Sealey SDL11 User manual

30W LITHIUM-ION RECHARGEABLE
SOLDERING IRON KIT
MODEL NO: SDL11
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these
instructions, and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY
WARNING! Ensure Health & Safety, local authority, and general workshop practice regulations are adhered to when using this
 equipment,makesureyouknowwherethenearestreextinguisheris.
WARNING!Alwayswearapprovedeye/faceprotectionwhenoperatingthesolderingiron.
WARNING!Donotusethesolderingironifyounoticedamagetotheworkpiece.
WARNING!Alwayspointthesolderingironawayfromtheeyesandbodywhenduringoperation.
WARNING!Donotputthesolderingirondown,putitbackinitsholder.
WARNING!Onlyuseinawellventilatedarea.
9 Keepammablematerialawayfromthetorchwhenoperating.
8DO NOToperatethesolderingironwhenyouaretiredorundertheinuenceofalcohol,drugsorintoxicatingmedication.
8DO NOTusethesolderingironinanareawherepaintfumes,solventsorotherammablesolids,liquidsorgasesposeapotential
 hazard.
8DO NOTholdanyworkpiecebyhand.
8DO NOTtouchtheworkpiececlosetotheheatedareaasitwillbeveryhot.Allowtocool.
8DO NOToperatethesolderingironifitisdamagedasthismaycausefailureand/orpossiblepersonalinjury.
8DO NOTtouchthetopofthesolderingironduringorimmediatelyafteruse,asitwillbeveryhot.Allowtocool.
8DO NOTallowchildrentooperatethesolderingiron.
9 Whennotinuse,storeawayfromdirectsunlightinasafe,dry,childprooflocation.
8DO NOTstoreatover40°C,suchasinacarinhotweather.
2. INTRODUCTION
 Cordlessandlightweightsolderingiron.InbuiltLEDtoilluminatesolderingareainlowlightareassuchasenginebays.Kitincludes
 standard,chiselandheatshrinktipsaswellascleaningsponge,solder,standandUSBcharginglead.Heatsuptoamaximum 
 temperatureof600°Candhasa40minuteworkingtime.
3. SPECIFICATION
Model No.:.................................................................. SDL11
Battery:...................................................... 2.5AhLithium-ion
Charging time:................................................................3.5hr
MaximumTemperature:............................................... 6000C
OperatingTime:........................................................... 40min
Power Rating:.................................................................30W
Consumables:Seeg.1andtablebelow.
SDL11Issue111/06/20
Original Language Version
© Jack Sealey Limited
Refer to
instructions
Warning:
Hot surfaces
Do not cover
Wear eye
protection
Item Description Part number
1SolderingwireforSDL11 SDL11.SW
2 ChargingcordforSDL11 SDL11.CC
3 SolderingstandforSDL11 SDL11.S
430W Chisel tip SDL11.CHT
5Cleaning sponge SDL11.CS
630W Cone tip SDL11.CT
730W Lighter and heat shrink tip SDL11.LHT
8Interchangeabletips(setof3)NOTSHOWN SDL11.T
9TransparentcapforSDL11NOTSHOWN SDL11TC g.1
Indooruse
only

4. OPERATION
4.1. CHANGING SOLDERING TIP
4.1.1. Ensure that the soldering iron tip is cold, select the appropriate tip and remove the current tip by applying a quarter turn to the tip
 collar.Mounttherequiredtipbyliningupthelugs,slidingthecollardownthetoolandapplyingaquarterturn.
4.2. CHARGING
4.2.1. WhenconnectedtoaUSBpowersupplytheLEDinthehandlewillshowredwhilechargingandwillturngreenwhenfullycharged.
4.3. USING THE SOLDERING IRON
4.3.1. SlidetheHeatingandLEDcontrolslider(g.2)forwardtopreparethetoolforsoldering.
4.3.2. DepresstheredbuttonontopoftheslidecontroltoheatthetipandtoturnontheLED.Whiletheredbuttonisdepressedthetip
 willcontinuetoheat.Ifthebuttonisreleasedthepowerise󰀨ectivelyswitchedo󰀨.
4.3.3. WhentheworkisdoneensurethattheHeatingandLEDcontrolsliderisreturnedtotheO󰀨position(g.2)andthatthetipiscold
 beforestoringtheironbackinit’sbox.
5. MAINTENANCE
5.1. Ifsoiled,cleanthetoolusingusingaclean,dampcloth.DO NOTgetthetoolwet.
Original Language Version
© Jack Sealey Limited
Sealey Group, Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR
01284 757500 01284 703534 [e-mail] www.sealey.co.uk
ENVIRONMENT PROTECTION
Recycleunwantedmaterialsinsteadofdisposingofthemaswaste.Alltools,accessoriesandpackagingshouldbesorted,takento
arecyclingcentreanddisposedofinamannerwhichiscompatiblewiththeenvironment.Whentheproductbecomescompletely
unserviceable and requires disposal, drain any fluids (if applicable) into approved containers and dispose of the product and fluids
accordingtolocalregulations.
WEEE REGULATIONS
Dispose of this product at the end of its working life in compliance with the EU Directive on Waste Electrical and Electronic Equipment
(WEEE).Whentheproductisnolongerrequired,itmustbedisposedofinanenvironmentallyprotectiveway.Contactyourlocalsolid
wasteauthorityforrecyclinginformation.
BATTERY REMOVAL
Under the Waste Batteries and Accumulators Regulations 2009, Jack Sealey Ltd are required to inform potential purchasers of products
containingbatteries(asdefinedwithintheseregulations),thattheyareregisteredwithValpak’sregisteredcompliancescheme.Jack
SealeyLtd’sBatteriesProducerRegistrationNumber(BPRN)isBPRN00705.
Note:Itisourpolicytocontinuallyimproveproductsandassuchwereservetherighttoalterdata,specificationsandcomponentpartswithoutprior
notice.
Important:NoLiabilityisacceptedforincorrectuseofthisproduct.
Warranty:Guaranteeis12monthsfrompurchasedate,proofofwhichisrequiredforanyclaim.
Partssupportisavailableforthisproduct.Pleaseemail[e-mail]ortelephone01284757500
SDL11Issue111/06/20
g.2