PAC RP5-GM11 User manual

RP5-GM11
Radio Replacement & Steering Wheel Control Interface
with OnStar Retention for General Motors Vehicles
3DFL¿F$FFHVVRU\&RUSRUDWLRQ®| Ph. 866-931-8021 | [email protected]
3DFL¿F$FFHVVRU\&RUSRUDWLRQ
www.pac-audio.com
Rev. 022516
P ifi ACti
Introduction & Features
Important Notes
Wiring Connection Chart
Illustration / Schematic
The RP5-GM11 interface allows the replacement of a factory radio in select General Motors vehicles with Class II radios.
Using this interface will retain factory features such as OnStar, steering wheel controls (SWC), warning chimes, Rear
6HDW&RQWUROV56&5HDU6HDW(QWHUWDLQPHQW56(DQGWKH%26(DPSOL¿HUZKHQWKHRULJLQDOUDGLRLVUHPRYHG7KH
RP5-GM11 also provides data bus driven outputs such as retained accessory power (RAP), vehicle speed sensor (VSS),
illumination, reverse trigger and parking brake.
1.7KHUDGLRVHOHFWURWDU\VZLWFK RQWKHVLGH RIWKHLQWHUIDFH PXVWEHDGMXVWHG WR WKHSURSHUUDGLR VHWWLQJEHIRUHSOXJJLQJ WKH
interface into the vehicle (see next page for setting chart).
2.7KHLQWHUIDFHFRPHVSUHSURJUDPPHGIRUDOORIWKHYHKLFOHVIDFWRU\6:&IXQFWLRQVDQGGRHVQRWUHTXLUHSURJUDPPLQJXQOHVV
\RXZLVKWRUHDVVLJQWKH6:&IXQFWLRQVWRGLIIHUHQWEXWWRQV7KH6:&FDQDOZD\VEHUHVWRUHGWRGHIDXOWVHWWLQJVE\SUHVVLQJ
DQGUHOHDVLQJWKHSURJUDPEXWWRQRQWKHVLGHRIWKHLQWHUIDFHRQFHDQGZDLWLQJVHFRQGVIRUWKH/('WRÀDVKWLPHVPLEASE
127('XHWRWKHPDQ\GLIIHUHQWSRVVLEOH2(06:&FRQ¿JXUDWLRQVVRPHDSSOLFDWLRQVPD\QHHGWREHUHSURJUDPPHG
for the SWC assignments to make sense. Whatever you assign as aftermarket volume commands will also be the
OnStar volume commands.
3.7KHDIWHUPDUNHWUDGLRPXVWKDYHDQDX[LOLDU\LQSXWLQRUGHUIRUWKHIDFWRU\56(DXGLRWREHUHWDLQHGWKURXJKWKHFDELQVSHDNHUV
4.56&EXWWRQVWKDWDUHLGHQWLFDOWRWKH6:&ZLOOPLPLFWKH6:&RQHIRURQH
5.7KH/('ZLOOÀDVKZKHQHYHUD6:&EXWWRQLVSUHVVHG
/LJKW*UHHQ Parking Brake
Output (-)
Pink Vehicle Speed
Output
Blue Not Used
Blue / White $PS7XUQ2Q,QSXW
Orange / White Illumination Output
(+)
Purple/White Reverse Output (+)
%URZQ/RRS 0XWH/RRS6HH
installation note 6.
Aftermarket Radio Connections
Yellow %DWWHU\Y
Black Ground
Red $FFHVVRU\2XWSXW
White )URQW/LQSXW
White / Black )URQW/LQSXW
*UH\ Front R + input
*UH\%ODFN Front R - input
Green 5HDU/LQSXW
Green / Black 5HDU/LQSXW
Purple Rear R + input
Purple / Black Rear R - input
SWC Connector
Blue/Yellow Kenwood, Newer
JVC
3.5mm Jack $OSLQH-9&
Clarion, Pioneer,
6RQ\)XVLRQ%R\R
'XDO/LJKWQLQJ
$XGLR9LVWHRQRU
$GYHQW
SWC Connection
See above chart for
different radio type
connections
Wiring SWC Connection
Page 1
Aftermarket
Radio
Connections
Vehicle
Connections

RP5-GM11
Radio Replacement & Steering Wheel Control Interface
with OnStar Retention for General Motors Vehicles
3DFL¿F$FFHVVRU\&RUSRUDWLRQ®| Ph. 866-931-8021 | [email protected]
3DFL¿F$FFHVVRU\&RUSRUDWLRQ
www.pac-audio.com
P ifi A C ti
Rev. 022516
Installation Steps
1. The radio select rotary switch on the side of the interface must be adjusted to the proper radio
setting before plugging the interface into the vehicle.
