Hunter Products S606 Datasheet

Model No:S606
Item No:HUN9953
BATTERY OPERATED RIDE-ON
Children’s

(Linke/LKC-120100.S)

washer
screw nut has installed
in the steering wheel

3 years.

Turn the car upside down.
washer
washer

Assembly

washer
washer
washer
GEAR BOXGEAR BOX
Battery
Fuse box
R
L
Gearbox power supply
Power connector
Gearbox insert Gearbox insert
Assembly

Assembly
Assembly
1
Attach the steering wheel.
Remove the nut and bolt from
the steering wheel.
Insert the steering wheel over the
steering and secure with nut and bolt.
2

Assembly

The battery features a thermal fuse with a reset fuse that will automatically trip and cut all
power to the vehicle if the motor, electric system or battery is overloaded. The fuse will
reset and power will be restored after the unit is turned OFF for 20 seconds and then turned
ON again. If the thermal fuse trips repeatedly during normal use, the vehicle may need
repair. From your distributor please to Hunter Products - [email protected]
To avoid losing power, follow these guidelines:
● Do not overload the vehicle.
● Do not tow anything behind the vehicle.
● Do not drive up steep slopes.
● Do not drive into fixed objects, which may cause the wheels to spin, causing the motor to
overheat.
● Do not drive in very hot weather, components may overheat.
● Do not allow water or other liquids to come in contact with the battery or other electric
components.
● Do not tamper with the electric system. Doing so may create a short, causing the fuse to
trip.
Battery Replacement and Disposal
The battery will eventually lose the ability to hold a charge . Depending on the amount of
use, and varying conditions, the battery should operate for one to three years. Follow these
steps to replace and dispose the battery:
1. Remove the car seat.
2. Disconnect the battery connectors.
3. Remove the battery bracket.
4. Remove the battery cover.
5. Carefully lift the battery.
● Depending on the condition of the battery (i.e.: leakage) you may want to wear
protective gloves before removal.
● Do not lift the battery by its connectors or cables.
6. Place the dead battery in a plastic bag.
Important! Recycle the dead battery responsibly. The battery contains lead acid
(electrolyte) and must be disposed of properly and legally. It is illegal in most areas to
incinerate lead acid batteries or dispose of them in landfills. Take it to a federal or
state-approved lead acid battery recycler, such as local automotive battery retailer.
Do not throw the battery away with your regular household waste!
7. Replace the battery and reconnect the connectors.
8. Replace the metal battery bracket.
9. Replace the seat.
13. Battery Replacement & Fuse

Problem Possible Cause Solution
Vehicle does not run
Vehicle does not run
very long
Vehicle runs sluggishly
Vehicle needs a push to
go forward
Difficult shifting from
forward to reverse or
vice-versa
Loud grinding or clicking
noises coming from
motor or gear box
Battery low on power
Thermal fuse has tripped
Battery connector or wires are
loose
Battery is dead
Electrical system is damaged
Motor is damaged
Vehicle still connected to
charger
Battery is under charged
Battery is old
Battery is old
Vehicle is overload
Vehicle is being used in harsh
conditions
Poor contact of wires or
connectors
“Dead Spot” on motor
Motor or gears are damaged
Battery low on power
Recharge battery.
Reset fuse, see <Fuse>
Disconnect charger from vehicle before operating.
Check that the battery connectors are firmly plugged into each
other. If wires are loose around the motor from your distributor
please to Hunter Products -
[email protected]
Check that the battery connectors are firmly plugged into each
other. If wires are loose around the motor, from your distributor
please to Hunter Products - [email protected]
A dead spot means the electric power is not being delivered to the
terminal connection and the vehicle needs repair.From your
distributor please to Hunter Products -
[email protected]
Attempting to shift while the
vehicle is motion
Completely stop the vehicle and shift, see <Use Your
Ride-On>
Check that the battery connectors are firmly plugged
into each other when recharging
Replace battery, from your distributor please to
Hunter Products - [email protected]
Replace battery, from your distributor please to Hunter
Products - [email protected]
Replace battery, from your distributor please to Hunter
Products - [email protected]
Reduce weight on vehicle. Maximum user weight is 30kg.
Avoid using vehicle in harsh conditions, see <Safety>.
Recharge battery, from your distributor please to Hunter
Products - [email protected]
From your distributor please to Hunter Products -
[email protected]
From your distributor please to Hunter Products -
[email protected]
From your distributor please to Hunter Products -
[email protected]
From your distributor please to Hunter Products -
[email protected]
Battery will not
recharge
Charger feels warm
when recharging
Battery connector or adapter
connector is loose
Charger not plugged in
Charger is not working
This is normal and not a
cause for concern
Check that the battery connectors are firmly plugged into
each other.
Check that the battery charger is plugged into a working
wall outlet.
Completely read through this manual and the troubleshooting guide table before calling. If you
still need help resolving the problem From your distributor please to Hunter Products -
[email protected].
14. Troubleshooting Guide

