Kontron CI5TTV Series User manual

CI5TTV Series
Full-Size Pentium PCI CPU Card
Version 1.1B
Industrial CPU Card
PC-Based Computer Boards for Industrial Automation
User’s Manual
StockCheck.com

ii CI5TTV User’s Manual
Copyright Notice
This publication is protected by copyright and all rights are reserved. No
part of it may be reproduced or transmitted by any means or in any form,
without prior consent of the original manufacturer.
The information in this document has been carefully checked and is
believed to be accurate. However, the original manufacturer assumes no
responsibility for any inaccuracies that may appear in this manual. In no
event will the original manufacturer be liable for direct, indirect, special,
exemplary, incidental, incidental or consequential damages resulting
from any defect or omission in this manual, even if advised of possibility
of such damages. The material contained herein is for informational
purposes only.
Acknowledgments
AMD is a registered trademark of Advanced Micro Devices, Inc.
Award is a registered trademark of Award Software International, Inc.
C&T is a trademark of Chips and Technologies, Inc.
Cyrix is a trademark of Cyrix Corporation.
IBM, PC/AT, PS/2 are trademarks of International Business Machines
Corporation.
Intel and Pentium are registered trademarks of Intel Corporation.
Microsoft Windows is a registered trademark of Microsoft Corporation.
SMC is a registered trademark of Standard Microsystems Corporation.
All other product names or trademarks are properties of their respective
owners.
StockCheck.com

Contents
CI5TTV User’s Manual iii
CI5TTV Series Comparison Table
Model CI5TTV CI5TT
Processor Intel Pentium (P54C,
P55C/MMX)
Cyrix 6x86, 6x86L,
6x86MX
AMD K5, K6
Intel Pentium (P54C,
P55C/MMX)
Cyrix 6x86, 6x86L,
6x86MX
AMD K5, K6
Processor Socket ZIF Socket ZIF Socket 7
Chipset Intel 430TX Intel 430TX
Multi I/O Chip SMC 37C669 SMC 37C669
BIOS Award Award
L2 cache 512KB P.B. SRAM 512KB P.B. SRAM
Max. RAM 256MB FPM/EDO 256MB FPM/EDO
Memory Sockets 4 x 72-pin SIMMs 4 x 72-pin SIMMs
VGA CRT/LCD C&T 65550 None
Watchdog Timer 16-level 16-level
PC/104 Connector yes yes
Enhanced IDE yes yes
2S/1P yes yes
USB yes yes
IrDA yes yes
CPU Digital Temperature
Sensor (LM75) yes yes
Board Size 338mm x 124mm 338mm x 124mm
StockCheck.com

Contents
iv CI5TTV User’s Manual
Contents
Chapter 1 Introduction.............................................1
Checklist.....................................................................2
Description.................................................................2
Features......................................................................3
Specifications.............................................................3
Intelligence.................................................................5
Board Dimensions and Layout.................................6
Chapter 2 Installations .............................................7
CPU Installation........................................................8
Memory Installation..................................................9
Jumpers on the CI5TTV.........................................10
Jumper Locations on the CI5TTV......................................11
SW1 (1-4): CPU Voltage Selector .....................................12
JP6, SW3 (1-4):CPU Frequency Selector ..........................13
JP5: Clear CMOS Content .................................................15
J18: External Battery Connector ........................................16
JPW1: LCD Panel Interface Setting...................................16
J7, JPW2/3/4: RS232/422/485 (COM2) Selection.............17
Connectors on the CI5TTV....................................18
Connector Locations on the CI5TTV.................................19
J1: Front Bezel Connector..................................................20
J3, J4: EIDE Connectors ....................................................22
J5: Floppy Drive Connector...............................................23
J6: CPU Fan Power Connector...........................................23
J8: LCD Panel Connector...................................................24
Flat Panel Display Interface Pin Descriptions....................25
J9: Parallel Port Connector.................................................26
J10: COM1 Serial Port.......................................................27
J11: PS/2 Mouse Connector...............................................27
J12: COM2 Serial Port.......................................................27
J13: IrDA Connector..........................................................27
J14: VGA CRT Connector.................................................28
J15: External Keyboard Connector ....................................28
J16: Keyboard Connector...................................................28
J19, J20: USB Connectors..................................................29
P1: Power Connector..........................................................29
StockCheck.com

Contents
CI5TTV User’s Manual v
CON1, CON2: PC-104 Connector.....................................30
Watchdog Timer Configuration ............................31
Chapter 3 BIOS Configuration.............................. 33
BIOS Introduction..............................................................36
BIOS Setup ........................................................................36
Standard CMOS Setup.......................................................38
BIOS Features Setup..........................................................41
Chipset Features Setup.......................................................44
Power Management Setup..................................................47
PNP/PCI Configuration......................................................49
Load BIOS Defaults...........................................................51
Load Setup Defaults...........................................................51
Integrated Peripherals ........................................................52
Supervisor / User Password ...............................................54
IDE HDD Auto Detection..................................................55
HDD Low Level Format....................................................55
Save & Exit Setup..............................................................56
Exit Without Saving...........................................................56
Chapter 4 VGA Driver Installation....................... 58
Installing the Drivers for Windows 3.1.................59
Installing the Drivers for Windows 95..................60
Installing the Drivers for Windows NT 3.5x.........61
Installing the Drivers for Windows NT 4.0...........62
Chapter 5 Intel PIIX Bus Master IDE Driver
Installation................................................................ 64
System Requirements..............................................65
Installing the Software............................................66
Appendix................................................................... 67
A. I/O Port Address Map........................................68
B. Interrupt Request Lines (IRQ).........................69
StockCheck.com