2. 0DNHDOOFRQQHFWLRQVDVGHVFULEHGLQWKHFKDUWRQSDJH
3. )DFWRU\LQVWDOOHGDPSOL¿HUVZLOOGHWHUPLQHWKHDXGLRRXWSXWFRQQHFWLRQ,IWKHYHKLFOHKDVDIDFWRU\LQVWDOOHGDPSOL¿HUXVHWKH
IDFWRU\DPSOL¿HUDXGLRORFDWLRQ,IDIDFWRU\LQVWDOOHGDPSOL¿HULVQRWSUHVHQWXVHWKHQRQDPSOL¿HGIDFWRU\DXGLRORFDWLRQ
4. ,I WKH DIWHUPDUNHW UDGLR LV HTXLSSHG ZLWK DQ DX[LOLDU\ LQSXW DQG \RX ZLVK WR UHWDLQ WKH IDFWRU\ 56( DXGLR SOXJ WKH 5&$
FRQQHFWRUVIURPWKHVHFRQGDU\KDUQHVVLQWRWKHUDGLRVDX[LOLDU\LQSXW
5. 3OXJWKH&0;FKLPHPRGXOHLQLIQHFHVVDU\,IWKHYHKLFOHFKLPHVZKHQWKHUDGLRLVUHPRYHGWKH&0;LVQRWQHFHVVDU\
PLEASE NOTE:,QRUGHUWRJHWWKHEHVWSRVVLEOHVRXQGRXWRIWKH&0;SOHDVHPRXQWLWLQDSODFHIUHHDQGFOHDURIDQ\
REVWUXFWLRQVSUHIHUDEO\DVFORVHDVSRVVLEOHWRWKHERWWRPRIWKHGDVKSRLQWLQJGRZQWRZDUGWKHÀRRURIWKHYHKLFOH
6. 7KH0XWHORRSLIQRWFXWZLOOWXUQWKHDFFHVVRU\RXWSXWRIIZKHQDQ2Q6WDURU%OXHWRRWKFDOOLVPDGHRUUHFHLYHG,IWKH
DIWHUPDUNHWUDGLRKDVDPXWHLQSXWFXWWKLVORRSDQGFRQQHFWWKHRXWHUEURZQZLUHWRWKHPXWHLQSXW
 Connect the SWC wire according to the chart on page 1 (aftermarket radio MUST support a wired remote input).
8. ,I\RXZLVKWRUHDVVLJQIXQFWLRQVWRWKH6:&IROORZWKHprogramming instructions on the next page.
IMPORTANT! 7KHLQWHUIDFHFRPHVSUHSURJUDPPHGIRUWKHIXQFWLRQVOLVWHGLQWKHFKDUWEHORZDQGGRHVQRWUHTXLUHSURJUDPPLQJ
XQOHVV\RX ZLVKWRUHDVVLJQ WKH6:& IXQFWLRQVWRGLIIHUHQWEXWWRQV7KH6:& FDQDOZD\V EHUHVWRUHGWR GHIDXOWVHWWLQJVE\
SUHVVLQJWKHSURJUDPEXWWRQRQWKHVLGHRIWKHLQWHUIDFHRQFHDQGZDLWLQJVHYHQVHFRQGVIRUWKH/('WRÀDVKWKUHHWLPHV
Alpine JVC Kenwood Clarion Pionee
r
Sony Fusion
Volume + Volume + Volume + Volume + Volume + Volume + Volume + Volume +
Volume - Volume - Volume - Volume - Volume - Volume - Volume - Volume -
Source Up Source Source Disc/FM+ Source Source Source Source
Source Down Band Preset + Disc/AM N/P Band Band Off
Seek Up Track + Track + Track + Search + Track + Track + Track +
Seek Down Track - Track - Track - Search - Track - Track - Track -
Voice Mute Mute Mute Mute Mute Mute Mute
Prog Preset Up Preset - Source Band Preset + Preset + Audio
'HIDXOW6WHHULQJ:KHHO&RQWURO3URJUDPPLQJ
Default SWC Button Assignments
Page 2
Alpine JVC Kenwood Clarion Pionee
r
Sony Fusion
V
olume + Volume + Volume + Volume + Volume + Volume + Volume + Volume +
V
olume - Volume - Volume - Volume - Volume - Volume - Volume - Volume -
Seek Up Track + Track + Track + Search + Track + Track + Track +
Seek Down Track - Track - Track - Search - Track - Track - Track -
V
oice Mute Mute Mute Mute Mute Mute Mute
End Source Source Source Source Source Source Source
Default SWC Button Assignments (Corvette)
1
2
3
4
5
6
7
8
9
0
$OSLQH JVC Kenwood Clarion Pioneer/Other 6RQ\ Fusion
1234 89
Other = $GYHQW%2<2'XDO/LJKWQLQJ$XGLR5RFNIRUG)RVJDWH9LVWHRQ
SET RADIO SELECT SWITCH

RP5-GM11
Radio Replacement & Steering Wheel Control Interface
with OnStar Retention for General Motors Vehicles
3DFL¿F$FFHVVRU\&RUSRUDWLRQ®| Ph. 866-931-8021 | [email protected]
3DFL¿F$FFHVVRU\&RUSRUDWLRQ
www.pac-audio.com
Rev. 022516
P ifi A C ti
Optional Steering Wheel Control Programming
Alpine JVC Kenwood Clarion Other* Pioneer Sony Fusion
1 Volume + Volume + Volume + Volume + Volume + Volume + Volume + Volume +
2 Volume - Volume - Volume - Volume - Volume - Volume - Volume - Volume -
3 Mute Mute Mute Mute Mute Mute Mute Mute
4 Preset + Source Source Source Preset + Preset + Preset + Source
5 Preset - Track + Play Search + Preset - Preset - Preset - Track +
6 Source Track - Track + Search - Source Source Source Track -
7 Track + Band/Disc + Track - Band Track + Track + Track + Audio
8 Track - Preset/Disc - Disc/FM + Send/End Track - Track - Track - Power
9 Power Select Disc/AM - Send Band Band Band
10 Enter/Play Attenuation Answer End N/A Phone Menu
Reject Call/Source
(Bluetooth equipped
radios only)
11 Band/Program Phone Receive Voice Dial Answer Call Answer/End Call
12 Receive Phone Reject On Hook End Call
13 End Voice Dial Off Hook VR
14 VR Power Mute (Multimedia
units only)
15 Preset +
*Other = Advent, Boyo, Dual, Lightning Audio, Rockford Fosgate, & Visteon
Optional Programming Order
Page 3
Programming
1. 7XUQWKHNH\WRWKHLJQLWLRQSRVLWLRQ
2. 3UHVVDQGUHOHDVHSURJUDPPLQJEXWWRQRQWKHVLGHRIWKHLQWHUIDFH
3. :LWKLQVHFRQGVSUHVVWKHEXWWRQWKDWLVWREHOHDUQHGRQWKHVWHHULQJZKHHO7KH/('ZLOOWXUQRIIZKHQWKHEXWWRQLVSUHVVHG
4. ,I\RXQHHGWRSURJUDPPRUHEXWWRQVUHSHDWVWHSIRUHDFKDGGLWLRQDODXGLRIXQFWLRQRQWKHVWHHULQJZKHHO
5. ,I\RXFRPHDFURVVDIXQFWLRQLQWKHFKDUWWKDW\RXUVWHHULQJZKHHOGRHVQRWKDYHRU\RXGRQRWZDQWWRSURJUDPSUHVVDQG
UHOHDVHWKHSURJUDPEXWWRQRQWKHVLGHRIWKHLQWHUIDFHWRVNLSWKDWIXQFWLRQ
6. 2QFHSURJUDPPLQJLVFRPSOHWHGZDLWVHYHQVHFRQGV7KH/('ZLOOÀDVKWKUHHWLPHVLQGLFDWLQJHQGRISURJUDPPLQJ
 7HVWWKHLQWHUIDFHIRUSURSHUIXQFWLRQDOLW\:KHQHYHUD6:&LVSUHVVHGWKH/('RQWKHLQWHUIDFHVKRXOGEOLQN,IDQ\IXQFWLRQ
does not work, repeat the programming steps
,I\RXZLVKWRUHDVVLJQWKH6:&IXQFWLRQVWKHLQWHUIDFHPXVWEHSURJUDPPHGLQWKHVSHFL¿FRUGHUVKRZQRQWKHFKDUWEHORZ,I
