NORDIC SEASON KEY WEST GG201973 User manual

1
GG201973
KEY WEST
4+1
EN
READ THE OPERATING INSTRUCTIONS
BEFORE USING THE APPLIANCE.
FOR OUTDOOR USE ONLY.
!
ASSEMBLY,
USE AND INSTRUCTION MANUAL

2
Contents
Warnings.................................................................... 3
Technical data ............................................................4
Gas category ...............................................................4
Exploded drawing ....................................................... 5
Parts list ................................................................... 6
Hardware ...................................................................7
Assembly instructions ...................................................8
Gas leak test ............................................................ 18
Connecting gas ...........................................................19
Lighting instructions ...................................................20
Before using the grill................................................... 22
Warnings ..................................................................23
Maintenance .............................................................24
Troubleshooting ........................................................25
Consumer Contact .....................................................26

3
WARNINGS
!Failure to follow the instructions provided can imply a risk of
serious injury to personnel and xed installations.
!Some grill parts can be sharp, we recommend wearing gloves
when assembling and lifting. Sharp edges can cause injury.
!The grill is intended for outdoor use only in well-ventilated areas.
Never grill in enclosed spaces or under a roof, due to the danger of the
lack of oxygen.
!Accessible parts of the grill become very hot during use.
Keep children and others who need supervision at a safe distance.
!Do not move the grill while in use or connected to the gas bottle.
Shut off the gas on the regulator after use and disconnect from the
gas bottle.
! Modication of the grill can cause danger and will invalidate
the warranty.
!Never keep the gas bottle under the grill when in use. Gas leaks
can cause serious damage. Place the gas bottle by the side of the grill
during use.
! Do not place the grill cover or other ammable material in the
compartment under the grill when it is in use or hot.
!Do not use lava stones, charcoal or briquettes.
!Clean the grill regularly and thoroughly.
!

4
Technical data — Key West 4+1
Gas information 0359-18
FOR USE IN
COUNTRIES VALVE SIZE GAS TYPE GAS CATEGORY
BE, CH, CY, CZ,
ES, FR, GB, GR,
IE, IT, LT, LU LV, PT,
SK, SI 0.9 mm Butan (28~30) mbar
Propan 37 mbar I3+(28-30/37)
BE, CY, CZ, DK,
EE, FI, FR, HU, IT,
LT, NL, NO, SE, SI,
SK, RO, HR, TR,
BG, IS, LU, MT
0.9 mm G30(butan),G31(propan) and mixture of these,
LPG 28~30 mbar I3B/P(30)
PL 0.86 mm G30(butan), G31(propan) and mixture of these,
LPG 37mbar I3B/P(37)
AT, CH, DE, SK 0.81 mm G30 (butan),G31(propan) and mixture of these,
LPG 50mbar I3B/P(50)
Total effect: 17 kW
(main burner heat input 14 kW (1020 g/h,
side burner heat input: 3 kW (218g/h)
Total gas consumption: 1235 g/h.
Hose and regulator (not included):
Must be approved according to
EN standard.
Gas bottle (not included): Use standard
bottle approved for use in the Nordic
Region, 10/11 kg recommended. Even
though butane and propane gas can be
used, we recommend propane for use in
the Nordic Region. Approved hoses and
regulators are available from most outlets
selling gas equipment.
NB!
Gas hoses used for this product must
not exceed 120 cm in length.
This product is produced according to EUROPEAN GAS APPLIANCE
STANDARD EN498 AND EN484 and is CE certied.

5
Exploded drawing

6
Parts list
seq. NO appellation qty
1 Lid󵽱assembly󵽱 1
2 Thermometer󵽱 1
3 Lid󵽱handle󵽱1
4 Cushion󵽱rubber󵽱4
5 Warming󵽱rack󵽱 1
6 Insert󵽱system󵽱basic󵽱grill󵽱 2
7 Cast󵽱iron󵽱grill󵽱240mm 1
8 Heat󵽱distribution󵽱panel󵽱 4
9 Clip󵽱to󵽱the󵽱tube󵽱burner󵽱 4
10 Tube󵽱burner󵽱 4
11 Grease󵽱cup󵽱holder󵽱 1
12 Grease󵽱cup󵽱 1
13 Grease󵽱tray󵽱 1
14 Side󵽱burner󵽱cooking󵽱grid󵽱 1
15 Side󵽱burner󵽱assembly󵽱1
16 Cart󵽱Left󵽱side󵽱panel󵽱1
17 Door󵽱magnet󵽱 2
18 Cart󵽱front󵽱beam󵽱 1
19 Cart󵽱rear󵽱panel󵽱 1
20 Cart󵽱bottom󵽱panel󵽱 1
21 Cart󵽱right󵽱side󵽱panel󵽱 1
22 Bottom󵽱panel󵽱decoration󵽱strip󵽱 1
23 Cart󵽱triangular󵽱support󵽱bracket󵽱 2
24 Lockable󵽱caster󵽱 4
25 Door󵽱2
26 Gas󵽱connection󵽱nozzle󵽱1
27 Main󵽱burner󵽱control󵽱knob󵽱 4
28 Side󵽱burner󵽱control󵽱knob󵽱 1
29 Control󵽱panel󵽱assembly󵽱 1
30 Firebox󵽱assembly󵽱1
31 Side󵽱table󵽱 1
32 Insert󵽱system󵽱round󵽱grill󵽱 1
2

7
Hardware
The following screws and nuts are supplied with the grill and must be tted.
TOOLS FOR ASSEMBLING (NOT INCLUDED)
0102030405060708090 100 110 120 130 140 150
0123456
0102030405060708090 100 110 120 130 140 150
0123456
Medium size at blade or
Philips/cross-point screwdriver Adjustable spanner or metric spanner set Ruler
01 02 03 04 05 06 07 08 09 0 100 110 120 130 140 150
01 23 45 6
WARNING!
Exercise caution when using electric tools –
their strength can damage the screws.

