Pentair ONGA LEISURETIME LTP400 User manual

LEISURETIME®Swimming Pool Pump Owner’s Manual
TABLE OF CONTENTS

LEISURETIME®Swimming Pool Pump Owner’s Manual
FEATURES & BENEFITS

LEISURETIME®Swimming Pool Pump Owner’s Manual
TECHNICAL INFORMATION

LEISURETIME®Swimming Pool Pump Owner’s Manual
TECHNICAL INFORMATION
130
53
121
470
291
283
180
A
130
53
121
470
291
283
180
A
180
120
260
136
A
Pump Model LTP400 LTP550 LTP750 LTP1100
A (mm)
526 535 535 583
LTP400S LTP400S LTP750S
347 356 356

LEISURETIME®Swimming Pool Pump Owner’s Manual
INSTALLATION

LEISURETIME®Swimming Pool Pump Owner’s Manual
INSTALLATION

LEISURETIME®Swimming Pool Pump Owner’s Manual
INSTALLATION

LEISURETIME®Swimming Pool Pump Owner’s Manual
OPERATION

LEISURETIME®Swimming Pool Pump Owner’s Manual
OPERATION

LEISURETIME®Swimming Pool Pump Owner’s Manual
OPERATION

LEISURETIME®Swimming Pool Pump Owner’s Manual
SERVICE & MAINTENANCE
FREQUENCY
Once per week Once per month
CHECK
Inspect trap basket, and empty
of any leaves and other debris.
Leaves and other debris that
collects in basket will choke
off water ow through the
pump and reduce eciency
and performance. See below
instructions on cleaning the trap.
Check the pump to ensure no
water is leaking from inlet and
outlet joints, whilst pump is
operating. If leaks are noticed,
clean and grease the o-rings or
replace if necessary.
Clean area around pump and
ensure there are no leaves or
debris which could become a re
hazard or choke the motor fan.
Check that there are no leaks
from under the pump. If there are,
this could be a sign of a leaking
mechanical seal. Call a Pentair
Service Agent immediately, to
prevent damage to the motor.
Check pump and motor for
insects and pest infestations
and ensure that motor ns are
clean of dust and dirt. Clean if
necessary.

LEISURETIME®Swimming Pool Pump Owner’s Manual
TROUBLESHOOTING
SYMPTOM CAUSE REMEDY
Low water
pressure, low ow
from pump.
Suction leaks / lost
prime.
• Pump must be primed; make sure that the
pump casing and strainer are full of water.
Refer priming instructions.
• Make sure there are no leaks in suction
piping and ensure all o-rings are present
and clean.
• Make sure suctions pipe inlet is well below
the water level to prevent pump from
sucking air.
• Suction lift of 3 to 6 metres will reduce
performance. Suction lift of more than 6
metres will prevent pumping and cause
pump to lose prime. In either instance,
move the pump closer (vertically) to water
source. Ensure that the suction pipe
diameter is large enough.
Clogged pipe /
strainer / impeller /
lter system.
• Ensure trap is not clogged with debris;
clean basket and/or filter.
• Make sure that the impeller is not
clogged. This should be checked by
qualified personnel only.
• Pump may be trying to push too high a
column of water. If so, a higher pressure
pump is required.

LEISURETIME®Swimming Pool Pump Owner’s Manual
TROUBLESHOOTING
SYMPTOM CAUSE REMEDY
No water coming
from pump (pump is
working).
Air ingress to
system.
• Prime the pump. Check that there are no
air leaks in the suction piping or ttings.
Ensure the strainer lid is airtight and
tted securely. Ensure all o-rings are
present.
Pump does not
work.
Motor fault. • Refer to motor fault codes.
No power at outlet. • Use another electrical appliance that is
known to work to check power outlet.
Blown fuse / Circuit
breaker.
• Check and call electrician if necessary.
Water leaking from
between the casing
and motor.
Casing bolts are
not tightened
suciently; worn
mechanical seal
requires replacing.
• Switch off the power to the pump.
Tighten the casing bolts or replace the
mechanical seal as required.