\RXFRPHDFURVVDIXQFWLRQLQWKHFKDUWWKDW\RXUVWHHULQJZKHHOGRHVQRWKDYHRU\RXGRQRWZDQWWRSURJUDPSUHVVDQGUHOHDVH
WKHSURJUDPPLQJEXWWRQRQWKHVLGHRIWKHLQWHUIDFHWRVNLSWKDWIXQFWLRQ7KH/('ZLOOÀDVKRIIDQGRQFRQ¿UPLQJWKDW\RXKDYH
VXFFHVVIXOO\VNLSSHGWKDWIXQFWLRQDQGDUHUHDG\WRSURFHHGWRWKHQH[WRQH
7HVWLQJ9HUL¿FDWLRQ
1. 7XUQWKHLJQLWLRQRQ7KH/('RQWKHLQWHUIDFHZLOOWXUQRQWKHYDFFHVVRU\ZLUHZLOOWXUQRQ
2. 7XUQRQWKHUDGLRFKHFNEDODQFHIDGH1RWH3UHPLXP)DFWRU\DPSOL¿HG6\VWHPV will not fade as neither the
DIWHUPDUNHWUDGLRRUWKH53LQWHUIDFHKDYHWKHDELOLW\WRFRQWUROWKHDPSOL¿HU¶VIDGHU
3. 9HULI\WKDWWKHIDFWRU\VXEZRRIHULISUHVHQWLVSOD\LQJ
4. 9HULI\WKDWDOO6:&DUHIXQFWLRQLQJSURSHUO\IRUERWKWKHDIWHUPDUNHWUDGLRDQG2Q6WDU7RDGMXVW2Q6WDUYROXPHSUHVVWKH
2Q6WDUEXWWRQRQWKHPLUURUWKHQXVHWKHYROXPHEXWWRQVRQWKH6:&WRDGMXVWWKHOHYHO7KHYROXPHZLOOUDLVHDWRWDORI
WLPHVEHIRUHUHWXUQLQJWRWKHRULJLQDOOHYHO
5. 3UHVVLQJWKH2Q6WDUEXWWRQRQWKHUHDUYLHZPLUURUZLOOWXUQRIIWKHUHDUVSHDNHUVDQGDOORZWKH2Q6WDUDXGLRWREHKHDUG
LQWKHWZRIURQWVSHDNHUV7KH2Q6WDUDFWLYH/('ZLOODOVRWXUQRQ:KHQ2Q6WDUGLVFRQQHFWVWKHUDGLRZLOOXQPXWHRU
WXUQEDFNRQDQGWKH2Q6WDU/('ZLOOWXUQRII3UHVVLQJWKH0XWH2Q6WDUEXWWRQRQWKHVWHHULQJZKHHOIRUVHFRQGV
will also activate Onstar®.
6. 7XUQRIIYHKLFOHUHPRYHNH\5$3ZLOOEHDFWLYHNHHSWKHUDGLRRQIRUPLQXWHVRUXQWLOWKHGULYHUVGRRULVRSHQHG

RP5-GM11
Radio Replacement & Steering Wheel Control Interface
with OnStar Retention for General Motors Vehicles
3DFL¿F$FFHVVRU\&RUSRUDWLRQ®| Ph. 866-931-8021 | [email protected]
3DFL¿F$FFHVVRU\&RUSRUDWLRQ
www.pac-audio.com
P ifi A C ti
Rev. 022516
7HVWLQJ9HUL¿FDWLRQFRQW
 7KH/('UDGLRZLOOWXUQRIIZKHQ5$3WXUQVRIIRUWKHGULYHUVGRRULVRSHQHG
 8VHWKHSRVLWLRQVHOHFWRUVZLWFKORFDWHGRQWKHVLGHRIWKH&0;PRGXOHWRVHOHFWWKHEHVWFKLPHRXWSXWYROXPHIRU\RXU
VSHFL¿FLQVWDOODWLRQ6HWWLQJEHLQJORXGHVWDQGVRIWHVW
Page 4
5HDU6HDW(QWHUWDLQPHQW56(,IHTXLSSHG
Product Updates (Firmware)
7KHIDFWRU\56(V\VWHPZLOOIXQFWLRQLQGHSHQGHQWO\IURPWKHDIWHUPDUNHWUDGLR7KHXQLWZLOOSRZHUXSDQGSDVVDXGLRWKURXJK
WKHKHDGSKRQHVDVORQJDVWKHYHKLFOHVLJQLWLRQLVRQ,I\RXZLVKWRSDVVDXGLRIURPWKH56(WRWKHDIWHUPDUNHWUDGLR\RXPXVW
FRQQHFWWKH5&$VIURPWKHSLQFRQQHFWRUWRWKHDIWHUPDUNHWUDGLRVDX[LOLDU\LQSXW6HOHFWWKHDIWHUPDUNHWUDGLRVDX[LOLDU\LQSXW
WRKHDU56(DXGLR
7KH53*0FDQEHXSGDWHGZLWKQHZ¿UPZDUHDVLWEHFRPHVDYDLODEOHXVLQJWKH3$&83LQWHUIDFHXSGDWHUVROGVHSDUDWHO\
3OHDVHYLVLWZZZSDFDXGLRFRP¿UPZDUHIRUDYDLODEOHXSGDWHV
2Q6WDU9ROXPH$GMXVWPHQWIRU9HKLFOHVZR6:&
,I6:&EXWWRQVDUHQRWSUHVHQW\RXPXVWXVHWKH
SURJUDPPLQJEXWWRQRQWKHLQWHUIDFHWRFRQWUROWKH2Q6WDU
audio level during an OnStar connection.
