IEI Technology AFL2-W21A/AB-H61 SERIES User manual

AFL2-W21A/AB-H61
Page I
IEITechnology Corp.
User Manual
AFL2-W21A/AB-H61 Series
MODEL:
Flat Bezel Panel PC with Intel® Core™ i7/ i5/ i3 and Pentium®
processor, Touch Screen, Wi-Fi, USB, Dual GbE LAN ,
RS-232/422/485, 2.0M pixels Camera,
HD Audio and RoHS
Rev. 1.00 - 16 April, 2013
User Manual

AFL2-W21A/AB-H61
Page II
Revision
Date Version Changes
16 April 2013 1.00 Initial release

AFL2-W21A/AB-H61
Page III
Copyright
COPYRIGHT NOTICE
The information in this document is subject to change without prior notice in order to
improve reliability, design and function and does not represent a commitment on the part
of the manufacturer.
In no event will the manufacturer be liable for direct, indirect, special, incidental, or
consequential damages arising out of the use or inability to use the product or
documentation, even if advised of the possibility of such damages.
This document contains proprietary information protected by copyright. All rights are
reserved. No part of this manual may be reproduced by any mechanical, electronic, or
other means in any form without prior written permission of the manufacturer.
TRADEMARKS
All registered trademarks and product names mentioned herein are used for identification
purposes only and may be trademarks and/or registered trademarks of their respective
owners.

AFL2-W21A/AB-H61
Page IV
Table ofContents
1 INTRODUCTION.......................................................................................................... 1
1.1AFL2-W21A/AB-H61 FLAT BEZEL PANEL PC OVERVIEW ........................................ 2
1.1.1 Model Variations................................................................................................ 3
1.1.2 Features ............................................................................................................. 3
1.1.3 Light Fanless Technology Design...................................................................... 4
1.2 EXTERNAL OVERVIEW................................................................................................ 5
1.2.1 Front Panel ........................................................................................................ 5
1.2.1.1 Function Keys............................................................................................. 5
1.2.2 Rear Panel ......................................................................................................... 6
1.2.3 Bottom Panel...................................................................................................... 7
1.2.4 Left Side Panel................................................................................................... 8
1.2.5 Right Side Panel................................................................................................. 8
1.3 INTERNAL OVERVIEW................................................................................................. 9
1.4 SYSTEM SPECIFICATIONS............................................................................................ 9
1.5 DIMENSIONS............................................................................................................. 12
2 LED LIGHT BAR (OPTIONAL)............................................................................... 13
2.1 OVERVIEW................................................................................................................ 14
2.2 IEI LED LIGHT BAR DISPLAY SIMULATOR ............................................................... 14
2.3 IEI LED RUN............................................................................................................ 22
2.4 LED CONTROLAPI.................................................................................................. 23
2.4.1 Introduction...................................................................................................... 23
2.4.1.1 Programming Language Support.............................................................. 23
2.4.1.2 Application Content .................................................................................. 23
2.4.2 LED Control API Functions............................................................................. 23
2.4.2.1 LIGHTBAR_DriverInit ............................................................................ 23
2.4.2.2 LIGHTBAR_DriverUninit........................................................................ 24
2.4.2.3 LIGHTBAR_DeviceInit ........................................................................... 24
2.4.2.4 LIGHTBAR_DeviceClose........................................................................ 24
2.4.2.5 LIGHTBAR_Brightness_Single............................................................... 25
2.4.2.6 LIGHTBAR_BLNK_Settings................................................................... 25