15. Maintaining
• It is parents' responsibility to check main parts of the toy before using, Must
regularly examine for potential hazard, such as the battery, charge,cable or
cord, plug, screws are fastening enclosure of other parts and that in the event
of such damage, the toy must not be used until that damage had been properly
removed.
• Make sure the plastic parts of the vehicle are not cracked or broken.
• Occasionally use a lightweight oil to lubricate moving parts such as wheels.
• Park the vehicle indoors or cover it with a tarp to protect it from wet weather.
• Keep the vehicle away from sources of heat, such as stoves and heaters.
Plastic parts may melt.
• Recharge the battery after each use. Only an adult can handle the battery.
Recharge the battery at least once a month when the vehicle Raider is not
being used.
• Do not wash the vehicle with a hose. Do not wash the vehicle with soap and
water. Do not drive the vehicle in rainy or snowy weather. Water will damage
the motor, electric system and battery.
• Clean the vehicle with a soft, dry cloth. To restore shine to plastic parts, use a
non-wax furniture polish. Do not use car wax. Do not use abrasive cleaners.
• Do not drive the vehicle in loose dirt, sand or fine gravel which could damage
the moving parts, motors or the electric system.
• When not using, all the electrical source should be turn off. Turn off the
power switch and disconnect the battery connection.

HUNTER PRODUCTS
Level 2, 424 Warrigal Road Moorabbin 3189
Ph: 1800 224 094
Office hours: Monday to Friday 9am to 5pm AEST
Email: [email protected]
20200828
Our goods come with guarantees that cannot be excluded under the Australian Consumer Law.
You are entitled to a replacement or refund for a major failure and for compensation for any
other reasonably foreseeable loss or damage. You are also entitled to have the goods repaired
or replaced if the goods fail to be of acceptable quality and the failure does not amount to a
major failure.
Where a failure does not amount to a major failure, we are entitled to choose between
providing you with a repair, replacement or refund. To obtain compensation, you would need
to provide documentary evidence of the loss or damage suffered, and documentary evidence
that such loss or damage was a reasonably foreseeable consequence of a failure by us to
comply with a consumer guarantee under the Australian Consumer Law. Such evidence may
include photographs, statutory declarations, receipts or reports (e.g. from your doctor),
depending on the loss or damage.
In addition to all rights and remedies to which you may be entitled under the Competition and
Consumer Act 2010 (Commonwealth) and any other relevant legislation, the manufacturer
warrants this product to be free from defects in materials or workmanship for a period as
stated on the packaging from the date of purchase.
In order to claim under this warranty, you will need to bring the product to the store of
purchase, along with proof of purchase (typically this will be a receipt). Any cost incurred by
you in bringing the product to the service desk will be borne by you. We will then, at our
option, either repair or replace the product, or refund your money and take back the product.
Our liability under this manufacturer’s warranty is subject to us being satisfied that a defect
was caused by defective workmanship or materials, and was not caused by or substantially
contributed to by other factors, or circumstances beyond our control, including (but not
limited to) defective installation, maintenance or repair, alteration or modification of the
product in any manner not recommended by the manufacturer or any neglect, misuse or
excessive use.
The benefits conferred by this manufacturer’s warranty are in addition to all rights and
remedies conveyed by the Competition and Consumer Act 2010 (Commonwealth), and any
other statutory rights to which you may already be entitled, and this warranty does not
exclude, restrict or modify any such rights or remedies that are implied by law.