kingsley-bate WS-59 User manual

KINGSLEY~BATE
Fine Garden Furniture
ASSEMBLY INSTRUCTIONS FOR THE WS-59
LEG ASSEMBLY BOTTOM STRETCHER TABLE TOP
NOTE:
A TENON
B MORTISE HOLE
STEP-I
Unpa k, inspe t and lay the parts on a lean, flat, soft surfa e to
avoid marring the wood.
NOTE: During assembly of the furniture please mat h all joints with the orresponding letters
or numbers stamped on the furniture. This is a two person proje t.
STEP-II
With the table top
upside down on a
lean, smooth
surfa e, fit one LEG
ASSEMBLY
mortise holes onto the TABLE TOP tenons as shown in the photographs. If ne essary, gently
ro k the LEG ASSEMBLY while pushing tenons into the mortise holes until joints fit snugly
(use of a rubber mallet may be needed). Again, mat hing the numbers stamped on the tenons
with the mortise holes, fit the BOTTOM STRETCHER as shown in the photograph (please
note there is a top and bottom side to the BOTTOM STRETCHER). While holding
BOTTOM STRETCHER in pla e, fit the se ond LEG ASSEMBLY, as shown in
photographs. If you need to use a rubber mallet to drive the joints together you should have
one person on either side of the table; one to keep the parts from sliding on your smooth
surfa e or shifting left to right, the other to drive the joints.

STEP-III
Carefully hammer the
dowels into the pre-drilled
holes of the assembly and
se ure the s rews with a
proper hand held
s rewdriver to the underside apron of the LEG ASSEMBLIES, details are shown in the
photographs.
NOTE: DO NOT FORCE THE DOWELS; ANY EXCESS CAN EASILY BE SANDED
AWAY. IF THE DOWELS ARE NOT FLUSH DO NOT CONTINUE TO DRIVE THE
DOWELS, YOU MIGHT DAMAGE THE ITEM. USE OF A POWER
SCREWDRIVER IS NOT RECOMMENDED. THE TORQUE OF A POWER
SCREWDRIVER CAN EASILY STRIP THE SCREW HOLE.
NOTE: TO UPRIGHT THE TABLE LIFT STRAIGHT UP, ROTATE IN THE AIR
AND SET IT BACK DOWN. ROLLING THE TABLE OVER MAY CAUSE
DAMAGE TO THE ITEM.
IF YOU HAVE ANY QUESTIONS REGARDING THE ASSEMBLY OF YOUR
KINGSLEY-BATE FURNITURE, PLEASE CONTACT THE KINGSLEY-BATE DEALER
NEAREST TO YOU OR KINGSLEY-BATE DIRECTLY. WE THANK YOU FOR
CHOOSING OUR FURNITURE.
*KINGSLEY-BATE WILL NOT TAKE RESPONSIBILITY FOR DAMAGE
IF THESE INSTRUCTIONS ARE NOT FOLLOWED PROPERLY.
7200 Gateway Court, Manassas, Virginia 20109
Phone: [phone], Fax: [phone]