AFL2-W21A/AB-H61
Page V
2.4.2.7 LIGHTBAR_BLNK_Type........................................................................ 26
2.4.2.8 LIGHTBAR_LED_ModeSet.................................................................... 26
2.4.3 Structures ......................................................................................................... 27
2.4.3.1 _LED_COLOR_INFO.............................................................................. 27
2.4.3.2 _LED_BLNK_SET................................................................................... 27
2.4.3.3 _LED_BLNK_SET................................................................................... 28
2.4.3.4 _LED_MODE_SETTINGS...................................................................... 29
2.4.4 Programming Example.................................................................................... 29
2.4.4.1 Turn on LED - single ................................................................................ 29
2.4.4.2 Turn on LED - multiple............................................................................. 30
2.4.4.3 LED Blink - 1............................................................................................ 32
2.4.4.4 LED Blink - 2............................................................................................ 33
3 UNPACKING............................................................................................................... 35
3.1 UNPACKING.............................................................................................................. 36
3.1.1 Packing List ..................................................................................................... 36
4 INSTALLATION ......................................................................................................... 39
4.1ANTI-STATIC PRECAUTIONS...................................................................................... 40
4.2 INSTALLATION PRECAUTIONS................................................................................... 40
4.3 INSTALLATION AND CONFIGURATION STEPS ............................................................. 41
4.4 HDD INSTALLATION................................................................................................. 41
4.5 K-TYPE TEMPERATURE SENSOR INSTALLATION ....................................................... 44
4.6 RFID READER (OPTIONAL)...................................................................................... 45
4.7 DVD-ROM INSTALLATION (OPTIONAL).................................................................. 46
4.8AT/ATX MODE SELECTION...................................................................................... 48
4.8.1 AT Power Mode................................................................................................ 48
4.8.2 ATX Power Mode............................................................................................. 49
4.9 CLEAR CMOS.......................................................................................................... 49
4.10 RESET THE SYSTEM................................................................................................ 50
4.11 POWERING ON THE SYSTEM ................................................................................... 50
4.12 POWERING OFF THE SYSTEM.................................................................................. 50
4.13 MOUNTING THE SYSTEM ........................................................................................ 51
4.13.1 Wall Mounting................................................................................................ 51
4.13.2 Panel Mounting.............................................................................................. 54

AFL2-W21A/AB-H61
Page VI
4.13.3 Stand Mounting.............................................................................................. 56
4.13.4 Arm Mounting................................................................................................ 57
4.14 EXTERNAL PERIPHERAL DEVICE CONNECTION ...................................................... 59
4.14.1 Audio Connection........................................................................................... 59
4.14.2 HDMI Device Connection.............................................................................. 60
4.14.3 LAN Connection............................................................................................. 62
4.14.4 Serial Device Connection .............................................................................. 63
4.14.5 USB Device Connection................................................................................. 65
4.14.6 VGA Monitor Connection .............................................................................. 67
5 SYSTEM MOTHERBOARD ..................................................................................... 69
5.1 OVERVIEW................................................................................................................ 70
5.1.1 Layout .............................................................................................................. 70
5.1.2 Peripheral Interface Connectors ..................................................................... 71
5.2 INTERNAL PERIPHERAL CONNECTORS ...................................................................... 73
5.2.1 Auto-Dimming Connector................................................................................ 73
5.2.2 Battery Connector............................................................................................ 74
5.2.3 BIOS Programming Connector........................................................................ 74
5.2.4 Bluetooth Connector........................................................................................ 75
5.2.5 CPU Fan Connector........................................................................................ 76
5.2.6 DDR3 SO-DIMM Slots .................................................................................... 77
5.2.7 Debug Port Connector..................................................................................... 78
5.2.8 Digital Microphone Connector........................................................................ 79
5.2.9 EC Debug Connector....................................................................................... 80
5.2.10 EC Programming Connector ......................................................................... 81
5.2.11 Hotkey Connector........................................................................................... 82
5.2.12 Hotkey LED Connector.................................................................................. 82
5.2.13 JSATA Connector ........................................................................................... 83
5.2.14 K Type Thermocouple Connector.................................................................. 84
5.2.15 LVDS Connector............................................................................................ 86
5.2.16 LVDS Backlight Inverter Connector.............................................................. 87
5.2.17 LED Connector.............................................................................................. 88
5.2.18 Light Bar Connectors..................................................................................... 89
5.2.19 LOGO LED Connector.................................................................................. 90
5.2.20 Mini USB Connector...................................................................................... 91