:KHQ2Q6WDULVDFWLYHSUHVVLQJWKHSURJUDPPLQJEXWWRQ
ZLOOUDLVHWKHDXGLROHYHOWLPHVEHIRUHUHWXUQLQJWRWKH
RULJLQDOOHYHO(YHU\WLPHWKHEXWWRQLVSUHVVHGDFRQ¿UPDWLRQ
EHHSZLOOEHKHDUG
x3
3UHVVWKHSURJUDPPLQJEXWWRQ
on the side of the interface while
2Q6WDULVDFWLYHWRDGMXVWWKH
OnStar volume
CMX
chime module
1
4
2
3

Installation Steps
RadioPRO5 Accessory Output Drop-out
Technical Bulletin
© 2017 AAMP Global. All rights reserved. PAC is a Power Brand of AAMP Global.
PAC-audio.com
Pacific Accessory Corporation
04-25-17
Email - [email protected] - Toll Free: 866-931-8021
1) Locate the Yellow 12 volt constant power wire
by the vehicle connector on the RP5 harness.
a. Carefully cut the insulation, and expose a small portion of the wire.
We will call this connection point “Point A”
2) Locate the Black ground wire
by the vehicle connector on the RP5 harness.
a. Carefully cut the insulation, and expose a small portion of the wire.
We will call this connection point “Point B”
Connection points (“A” and “B”) at the vehicle connector(s) on the RadioPRO5 harness
Connection points (“C” and “D”) at the input side of the micro relay on the RadioPRO5 harness
Page 1
3) Locate the Yellow 12 volt constant power wire
by the input side of the micro relay on the RP5 harness.
a. Carefully cut the insulation, and expose a small portion of the wire.
We will call this connection point “Point C”
4) Locate the Black ground wire
by the input side of the micro relay on the RP5 harness.
a. Carefully cut the insulation, and expose a small portion of the wire.
We will call this connection point “Point D”
If you find that the data-driven 12 volt accessory output is not functioning correctly when using a high power
head unit at high volume, follow the steps listed below to make a modification to the RadioPRO5 (RP5) harness.
During this modification you will add two new wire leads, providing additional power and ground paths for the
aftermarket radio. These wires will remove the high power demand from the RP5 module, and restore proper
12 volt accessory operation.
NOTE:
We advise making all connection points secure by soldering or using crimp terminals, and insulating appropriately.
Point A
Poin t B
Point C
Point D

Installation Steps
RadioPRO5 Accessory output drop-out
Technical Bulletin
© 2017 AAMP Global. All rights reserved. PAC is a Power Brand of AAMP Global.
PAC-audio.com
Pacific Accessory Corporation
04-25-17
Email - [email protected] - Toll Free: 866-931-8021
Adding additional 15” wires to jump power and ground
Page 2
5) Connect a 15” lead of Yellow wire (any color will work) to Point A.
6) Connect the other end of this wire to the Yellow input wire on the micro relay (Point C)
Ensure your connection points are insulated with either electrical tape, or otherwise.
7) Connect a 15” lead of Black wire (any color will work) to Point B.
8) Connect the other end of this wire to the Black input wire on the micro relay (Point D)
Ensure your connection points are insulated with either electrical tape, or otherwise.
Once the constant power and ground leads are connected and bypass the RadioPRO5 module,
the modification is complete.
At this point the module can be installed into the vehicle.