NORDIC SEASON Summer BBQ GG291715 User manual

3 BURNER
GAS BBQ
INSTRUCTIONS AND USE
ENGLISH
Read these instructions for use carefully
to familiarize yourself with the appliance
before connecting it to a gas cartridge.
Keep these instructions for future reference.
OUTDOOR USE ONLY!
Model GG291715

Drip Tray
●If you do not follow the instructions in this guide, you risk serious
injury or damage.
●The grill must only be used in well ventilated areas.
●Accessible parts of the grill get very hot when you use it. Keep
children and others who need supervision at a safe distance.
●Do not move the grill while you use it!
●Disconnect the gas cartridge after use.
●Faults caused by incorrect use, lack of maintenance or
modications made to the grill will invalidate the warranty.
●Check that the seals between the valve and the gas
cartridge is in place and that they are in good condition
before connecting the gas cartridge
●Do not use the grill if the seals are damaged or destroyed.
●The grill should be on a at, stable surface when using it.
●Keep the grill away from combustible surfaces and materials.
The safety distance must be at least 40 cm.
●Do not change the gas cartridge near an open ame.
●When you do not use the grill, keep it dust-free in your bag or
in another dust-free container.
WARNINGS!
Gas Category Information
Injector Type of Gas Gas Category Gas
Consumption Heat Input
Diameter 0,6mm
Butane
Standard gas
casette cartridge
220g
Vapor Pressure-
Butane 175g/h 2,4kW
03503599
For use in all applicable EU Countries.
This appliance should only be used with
220g butane gas cartridge which complies to EN417.
2

Cooking Griddle
Drip Tray
Burner
Gas Cartridge Lock
Control Knob
Cooking Grill
Flame Tamer
Gas Cartridge
Housing Cover
PARTS OVERVIEW
3

IMPORTANT!
Do not use for purposes other than cooking. It
may cause a re hazard to use the appliance
for drying clothes, burning waste, etc.
Do not allow the food to boil over. If boil over
occur when cooking, turn o󰀨 the grill and
clean with kitchen cleanser and dry close.
Do not use two grills side by side or
oversize cooking utensils (pots, pans,
griddles, etc). This may cause overheating
or exploding.
Select a well safe place before lighting
the appliance. Keep it safely away from
any ammable items, and at least 40cm
from walls /100cm from ceilings.
When use of the cooking grill When use of the cooking griddle
This appliance should be used in a well-
ventilated place and protected for gusty
wind. Otherwise, ames may be scattered or
extinguished.
Be sure to t the gas cartridge
correctly by aligning the slot with keyway.
This will avoid a gas leak.
Ensure that the grill and griddle are in position before use!
1 2
Cooking grill
Cooking
griddle
Four supports should
be placed underside
cooking grill.
Four supports
should be placed
stably with foor
supports above
cooking grill.
Support
4

CORRECT USE
Ensure the cooking grill and cooking
griddle are in position, and open the
gas cartridge housing cover.
Push the gas cartridge lock down.
Turn the control knob anti-clockwise
until a click is heard and burner is lit.
When nish cooking, turn the control
knob clockwise to OFF position to
extinguish the ame.
Install the gas cartridge by aligning
the slot and keyway.
Close the gas cartridge housing cover.
Place the cooking grill and cooking
griddle in position, and turn the
control knob to adjust ame, turn left
to increase heat, turn right to
decrease heat.
Pull up the gas cartridge lock until
the gas cartridge is not locked. Take
out the gas cartridge and store in a
safe and suitable place.
1
3
5
7
2
4
6
8
5

INSTALLING GAS CARTRIDGE
The Seal s
When nish cooking, turn the control knob clockwise to
OFF position to extinguish the ame.
Check that seals are in place before connecting to the
gas cartridge. Open the gas cartridge housing cover, put
the gas cartridge in position. Make sure the gas outlet
of cartridge ts into the gas inlet of valve inside the
barbecue.
Push down the gas cartridge lock to Lock position before
lighting the barbecue. If a hissing is heard or a gas odor
is smelled, please check that if the gas cartridge is tted
correctly. Repeat the step 2 to stop gas leak.
1
3
2
The grill is powered by a 220gram CASSETTE GAS container.
This is a standard gas container and comes from several brands.
We recommend Nordic Season 220 gram butane gas cartridge.
L
H
OFF
UNLOC KLOCK
L
H
OFF
UNLOCK
LOCK
6

LEAK TEST
Testing Position Testing Position
Testing
Position
Always perform a leak test in a well-ventilated area. Always wipe the mixed solution
(½ water and ½ liquid detergent / soap) from all connection after leak test.
1. Conrm control knob is in the OFF position.
2. Install the gas cartridge in position.
3. Push the gas cartridge lock down. Turn on the gas.
4. Check for leaks by brushing a solution of ½ water and ½ liquid detergent / soap over all the gas
system joints, including all valve connections, hose connections.
5. NEVER USE AN OPEN FLAME to test for leaks at any time.
6. If bubbles form over any of the joints there is a leak.
• Turn o󰀨 the gas supply
• Re-tighten all joints
• Repeat test
If bubbles form again do not use the barbecue and contact your local Nordic Season™ distributor for
assistance.
1. The gas cartridge should be placed safely away from any source of
heat or ignition, and never under direct sunlight. Store cartridge in a
cool and dry place where the temperature is less than 40°C.
2. Store cartridge in a secure place.
3. Do not subject the cartridge to impact or rough shake.
4. Do not puncture or incinerate empty cartridge.
5. Do not place cartridge in boot of a car or any unventilated location.
CAUTION Gas Cartridge
Placement of grill
●Make sure that the grill has at least 40 cm distance in all directions from
house walls, trees, plants and other ammable materials / liquids.
●The grill should not be placed under a roof or developer.
●Make sure the grill is located in an area with good ventilation.
7

OPERATION INSTRUCTIONS
1. Turn the control knob anti-clockwise to IGNITE position until a click is
heard.
2. If the burner fails to ignite, turn the control knob back to OFF position,
and repeat the above step.
1. The control knob can be positioned anywhere between and , as
desire. Adjust it to suitable position for best cooking result
2. Always turn the control knob slowly from to , this can avoid ame
extinguishing.
1. Turn the control knob to OFF position. Make sure that the ame is
completely extinguished.
2. Turn the gas cartridge lock to UNLOCK
position, take out the gas cartridge.
Lighting the barbecue
Heat control
Extinguishing
Manual lighting of the grill.
If the grill does not ignite using normal ignition, use the following procedure for manual ignition.
●Use a long match holder or ligther.
●Place the match / ligtheren close to the burner.
●Never lean over the grill.
●Turn the switch to the full position.
If the grill does not ignite at normal ignition or manual ignition, check if there is gas in the tank or
contact your dealer.
NOTE!
The ames should be blue and stable. For large yellowish ame,
are or ”noisy” ame, check the troubleshooting manual.
L
H
L
H
L
H
OFF
OFF
OFF
OFF
UNLOCK
LOCK
L
H
8

CAUTION
Tip.
1. Clean the grill after use.
2. Brush the cooking grates with an oil that can withstand high temperatures. This
prevents the food to burn onto the grates.
3. Do not grill frozen or semi-thawed food. The cold will extend grilling time and result
in a poorer outcome.
4. Consider the preparation time for each product to be grilled and put on in order to
make sure the food will be ready at the same time.
5. Brush the food regularly during cooking with oil or marinade. This means that food
stays juicier.
Safe use of the grill.
1. Always supervise the grill when in use. Make sure that children and others in need
of supervision is not near the grill when in use.
2. This grill is intended for outdoor use. The grill must not be used in places that
are below normal ground level. The gas can then accumulate and pose a risk of
explosion.
3. This grill is designed for use with butane gas, DO NOT use lava rocks, briquettes,
charcoal, Lay two agents etc in this grill.
4. Perform regular leak test and always when replacing the gas tank or after
prolonged storage.
5. UNLOCK the gas cartridge when grill is not in use and before the grill is to be
moved.
6. If the grill is stored in the garage or basement below ground level the gas cartridge
shall not be stored in the same place. Gas cartridge must always be stored above
normal ground level.
7. This grill is not intended for commercial use.
Lack of maintenance can lead to residues of old grease which can catch
re and start a grease re. When grease re occurs, turn o󰀨 the gas
supply and wait until the re goes out by itself.
NB! NEVER USE WATER TO EXTINGUISH A GREASE FIRE!
Clean the grill regularly to avoid grease re.
GREASE FIRE!
9

TROUBLESHOOTING
Issue Possible Cause Solution
Burner will not light using the
igniter.
The electrode is soiled with
grease or food particles. Clean the electrode.
Electrode is damaged. Use manual ignition.
Burner will not light with
manual ignition. Out of gas. Check the gas casette and
replace if empty.
Yellow / orange ame and
gas smell Windy. Protect the grill from wind.
Inaming
Fat from food has caught
re.
Close the gas supply and
wait until it is extinguished.
Ensure good cleaning.
Grilling with high
temperature. Adjust the heat.
Drip tray is full. Empty the drip tray.
The grill goes out
Windy. Place the grill on a less
windy place.
Empty gas cassette. Try a di󰀨erent container.
Grease re Much fat in food grilled. Close gas, wait for the
ames to burn out.
10

MAINTENANCE & CLEANING
Caution!
1. Make sure that the gas cartridge is empty before cleaning.
2. Never remove safety devices and gas components.
Cleaning
1. Body: Wipe o󰀨 with a clean cloth. If necessary, use a kitchen cleanser and
nish with a dry cloth.
2. Drip Tray: After cleaning, wipe with a dry cloth.
3. Burner: Clean the burner with a hard brush, ensure that all food residue are
removed from the burner
1. Pressure-sensitive Safety Device: The gas cartridge will be ejected
automatically, when the pressure in gas cartridge become unusually high.
2. Gas Leak Prevention System: If the control knob is not on vertical (OFF)
position, the gas cartridge lock can not be operated.
3. Prevention System for Incorrect Placement of Gas Cartridge: If the gas
cartridge is not aligned with the keyway in position, the appliance can not be
operated.
4. NEVER attempt to modify the grill or try to t other types of gas cartridges..
FOR YOUR SAFETY
11

This product is covered by a warranty in accordance
with consumer legislation. It has undergone strict quality
controls and testing at the factory.
If there are any parts missing or the product has been
damaged, please contact your dealer or the consumer
contact below for help.
Faults due to misuse, lack of maintenance or modication
of the product will invalidate the warranty.
Damaged parts not due to a fault with the product will
be invoiced according to our price list + carriage and
administration fee.
If new parts are needed or in the event of a warranty
claim, please contact your dealer or consumer contact:
Nordic Season Products AS
Kjeller Vest 3, 2007 Kjeller, Norway
031 189095
[phone]
[email protected]
www.nordicseason.no
Always attach your receipt when making a warranty claim.
We are always looking for ways we can improve our products.
Therefore, we reserve the right to change technical specications at any time.
You will always nd the latest manual on www.nordicseason.no.
Consumer Contact: