Hunter Products TR1103 User manual

CHILDREN'S
ELECTRONIC
TOY
VEHICLE
•Suitable for 3+
years
•Maximum user
weight:
25
kg
•Adult
assembly
required
OWNER'S MANUAL
Read and understand this entire manual before using!
Please
keep
this manual for future reference as it contains
important
information
Before first time use,
charge
the
battery
for at least 8-12 hours,no more than
20 hours
ITEM NO: 2406/2635
MODEL NO: TR1103

Table of Contents
1.
About
Your
New Vehicle
2. Parts
List
3. Parts
Diagram
4.
Assembly
Steps
5.
ow
To Operation
Your
Vehicle
6.
Charging
The Vehicle
7.
Troubleshooting
Guide
8.
Maintaining
Your
Vehicle
9.
Disposal
Of
Battery
About Your New Vehicle
Thank you for your purchasing our products, we wants your child to enjoy this product for years to
come. Keep these points in mind as you read this guide:
Suitable age: 3+years Battery: DC 6V 4.5AH *1
Load Capacity: Under 25Kg Size of car: 680*400*460mm
Speed: 2.5-3Km/h Carton size: 640*380*310mm
Material: PP Optimum
Temperature:
Below 40°C
Avoid to use under burning sun
Charger:
Input: Shown on the charger Charging time:8-12 hours,at most 20 hours
Ou pu : DC 6V Fuse: F 5A, Self-rese ing
Curren : DC 0.5A
WARNING!
FOR THE SAFETY OF YOUR CHILD, PLEASE READ ALL WARNINGS AND
ASSEMBLY/USE INSTRUCTIONS. KEEP THIS GUIDE FOR FUTURE REFERENCE.
•ADULT ASSEMBLY REQUIRED. The product contains small parts, which are for
adult assembly only. Keep small children away when assembling.
•Always remove protective material and poly bags and dispose before assembly.
-1-

Parts List
PART
NO
PART
NAME PICTURE Q,ty (pcs)
REMARKS
PART
NO
PART
NAME PICTURE Q,ty (pcs)
REMARKS
1Vehicle
body 12Handle 1
3Bumper 14Gear
box 1
5Driving
wheel 16Wheel 3
7Round
tube 1
Placed
in the
Rear
axle
8Rear
axle 1
9M10
Washer 9
Placed
in the
rear and
front
axle and
handle
10 M Nut 5
Placed
in the
rear and
front axle
and
handle
-2-

Parts List
Assembly package
PART
NO
PART
NAME PICTURE Q,ty (pcs)
REMARKS
PART
NO
PART
NAME PICTURE Q,ty (pcs)
REMARKS
11 Hub cap 412 M3.5X12
Screw 2
13 Charger 114 Instruction
manual 1
15 Spanner 2
-3-

Parts Diagram
NOTE: Some Parts Shown are assembled
on both sides of vehicle
1Vehicle body *12Handle*1 3Bumper*1 4Gear box*1 5Driving wheel*16Wheel*3 7Round ube*18Rear axle*1 9M10 Washer*910 M8 Nu *5
11 Hub cap*412 M3.5X12 Screw*2
Hammer(not included)
Pliers(not inclued)
Screwdriver(not included)
Tools Required
Spanner
-4-

Assembly Steps
Your new vehicle requires adult assembly. Please set aside at least 40 minutes for
assembly. Children can be harmed by small parts, sharp edges and sharp points in the
vehicle's unassembled state. Care should be taken in unpacking and assembly of the
vehicle. Children should not handle parts, or help in assembly of the vehicle.
Please identify all parts before assembly and save all packaging material until assembly
is complete to ensure that no parts are discarded.
ssembly tool for need: screwdriver(not included), pliers(not included), hammer(not
included), spanner.
1. Install the back wheels
Turn over the car body,and plug the
wire connector into the motor
connector.
Turn over the car body,and disconnect the rear axle parts,then put the rear axle through the car
body.
Put the gear box is arranged on the left.(when reverse side up)
Put the driving wheel through the back axle and fix it with washer,nut and the hub cap in turn.
Put the washer,round tube,washer,wheel and another washer through the back axle on the other
side in turn,then fix them with nut and hub cap.
-5-

Assembly Steps
2. Install the front wheels.
Remove the nut and washer on the
front axle;
As showed in the picture, fix the
washer, wheel, washer and nut onto
the axle in proper order.
Fasten the nut with spanner.
Fix the hub cap.
Fix another wheel on the other side.
3. Install the handle.
Install the handlebar and steering
column. put through the hole on
the top of the ride on body.
As shown in the picture,ensure the
end of the steering column locates
correctly into the front axle.
Then push firmly down on to the
handlebar. and fasten with washer
and nut.(PIC1, )
-6-

Assembly Steps
4. Connect the wire connector plug.
As shown in the picture,the wire
connector plug butt.
5. Install the bumper.
As shown in the picture, install the
bumper to the corresponding
place,and fasten with screws.
6. Connect the power supply.
As shown in Figure 1 , unscrew the
bolt,and open the seat.
Dock the wire connector A and the
wire connector B.
Then install the seat to the
corresponding place, and fasten with
the bolt.
-7-

Assembly Steps
7. Install the Battery.
Loosen battery
cover
of
handle and remove the cover. Insert two
AA1.5V
batteries(See above
photo). Replace battery cover .
Use 2X "AA" for batteries - not in cluded.

Alkaline
Battery
is Recommended.
Do not
allow
children to
play
with batteries.
Do not mix old and new batteries or different
type
of batteries.

non-rechar eable
batteries are not to be
rechar ed;
different
type
of batteries or new and used batteries are not to be mixed;
batteries are to be inserted with the correct
polarity;
exhausted batteries are to be removed from the
toy;
the
supply
terminals are not to be short-circuited.

rechar eable
batteries are
only
to be
char ed
under adult supervision;

rechar eable
batteries are to be removed from the
toy
before
bein
char ed;
The transformers or
battery
char er
used with the
toy
are to be
re ularly
examined for
dama e
to the cord,
plu ,
enclosure and other parts, and in the event of such
dama e,
they
must
not be used until that
dama e
had been repaired.
IMPORTANT SUPPLEMENT TO INSTRUCTION MANUAL
After assembling any wheel to the axles, please check the gap
between the screw thread and the collapsible (refer to below
picture), if the gap is too big, please add two or three washers inside
the wheel, But after tightening the nut outside the wheel, please turn
the wheel by your finger to check if the wheel can run smoothly, this
is very important, because if the wheel can run smoothly, it is ok, but
if the nut press the wheel and the wheel can’t run smoothly, the
motor will be broken easily! Then you need to decrease one or two
washers to make sure the wheel can run smoothly!
-8-

How To perate Your Vehicle
Must confirm before using
that
following
work
which
is already
finished:
•
Important!
Before
using
the vehicle for the first time, the
battery
needs to be
charged
for 8 to 12 hours,
no more than 20 hours.
Only
an adult can
charge
or
recharge
the
battery.
•
Finishing
the
complete
motorcycle
to assemble
according
to the
steps
that the manual described. The
plug-in
pac age
of
storage
battery
has
already
been inserted well, the power has
already
been put
through.
•
All
places to need the screw
guarantee
the
screw
has
already
been loc ed.
Rules
for
Safe Riding
READ THESE RULES ALOUD TO YOUR CHILD AND THEIR PLAYMATES AND MAKE
SURE THEY UNDERSTAND THEM!
•This
toy
is no
brea .Always
wear a helmet and
protective
clothing
when
riding.
•Direct
Adult
Supervision
Required.
•
Keep
Children within Safe
Riding
Areas
.
•Never use in
roadway,
near motor vehicles, on lawn
space,
on or near
steep
inclines or
steps,
swimming
pools
or other bodies of water.
•Use the
toy
only
on flat surfaces. such as inside
your
house,
garden
or
playground.
•Never use in the dar .
A
child could encounter
unexpected
obstacles and have an accident.
Operate
the
vehicle
only
in the
daytime
or a
well-lit
area.
•It is not recommended to drive the vehicle on wet surfaces or on
lopes
of
greater
than 15
degrees.
•Do not use this vehicle outdoors when it is
raining
or
snowing.
•Ma e sure
you
come to a
complete
stop
before
changing
directions from forward to bac .
•Please follow the correct
weight
and
age
limits allowed to drive this vehicle.
•It is
prohibited
to
change
the circuit or add other electric
parts
•
Inspect
wires and connections of the vehicle
periodically.
•In order to avoid accidents,
please
ensure the vehicle is safe before
riding.
•Do not let
any
child touch the wheels or be near them when the
car
is
moving
.
•This vehicle has
adjustable
play
seat belts.
please
instruct children how to tie the
safety
belt before
using,
guarantee
the
security.
WARNING!
PREVENT INJURIES AND DEATHS:
•NEVER LEAVE CHILD UNATTENDED. DIRECT ADULT SUPERVISION IS
REQUIRED. Always keep child in view when child is in vehicle.
•Never use in roadways, near cars, on or near steep inclines or steps,
swimming pools or other bodies of water.
•Always wear shoes.
•Always sit on the seat.
•Suitable for age 3+years; Maximum user weight is 5kgs.
•Not to be used in traffic .
-9-