Kaba Mas X-09 User manual

Disassemble and remove the lock
body from the container or door.
Turn the lock over so the cables
and plastic tube retainer are
visable.
Insert the T-6 Torx Bit, supplied
with the X-09/X-10 Service Tool,
into the tool and remove the
screw holding the tube retainer
on to the lock case.
Carefully remove the tube
retainer.
Note: The Ground Contact will
probably be stuck to the Tube Retainer
with grease, please be aware of this and
make sure it is in place when re-
installing the tube retainer. The cable
plug should now be visable.
Note: The X-10 plastic tube retainer is
shorter and is located in a different spot.
If using an X-10 ribbon cable assembly
kit, make sure to use the plastic tube
retainer that’s on the X-09.
Remove the cable plug and
damaged cables and discard.
Remove the protective cover off
of the contacts of the new cables
and insert them into the lock case
as shown.
Replacing the Ribbon Cable on the X-09/X-10TM
X-09 X-10
X-10 X-09
(1) (2)
(3) (4)

Feed the cables through the slot
in the tube retainer making sure
the cables are nor crimped or
damaged. Make sure the tube
retainer is oriented correctly so
that it will seat ush against the
lock case.
Seat the tube retainer properly,
making sure it’s tab is inserted
into the lock case. Don’t forget to
install the ground contact as well.
Keep the cables pulled
tight as you are seating the
tube retainer so that none of the
excess cable is caught under the
tube retainer as it is being seated
into place.
The cables should look like the
photo when installed properly.
Hold the tube retainer in place,
insert and tighten the screw
holding the tube retainer.
Replacement of Ribbon Cable
Complete.
Re-install the X-09/X-10 lock and check for proper operation.
Please note that Kaba Mas provides a NEW tube retainer, ground contact and screw with all cable
sets. Inspect and replace these parts if worn, damaged or lost.
Call Customer Service at 800-654-0637 to place your order.
Part Number Description
KABA527100 X-10 CABLE ASSEMBLY
800-654-0637 • www.lockmasters.com • fax [phone]