8
Assembly instructions
Please follow these instructions step by step.
We recommend two people to assemble the
grill to avoid heavy lifting.
1
2

9
3
4xB

10
4

11
5
6
6
4xA

12
7
8
4xE

13
9
10
2xB
2xD

14
11
12 2xB
2xD

15
13
14
1xA
2XC

16
15
16
2xA

17
17
18
ASSEMBLY IS NOW COMPLETE.
ALL JOINTS AND CONNECTIONS
MUST NOW BE LEAK TESTED
BEFORE USING THE GRILL.
READ CAREFULLY CHAPTER ON
LEAK TESTINING.

18
8If there are still gas leaks after repeated attempts, contact your dealer.
7IF BUBBLES APPEAR, SWITCH OFF THE GAS SUPPLY AND REPAIR THE PROBLEM. PERFORM A NEW LEAK TEST. DO NOT USE THE GRILL BEFORE YOU
ARE SURE THAT THERE ARE NO LEAKS.
6Open the gas tap on the regulator and carefully check for bubbles
appearing anywherethe liquid has been applied.
1Make a mixed solution
(½ water and ½ liquid detergent / soap).
2Ensure that there are no naked ames,
heat sources and cigarettes in the vicinity
when performing a leak test.
3Check that all controls on the grill are in
the ”OFF” position.
4Set the regulator to the ”OFF” position and connect it
to the gas bottle.
5Apply the liquid to all joints and connections on the gas bottle,
regulator, the entire hose and all valves on the grill.
ALL JOINTS AND CONNECTIONS MUST NOW BE
LEAK TESTED BEFORE USING THE GRILL.
Leak test annually, and whenever the gas bottle is removed or replaced.
Always perform a leak test in a well-ventilated area.
!WARNING!
NEVER USE AN OPEN
FLAME TO PERFORM
A GAS LEAK TEST
IMPORTANT! GAS LEAK TEST
!

19
ALWAYS perform a gas leak test before using the grill.
Connect the gas hose to the gas
rail inlet on the left hand side of the
barbecue. Do not overtighten.
Do not use any sealing tape, paste
or liquid on the connection.
Connect the regulator to the gas
bottle according to your regulator
and bottle dealer’s instructions.
Gas hoses used for this product
must not exceed 120 cm in length
 Conrm all barbecue control knobs
are in the OFF position.
 We recommend propane gas for
use in the Nordic Region, but butane
can also be used.Butane is not very
suitable for low temperatures.
 Fit the regulator and the hose.
Follow the assembly instructions
supplied with the regulator set.
Check the gas hose regularly
for cracks, damage and de-
cay. Never use a damaged gas
hose.
Check that the movable
plastic collar on the regulator
is intact and that it has not
been damaged by hot grill
parts.
Check that the gas bottle
stands on a rm, at surface
and is lower than the
connector.
Use an approved gas
bottle that ts the regulator
supplied. Bottles of 10/11 kg
or above are recommended.
I3B/P(30): G30(Butane), G31(propane)
and mixture of these, LPG 28-30 mbar
The following gas types can be used
Hose Gas bottle
Regulator
Connecting the gas
WARNING
!Never store the gas bottle
under the grill when in use. If the
gas bottle is being stored under the
grill when not in use, disconnect
the regulator.
!Never move the grill while
it is in use, or connected
to the gas bottle.

20
Lighting instructions Key West 4+1
MANUELL-MANUAL IGNITION
If the grill will not light using the
normal lighter, use the following
procedure for manual lighting.
Use a long match or lighter.
1. Follow step 1 and 2
(Lighting instruction).
2. Lift up the grate and place a
grillighter or a lit match close to
one burner.
3. Push and turn any knob anti-
clockwise to the high position,
taking care to protect yourself
from the ames.
4. When the burner is lit, light
the remaining burners. Conrm
that each burner is alight before
turning on the next burner.
5. If a burner fails to ignite,
contact your local dealer for
assistance.
6. Follow step 6.
WARNING: If the burner still does not light, turn the burner control knob to OFF and
wait 5 minutes to let the gas clear before lighting again.
1The lid must be open when lighting the burner. Do not
stand with your face directly over the gas grill when
lighting it. Your gas grill will have following method of
ignition: PILOT GAS CONTROL IGNITION:
2With all gas controls on the gas grill in the “OFF”
position, turn the gas cylinder valve to the ON position
at the regulator.
3To create a spark you must push the control knob in
(A) and hold in this position for 3-5 seconds to allow
gas ow and then turn anticlockwise to” HIGH” (B). It can
spark to the burner lighting tube (C). You will hear a “snap”
from the igniter and you will also see a 3”-5” orange ame
coming from the burner lighting tube at the left side of the
burner (D). Continue to hold the burner control knob in
for two seconds after the “snap”, this will allow gas to ow
completely down the burner tube (E) and insure ignition.
4When the burner is alight, adjacent burners will cross
light when their controls are turned to “HIGH”. At
“High” setting the burner ame should be approximately
12-20mm long with a minimum of orange ame. Turn the
gas control fully anticlockwise for minimum setting.
5Should you have any difculty lighting your gas grill
following the above steps, contact your dealer for
advice.
6
After completion of preheating, turn all burners to the
low position for best cooking results.
!