Life Fitness Club Series User manual

CLUBSERIESVERITCAL
DUMBBELLRACK
Part # 7189501
Rev B. Revision:3/01/021
ASSEMBLY INSTRUCTIONS

PARTS LIST
PART #
ACUAP04-0047
ACUAP01-0083
ACUP02-0044
3102922
3102905
KEY
1
2
3
4
5
QTY
1
2
2
4
3
KEY
6
7
8
9
10
OR
PART #
3102807
3102514
6866701
6866601
6866602
6866603
DESCRIPTION
3/8” LOW HEIGHT LOCK NUT
3/8” SAE WASHER
3/8” RH WASHER
BLACK RH CAP
WHITE RH CAP
PLATINUM RH CAP
QTY
7
14
14
6
8
8
DESCRIPTION
FRAME
3 X 2 X 18” TUBE
DUMBBELL CHANNEL
3/8 X 2-3/4” BOLT
3/8 X 3-3/4” BOLT
BOLT LENGTH
Tools Required forAssembly
2
NOTE:BOLTLENGTH IS MEASURED FROMTHEUNDERSIDEOFTHEHEADOFTHEBOLT.
Bolt Length Ruler
0123456
1/2 1/2 1/2 1/2 1/2 1/2
* Rubber mallet or hammer
* 9/16” wrench
* Ratchet with 9/16” socket

3
6
3/8” LOW
HEIGHT LOCK
NUT
7
3/8” SAE
WASHER
10
RH CAP
(BLACK/WHITE/PLATINUM)
8
RH
WASHER
4 3/8 X 2-3/4” BOLT
5 3/8 X 3-3/4” BOLT
9

STEP 1:
FIGURE 1
4
• SECURELY assemble the two 3 X 2 X 18” TUBES (2) to the FRAME (1) using eight RH CAPS (10), four 3/8 X 2-3/4” BOLTS
(4), eight 3/8” SAE WASHERS (7), eight 3/8” RH WASHERS (8) and four 3/8” LOW HEIGHT LOCK NUTS (6) as shown in
FIGURE 1. (IMPORTANT! Note orientation of TUBES.)
0123456
1/2 1/2 1/2 1/2 1/2 1/2
1
7 8
10
6
2
3/8 X 2-3/4” 4

STEP 2:
FIGURE 2
5
• SECURELY assemble two DUMBBELL CHANNELS (3) to the FRAME (1) using six BLACK RH CAPS (9), three 3/8 X 3-3/4”
BOLTS (5), six 3/8” SAE WASHERS (7), six 3/8” RH WASHERS (8) and three 3/8” LOW HEIGHT LOCK NUTS (6) as shown
in FIGURE 2.
3
8
1
6
9
3/8 X 3-3/4” 5
7

Clean:
• Upholstery with mild soap and water.
• Guide rods with a cotton cloth.
• Hand grips with mild soap and water.
• Frame damage can be repaired with touch-up paint can be purchased from your LifeFitness customer service representative at
[phone].
Inspect:
• Cables for wear or damage and proper tension (should not exceed 3/4” deflection.) Pay close attention at bends and attachment
points.
• Hardware should be checked for looseness. Tighten as required.
• Frames should be inspected for wear or damage.
• Hand Grips should be checked for wear or damage
Lubricate:
• Lube the Guide Rods. Apply the lubricant to a cotton cloth, then run the cotton cloth up and down the guide rods as needed. Do not
spray lubricant directly on the Guide Rods.
PREVENTATIVE MAINTENANCE TIPS
There is a risk assumed by individuals who use this type of equipment. To minimize risk, please
follow these rules:
2. Do not allow minors or children to play on or around this equipment.
1. Inspect equipment daily. Tighten all loose connections and replace worn parts immediately.
Failure to do so may result in serious injury.
3. Exercise with care to avoid injury.
4. Consult your physician before beginning any exercise program.
6
Thankyouforpurchasingthe LifeFitness CLUB SERIES PLATETREE. If unsureofproperuseofequip-
ment, call your local LifeFitness distributor or call the LifeFitness customer service department at (800)
351-3737.
CAUTION-PLEASE READ
Action DAILY WEEKLY QUARTERLY BI-ANNUALLY AS NEEDED
CLEAN
Upholstery X
Guide Rods X
Hand Grips X
INSPECT
Visual Overall X
Cables X
Hardware X
Frame X
Hand Grips X
LUBRICATE
Guide Rods X
WARRANTY INFORMATION
10YEARS STRUCTURUALFRAME
3 YEARS PILLOWBLOCKS, PULLEYS,WEIGHTPLATESANDGUIDE RODS
1YEAR CABLES
90 DAYS UPHOLSTERY