StockCheck.com

Chapter 1 Introduction
CI5TTV User’s Manual 1
1
Introduction
This manual is designed to give you information on the CI5TTV CPU
card. It is divided into the following sections:
Checklist.......................................................................................2
Description ...................................................................................2
Features ........................................................................................3
Specifications ...............................................................................3
Intelligence...................................................................................5
Board Dimensions and Layout .....................................................6
The topics covered in this chapter are as follows:
 Checklist
 Description
 Features
 Specifications
 Layout of Key Components and Dimensions
StockCheck.com

Chapter 1 Introduction
2 CI5TTV User’s Manual
Checklist
Please check that your package is complete and contains the items below.
If you discover damaged or missing items, please contact your dealer.
•
••
•
The CI5TTV Industrial CPU Card
•
••
•
This User’s Manual
•
••
•
1 IDE Ribbon Cable
•
••
•
1 Floppy Ribbon Connector
•
••
•
1 Serial Port Ribbon Cable and 1 Parallel Port Attached to a
Mounting Bracket
•
••
•
1 PS/2 mouse cable
•
••
•
1 Diskette Containing Intel PCI IDE Driver and Flash Memory
Utility
•
••
•
1 Diskette Containing C&T 65550 VGA Driver
Description
The CI5TTV is a PCI Pentium Industrial CPU card based on Intel’s
430TX chipset and is fully designed for harsh industrial environment. It
features ZIF Socket 7 compatible with various processors from Intel,
AMD and Cyrix. This card accommodates up to 256MB of DRAMs in
FPM or EDO configurations and a secondary level 512KB cache.
The CI5TTV comes with onboard CPU temperature sensor to protect
your processor from overheating. The power management feature
provides power savings by slowing down the CPU clock, turning off the
monitor screen and stopping the HDD spindle motor.
StockCheck.com

Chapter 1 Introduction
CI5TTV User’s Manual 3
Features
•
••
•
CPU Speed 90~233MHz, Intel P54C, P55C/MMX, Cyrix 6x86,
6x86L, 6x86MX, AMD K5, K6
•
••
•
Intel 430TX PCIset
•
••
•
Up to 256MB system memory
•
••
•
Onboard VGA CRT/LCD
•
••
•
16 level programmable watchdog timer
•
••
•
High speed bi-directional SPP/ECP/EPP parallel port
•
••
•
PC/104 connector
•
••
•
CPU Temperature monitoring and alert (LM75)
•
••
•
Auto fan off
Specifications
•
••
•
Processor Socket: ZIF Socket 7
•
••
•
Processor:
Intel Pentium/P55C 90/100/120/133/150/166/200/233
Cyrix 6x86/6x86L P150+/P166+
Cyrix 6x86MX-166/180/200
AMD K5 PR90/PR100/PR133/PR166
AMD K6-166/200/233/266/300
AMD K6/2-300/333/366/400
•
••
•
Chipset: Intel 430TX PCIset with built-in PCI EIDE
•
••
•
Secondary Cache: 512KB P.B. SRAM
•
••
•
Memory: Up to 256MB FPM/EDO DRAM
•
••
•
Memory Sockets: Four 72-pin SIMM sockets for DRAMs in
4MB, 8MB, 16MB, 32MB and 64MB configurations.
•
••
•
BIOS: Award BIOS, PnP support
•
••
•
FLASH EEPROM (128KB) for BIOS update
•
••
•
ISA Plug and Play (PnP) extension
•
••
•
Power management
StockCheck.com

Chapter 1 Introduction
4 CI5TTV User’s Manual
•
••
•
Multi I/O: SMC 37C669 chipset
•
••
•
Parallel Port: One high-speed parallel port, SPP/EPP/ECP mode
•
••
•
Serial Port: Two 16550 UART compatible RS232/422/485 ports
•
••
•
Enhanced IDE: Two Bus Mastering EIDE mode, up to 4 devices,
Two EIDE interfaces for up to four devices, support PIO Mode 3/4
or Ultra DMA/33 IDE Hard Disk and ATAPI CD-ROM.
•
••
•
FDD Interface: Two floppy drives (360KB, 720KB, 1.2MB,
1.44MB, 2.88MB, LS-120)
•
••
•
USB Interface: Two USB pin-header connectors, compliant with
USB Specification Rev. 1.0
•
••
•
Watchdog Timer: 16-level, programmable
•
••
•
I/O port 0443H to enable watchdog.
•
••
•
I/O port 0441H to disable watchdog.
•
••
•
Time-out timing select 0/2/4/6/8/10/12/14/16/18/20/22/
24/26/28/30 seconds (+/-20%).
•
••
•
Green Function: Power management via BIOS, activated through
mouse/keyboard movement
•
••
•
Keyboard Connector: PC/AT type mini-DIN and 5-pin external
keyboard connectors
•
••
•
IrDA Interface: Pin-header connector for the optional IrDA
external connector
•
••
•
VGA Display:
•
••
•
C&T 65550 VGA chip on board
•
••
•
SVGA for CRT & Panel
•
••
•
32-bit PCI local bus
•
••
•
VGA BIOS with 128KB flash ROM and system BIOS
•
••
•
15-pin connector
•
••
•
1024x768 (256 colors) resolution on SVGA(1MB memory)
•
••
•
41-pin connector for LCD panel, 640 x 480 resolution
•
••
•
LCD panel supports monochrome, color STN, TFT, EL
•
••
•
Simultaneous VGA and panel display
StockCheck.com