AFL2-W21A/AB-H61
Page VII
5.2.21 PCIe Mini Card Slot ...................................................................................... 93
5.2.22 Power Button Connector................................................................................ 94
5.2.23 RFID Connector............................................................................................. 94
5.2.24 SATA 3Gb/s Drive Connectors....................................................................... 95
5.2.25 SATA Power Connector.................................................................................. 96
5.2.26 Speaker Connector......................................................................................... 97
5.2.27 Touch panel connector (5-wire resistive type)............................................... 98
5.2.28 Touch panel connector (projected capacitive type)....................................... 99
5.2.29 TPM Connector............................................................................................ 100
5.2.30 Web Camera Connector............................................................................... 101
5.3 JUMPER SETTINGS .................................................................................................. 103
5.3.1 LVDS Voltage Selection.................................................................................. 103
5.3.2 LCD panel selection....................................................................................... 104
6 SYSTEM MAINTENANCE ..................................................................................... 106
6.1 SYSTEM MAINTENANCE INTRODUCTION ................................................................ 107
6.2ANTI-STATIC PRECAUTIONS.................................................................................... 107
6.3 TURN OFF THE POWER............................................................................................ 108
6.4 OPENING THE SYSTEM............................................................................................ 108
6.4.1 Removing the Back Cover.............................................................................. 108
6.4.2 Removing the Internal Aluminum Cover........................................................ 109
6.5 REPLACING COMPONENTS.......................................................................................110
6.5.1 Memory Module Replacement ........................................................................110
6.5.2 WLAN Card Replacement...............................................................................111
6.6 REINSTALLING THE COVERS....................................................................................114
7 BIOS SETUP...............................................................................................................115
7.1 INTRODUCTION........................................................................................................116
7.1.1 Starting Setup..................................................................................................116
7.1.2 Using Setup.....................................................................................................116
7.1.3 Getting Help....................................................................................................117
7.1.4 Unable to Reboot after Configuration Changes.............................................117
7.1.5 BIOS Menu Bar...............................................................................................117
7.2 MAIN.......................................................................................................................118
7.3ADVANCED..............................................................................................................119

AFL2-W21A/AB-H61
Page VIII
7.3.1 ACPI Settings................................................................................................. 120
7.3.2 RTC Wake Settings......................................................................................... 121
7.3.3 Trusted Computing......................................................................................... 122
7.3.4 CPU Configuration........................................................................................ 123
7.3.4.1 CPU Information..................................................................................... 124
7.3.5 SATA Configuration ....................................................................................... 126
7.3.6 Intel TXT (LT) Configuration......................................................................... 127
7.3.7 USB Configuration......................................................................................... 128
7.3.8 F81216 Super IO Configuration.................................................................... 129
7.3.8.1 Serial Port n Configuration..................................................................... 129
7.3.9 H/W Monitor.................................................................................................. 132
7.3.10 Serial Port Console Redirection .................................................................. 136
7.3.10.1 Console Redirection Settings................................................................ 137
7.4 IEI FEATURE ........................................................................................................... 140
7.5 CHIPSET ................................................................................................................. 140
7.5.1 Northbridge Configuration............................................................................ 142
7.5.2 Southbridge Configuration ............................................................................ 142
7.5.3 Integrated Graphics....................................................................................... 145
7.6 BOOT...................................................................................................................... 147
7.7 SECURITY............................................................................................................... 149
7.8 SAVE &EXIT.......................................................................................................... 150
8 SOFTWARE DRIVERS............................................................................................ 152
8.1AVAILABLE SOFTWARE DRIVERS ............................................................................ 153
8.2 STARTING THE DRIVER PROGRAM .......................................................................... 153
8.3 CHIPSET DRIVER INSTALLATION............................................................................. 154
8.4 GRAPHICS DRIVER INSTALLATION.......................................................................... 158
8.5AUDIO DRIVER INSTALLATION ............................................................................... 163
8.6 LAN DRIVER INSTALLATION.................................................................................. 165
8.7 INTEL®MANAGEMENT ENGINE COMPONENTS INSTALLATION............................... 167
8.8 USB 3.0 DRIVER INSTALLATION............................................................................. 170
8.9 WI-FI DRIVER INSTALLATION................................................................................. 173
8.10 LED BAR DRIVER INSTALLATION ........................................................................ 177
8.11AMCAP DRIVER INSTALLATION ........................................................................... 180
9 COOLING MANAGEMENT CONSOLE (ICMC)................................................ 182

