Mityvac 04050 User manual

Form822683
SILVERLINE DUAL
CONVERTER
MODEL 04050
JAN - 2004 Page
Section - MV7 - 1A

Page Number - 2 Form 822683
SILVERLINE DUAL CONVERTER
MODEL 04050

Page Number - 3Form 822683
SILVERLINE DUAL CONVERTER
MODEL 04050
DUAL CONVERTERTM INSTALLATION INSTRUCTIONS
1. Make sure the exterior of your pump is cleaned of loose dirt, grease, oil, etc.
2. Remove the old exhaust fitting
a. Retain screws for reuse
3. Remove the old junction
a. Retain screws for reuse
4. Install black exhaust valve in elbow. Install the elbow on the pump. Do not overtighten.
5. Slip the small 0-ring onto elbow. Install the large 0-ring into Dual Converter™ frame. Slide the Dual Converter™
into place on the pump body and elbow. Make sure the elbow is fully seated and the frame is snug against the
body. Install rear screw (on side away from knob) and tighten until just snug. Use one of the screws retained in
step 3.
6. Turn knob to “Vacuum” position. (Note the large square notch on rear side of the black rotary valve is pointing up,
toward elbow.) Remove the screw from knob, then remove the knob from the shaft.
7. Slowly slide the black rotary valve completely out. Install front screw. Use the remaining screw retained in step 3.
Tighten until snug. Snug rear screw again.
8. Make sure that all three 0-rings are in their recesses, and carefully push the rotary valve back into place. * The
large square notch must point up toward the elbow. Replace the knob onto the rotary valve shaft, with the wide
flange pointing toward “Vacuum”. If necessary, wiggle it slightly to fully seat the knob, then replace the screw. Do
not overtighten.
Item Description Part No. Item Description Part No
.
1 Seal Kit 823390 7 Reservoir Jar Kit 06909
2 Handle Kit 823373 8 Tubing (1/4"x24") Kit 822391©
3 Compound Gauge 06170 9 RubberSuction Cup (3 pack) 822392©
4 RotaryValve Kit 823379 10 Vacuum Cap Kit 823357
5 Brake Bleeding Adapter Kit 822303 11 Feeder Cap Kit 823396
6 Auto Adapter Kit 822304 12 Adapter Plate Kit 823398
MODEL 04050 SERVICE PARTS
NOTE: Coat rubber components of pump with silicone oil (not supplied) prior to installing.
© Indicates change

Page Number - 4 Form 822683
SILVERLINE DUAL CONVERTER
MODEL 04050
58
6
7
9
10
12
11

Page Number - 5Form 822683
SILVERLINE DUAL CONVERTER
MODEL 04050
LIMITED WARRANTY-
Lincoln warrants the equipment it supplies to be free from defects in material and workmanship for one (1) year
following the date of purchase. If equipment proves to be defective during this warranty period it will be repaired or
replaced, at Lincoln’s discretion, without charge provided that factory authorized examination indicates the equipment
to be defective. To obtain repair or replacement, you must ship the equipment, transportation charges prepaid, with
proof of date of purchase to a Lincoln authorized warranty and service center, within one (1) year following the date of
purchase.
LIMITED 5 YEAR WARRANTY (Series 20, 25, 40 Bare Pumps, Heavy Duty and Golden Standard Bare Reels)-
Lincoln warrants series 20, 25, 40 bare pumps, and heavy duty and golden standard bare reels it supplies to be free
from defects in material and workmanship for one (1) year following the date of purchase. If equipment proves to be
defective during the warranty period it will be repaired, or replaced, at Lincoln’s discretion, without charge provided
that factory authorized examination indicates the equipment to be defective. To obtain repair or replacement, you
must ship the equipment, transportation charges prepaid, with proof of purchase to a Lincoln Authorized Warranty
and Service Center within one (1) year following the date of purchase. Additionally, in years two (2) and three (3) the
warranty on this equipment is limited to repair with Lincoln paying parts and labor only. In years four (4) and five (5),
the warranty on this equipment is limited to repair with Lincoln paying for parts only.
This warranty is extended to the original retail purchaser only. It does not apply to equipment damaged from acci-
dent, overload, abuse, misuse, negligence, faulty installation or abrasive or corrosive material, or to equipment
repaired or altered by anyone not authorized by Lincoln to repair or alter the equipment. This warranty applies only to
equipment installed and operated according to the recommendations of Lincoln or its authorized field personnel. No
other express warranty applies.
Any implied warranties applicable to equipment supplied by Lincoln, including the warranties of merchantability and
fitness for a particular purpose, will last for only one (1) year from the date of purchase. Some jurisdictions do not
allow limitations on how long an implied warranty lasts, so the above limitation may not apply to you.
In no event shall Lincoln be liable for incidental or consequential damages. Lincoln’s liability on any claim for loss or
damages arising out of the sale, resale or use of equipment it supplies shall in no event exceed the purchase price.
Some jurisdictions do not allow the exclusion or limitation of incidental or consequential damages, so the above
limitation or exclusion may not apply to you.
This warranty gives you specific legal rights. You may also have other rights that vary by jurisdiction.

Page Number - 6 Form 822683
SILVERLINE DUAL CONVERTER
MODEL 04050
Americas:
One Lincoln Way
St. Louis, MO 63120-1578
USA
Phone [phone]
Fax [phone]
Europe/Africa:
Heinrich-Hertz-Str 2-8
D-69183 Walldorf
Germany
Phone [phone]
Fax [phone]
Asia/Pacific:
25 Int’l Business Park
#01-65 German Centre
Singapore 609916
Phone [phone]
Fax [phone]
© Copyright 2003
Printed in USA
Web site:
www.mityvac.com