECYCLE packaging according to local
regulations.
READ INSTRUCTIONS and ensure you fully
understand them before using this product.
Product Benefits
For the patient
• Natural motion pattern
• Ideal for rehabilitation exercises
• Non-slip footplate surface
For the caregiver/facility
• Electronic leg spreading
• Shorter legs for easy maneouvring
• Helps prevent caregiver injury
EN

4www.humancaregroup.com
Warnings
The decision to use this equipment
must be made by a trained
professional. In all cases, this product
can only be articulate when the
patient is attended.
If you are unable to understand
the warnings, cautions and/or
instructions, contact a healthcare
professional, dealer or technical
personnel (if applicable) before
attempting to use this equipment.
Using this equipment without fully
understanding it may result in injury
or damage.
DO NOT USE the product if,
Weight capacity is exceeded.
Product is damaged in any way.
The sling clips are not securely and
adequately fastened.
You have not read and understood all
warnings and instrucons.
Warnings
Do not touch any parts which may
have leakage current and the patient
simultaneously.
Disconnect the power supply during
maintenance.
Product modification is not permitted
and will void the warranty. Service
and maintenance must only be done
by qualified personnel.
Use only the supplied power supply.
Use only replacement parts supplied
by Human Care.
To avoid the risk of electric shock, this
equipment must only be connected to
a supply main with protective earth.
Maximum user weight 160kg /
352.7lb.

ENGLISH
www.humancaregroup.com 5
Check the Levanto prior to each use to ensure it is not damaged in any way. Do not use if
there are any signs of wear and damage on any part of the device.
Only qualified persons should use
this equipment.
Under some circumstances, more
than one caregiver may be needed
to assist with the patient.
The Levanto should only be utilized
on a hard, even and clean floor clear
of any obstacles. It should never be
used on an incline or decline.
General Care and Use
Assess the patient’s ability prior to
using this product. Only use this
product for its intended purpose.
The right type, size, material and
design of accessories have been
selected by a professional with
respect to the client´s safety and
needs.
Facility administrator and/or risk
management department should
approve all patient handling
protocols associated with this
mobile lift prior to use.
Prior to using on a patient, it is
strongly recommended that training
or practice with other caregivers is
done until the user is comfortable
with using the product.
This product is intended for indoor
ambient environments. It is not
intended for use in high moisture
areas (i.e. showers, pool therapy),
extreme temperature, humidity or
pressure environments.
The Levanto may only be used with
Human Care products.
Charging of batteries should always
be done in a well ventilated space.
Inspect the charger regularly.
The Levanto is designed to be used
only with one patient at a time.
Never use this product to lift a
patient along with other furniture.

6www.humancaregroup.com
4
1
2
3
5
7
6
EN
Components
6. Front Wheel
7. Rear Wheel (with brake)
8. Hand Control (not shown)
9. Footplate (not shown)
1. Lift Arm
2. Push Handle
3. Battery/Control Box Unit
4. Actuator
5. Shin Pads

ENGLISH
www.humancaregroup.com 7
Technical Specifications
Descripon
Part no. 20000170
Width 68.7cm / 27”
Length 110cm / 43.3”
Height Arm Lowered: 88.9cm / 35”
Arm Raised1: 164.8cm / 64.9”
Height (from oor) 11.9cm / 4.7”
Adjustable Leg2(Min- Max) 67.9cm- 113.1cm / 26.7”- 44.5”
Sound Level 48dB (loaded) while liing
52dB (loaded) while spreading legs
IP Rang IPX4
Turning Radius 128cm / 50.3”
Wheels Front: 10cm / 4”
Rear: 12.5cm / 5”, with brake
Baery 24V DC, 2 x 12V/2.9Ah
Li-Ion accu, 24V DC/2.9Ah
Motor Liing: 24V DC, 8A max, 8kN, 10% duty cycle
Spreading: 24Vdc, 2. 3A max, 1.5kN, 10% duty cycle (2x)
Control Box 24Vdc, 10A max, 10% duty cycle
Charger Primary: 100-240VAC50 / 60Hz, 400mA
Secondary: 28.5VDC 37-53W
Approvals EN60601-1, EN60601-2
Weight 49kg / 108lb
Weight Capacity 160kg / 352.7lb
1 Measurement based on arm mast at highest seng 2Outside measurement

8www.humancaregroup.com
The product label contains information about
the device and is located on the right side, close
to the mast.
This product has been tested by an accredited
test institute and complies with the necessary
requirements in accordance with medical
requirements as follows: EN 10535, EN 60601-1
(Electrical Safety) and EN 60601-1-2 (EMC). This
product is CE marked.
Product Label
Symbols on the unit and product label:
CE Marking
Date of manufacture
Manufactured for Human Care
Maximum load
Instrucons: Read the instrucons and
make sure you understand them before
use
Part number/reference number
Serial number
Warning
The device contains electronics and it
must be recycled appropriately
Applied part type B: approved for
physical contact with paents (IEC
60601-1)
Product Symbols

ENGLISH
www.humancaregroup.com 9
Understanding the Components
1. Arm up
2. Arm down
3. Open legs
4. Close legs
1
2
3 4
1
2
Understanding the Control Box
1. Control funcons up/down
2. Emergency Stop
3. Mains socket
Understanding the Hand Control Emergency Stop
Use the emergency stop to turn o the li when
not in use to reduce the baery discharge.
Press the emergency stop
button located on the side
of the control box to stop
the lift.
Turn the button clockwise to
release the emergency stop.
3

10 www.humancaregroup.com
Battery
Always ensure that baery is suciently charged
before using this li. The baery will not charge if
the emergency stop is engaged.
The baery in this device is located in the module
along with the control box.
These batteries have a tamper proof seal that is
located on the battery to make it easier to see if
the battery has been tampered/replaced by a non-
authorized person. This seal should be replaced
after battery replacement.
Changing the Battery
Remove all external cables
from the control box. Remove
from frame.
On the back side of the
module, unscrew and remove
the 7 torx screws on the rear
of the control box/battery
module to open.
Disconnect the battery
connectors and remove the
old batteries.
Insert the new batteries in
the same direction as the old
batteries, with the connectors
at the top and connect (Note:
+= red, - = black). Be careful
not to bend the connectors.
Do not cover the holes.
Ensure that none of the
wires are squeezed or caught
when reinstalling the cover.
Ensure the mains is not
connected.
Ensure that the silicone string
is in place and properly fitted
before reinstalling the cover.
Replace seal if necessary.
The silicone string separates the battery from the
electronics and must not be damaged or modified
as it will allow penetration of battery gas into the
electronics components with risk of explosion. Do
not use if this seal is damaged in any way.
Charging the Battery
The battery should be charged minimum 8 hours
before used for the first time.