LEISURETIME®Swimming Pool Pump Owner’s Manual
Item Description Part No. Part No. Part No. Part No.
LTP400 LTP550 LTP7 50 LTP1100
1MOTOR 800738 800442 800442 801211
2SHAFT SLEEVE (INCLUDES ITEM 2&3) 800894K 800894K 800894K 800895K
3O-RING SHAFT SLEEVE (10 Pack) 702196K 702218K
4BAFFLE 302060K 302060K 302060K 305300
5ORING-CASING 702206K 702206K 702206K 702206K
6MECHANICAL SEAL (25 Pack) 702789K (800901) 700270K (800900)
SEAL KIT (INCLUDES ITEM 2,3,5 & 6) 800582K 800582K 800582K 800583
7DIFFUSER 302200K 302200K 302190K 303460K
8IMPELLER 504593K 510803K 504823K 506840K
9CASING ASSEMBLY 800410 800410 800410 800410
9A SEPERATOR PLATE 408610 408610 408610 412140
10 LID (INCLUDES O-RING) 800897K 800897K 800897K 800897K
11 ORING-LID (4 Pack) 702208 (702208K)
12 BASKET 302310 302310 302310 302310
13 FINGER GUARD 508210 508210 508210 508210
14 DRAIN PLUG 504605 504605 504605 504605
15 BARREL UNION KIT (2pk) 800714 800714 800714 800714
15c ORING-SWIVEL BARREL UNION 702193 702193 702193 702193
18 BASE & SCREW KIT 800532 800532 800532 800532
NON-RETURN CLACKER 604021K 604021K 604021K 604021K
PUMP FASTENERS KIT 801278 801278 801278 801278
9
15
1
5
4
7
18
8
9a
15c
2
6
11
10
12
14
3
REPLACEMENT PARTS

LEISURETIME®Swimming Pool Pump Owner’s Manual
Item Description Part No. Part No. Part No.
LTP400S LTP550S LTP750S
1MOTOR 800738 800442 800442
2SHAFT SLEEVE & O-RING KIT (INCLUDES ITEM 2 & 3) 800894K 800894K 800894K
3O-RING SHAFT SLEEVE (10 PACK) 702196K 702196K 702196K
4BAFFLE 302060K 302060K 302060K
5ORING-CASING 702206K 702206K 702206K
6MECHANICAL SEAL 702789K 702789K 702789K
SEAL KIT (INCLUDES ITEM 2,3,5 & 6) 800582K 800582K 800582K
MECHANICAL SEAL (25 PACK) 800901 800901 800901
7DIFFUSER 302200K 302070 302190K
8IMPELLER 504593K 510803K 504823K
9CASING & B/UNION ASSEMBLY LTP SOLAR 707426 707426 707426
9CASING ASSEMBLY LTP AGP 512646 512647 512647
10 SCREW 5/16inW x 1.1/2in HWF Hd See Pump Fasteners Kit
11 NUT 5/16inW HEX Steel See Pump Fasteners Kit
PUMP FASTENERS KIT (INCLUDES ITEM 10 & 11)x4 801278 801278 801278
12 CLACKER ASSEMBLY (INCLUDES ITEM 12 & 13) 800904K 800904K 800904K
14 BARREL UNION ASSEMBLY(INCLUDES ITEM 15, 16 & 17)x2 800714 800714 800714
17 ORING -BARREL UNION 702193 702193 702193
18 BASE & SCREWS KIT (INCLUDES 18 & 19x2) 304600K 304600K 304600K
PRIMING CAP (AGP ONLY) 504605 504605 504605
REPLACEMENT PARTS
9

LEISURETIME®Swimming Pool Pump Owner’s Manual
PURCHASED FROM:
PURCHASE DATE:
SERIAL NO:
MODEL NO: