kingsley-bate Ipanema Settee IP55 User manual

Kingsley-Bate
IP55 Ipanema Settee
Assembly Instructions

KINGSLEY–BATE
Fine Garden Furniture
0ASSEMBLY INSTRUCTIONS FOR THE IP–55 / 80
RIGHT END FRAME SEAT FRAME LEFT END FRAME
* NOTE
A TENON
B MORTISE
HOLE
SEAT SCREEN BACK
STEP-I
Unpack, inspect and lay the parts on a clean, flat, soft surface to avoid marring the wood.
NOTE: During assembly of the furniture please match joints with the corresponding letters or
numbers stamped on the wood.
STEP-II
Gently lay the END FRAME w ith the stamps near the
mortise holes on a clean, flat surface and fit the SEAT
FRAME and BACK tenons into the END FRAME
mortise holes. If necessary, ge ntly rock the parts while
pushing down on them until all the joints fit snugly
together. NOTE: END FRAME DOES NOT LAY
FLUSH ON THE GROUND, PLEASE BE CAREFUL
NOT TO FORCE PARTS TO THE POINT OF DAMAGING THE END FRAME. ALSO,
THIS IS A TWO PERSON ASSEMBLY, TH E IP55 AND 80 WILL NOT BALANCE ON
THE END FRAME. ONE PERSON MUST BALANCE BETWEEN STEPS II AND III.
STEP-III
Carefully fit the rem aining END FR AME mortise holes over all exposed
tenons and using a rubber m allet or a regular ham mer with the sanding
block between the ham mer and the wood, gently drive the m ortise holes
onto the tenons until all joints fit snugl y together. Carefully upright the
chair by lifting it up and setting it down, tilting the chair over m ight
damage un-doweled tenons.

STEP-IV
Carefully hammer the proper dowels into the pr e-drilled holes of the assem bly, details are
shown in the photographs and all dowels (and/or dowel bags) are marked to match where they
go.
NOTE: DO NOT FORCE THE DOWELS; ANY EXCESS CAN EASILY BE SANDED
AWAY. IF THE DOWELS ARE NOT FLUSH DO NOT CONTINUE TO DRIVE THE
DOWELS, YOU MIGHT DAMAGE THE ITEM.
STEP-V
Place SEAT SCREENS into SEAT FRAME as shown in the photograph.
1IF YOU HAVE ANY QUESTIONS REGARDING THE ASSEMBLY OF YOUR
KINGSLEY-BATE FURNITURE, PLEASE CONTACT THE KINGSLEY-BATE DEALER
NEAREST TO YOU OR KINGSLEY-BATE DIRECTLY. WE THANK YOU FOR
CHOOSING OUR FURNITURE.
* KINGSLEY-BATE WILL NOT TAKE RESPONSIBILITY FOR DAMAGE
IF THESE INSTRUCTIONS ARE NOT FOLLOWED PROPERLY
7200 Gateway Court, Manassas, Virginia 20109
Phone: [phone], Fax: [phone]