AFL2-W21A/AB-H61
Page IX
9.1 OVERVIEW.............................................................................................................. 183
9.1.1 iCMC Installation .......................................................................................... 183
9.2 ICMC OVERVIEW ................................................................................................... 186
9.2.1 Information Panel.......................................................................................... 186
9.2.2 Chart Panel.................................................................................................... 189
ASAFETY PRECAUTIONS....................................................................................... 191
A.1 SAFETY PRECAUTIONS .......................................................................................... 192
A.1.1 General Safety Precautions........................................................................... 192
A.1.2 Anti-static Precautions .................................................................................. 193
A.1.3 Product Disposal........................................................................................... 194
A.2 MAINTENANCE AND CLEANING PRECAUTIONS...................................................... 194
A.2.1 Maintenance and Cleaning............................................................................ 194
A.2.2 Cleaning Tools............................................................................................... 195
B BIOS MENU OPTIONS........................................................................................... 196
C ONE KEY RECOVERY........................................................................................... 199
C.1 ONE KEY RECOVERY INTRODUCTION .................................................................... 200
C.1.1 System Requirement ...................................................................................... 201
C.1.2 Supported Operating System......................................................................... 202
C.2 SETUP PROCEDURE FOR WINDOWS........................................................................ 203
C.2.1 Hardware and BIOS Setup............................................................................ 204
C.2.2 Create Partitions........................................................................................... 204
C.2.3 Install Operating System, Drivers and Applications..................................... 208
C.2.4 Building the Recovery Partition.................................................................... 209
C.2.5 Create Factory Default Image .......................................................................211
C.3AUTO RECOVERY SETUP PROCEDURE.................................................................... 216
C.4 SETUP PROCEDURE FOR LINUX.............................................................................. 220
C.5 RECOVERY TOOL FUNCTIONS ................................................................................ 224
C.5.1 Factory Restore............................................................................................. 225
C.5.2 Backup System............................................................................................... 226
C.5.3 Restore Your Last Backup.............................................................................. 227
C.5.4 Manual .......................................................................................................... 228
C.6 RESTORE SYSTEMS FROM A LINUX SERVER THROUGH LAN.................................. 229
C.6.1 Configure DHCP Server Settings.................................................................. 230

AFL2-W21A/AB-H61
Page X
C.6.2 Configure TFTP Settings............................................................................... 231
C.6.3 Configure One Key Recovery Server Settings............................................... 232
C.6.4 Start the DHCP, TFTP and HTTP................................................................. 233
C.6.5 Create Shared Directory................................................................................ 233
C.6.6 Setup a Client System for Auto Recovery...................................................... 234
C.7 OTHER INFORMATION ............................................................................................ 237
C.7.1 Using AHCI Mode or ALi M5283 / VIA VT6421A Controller ...................... 237
C.7.2 System Memory Requirement........................................................................ 239
D HAZARDOUS MATERIALS DISCLOSURE....................................................... 240
D.1 HAZARDOUS MATERIAL DISCLOSURE TABLE FOR IPB PRODUCTS CERTIFIED AS
ROHS COMPLIANT UNDER 2002/95/EC WITHOUT MERCURY..................................... 241