Volvo 30775790 User manual

Instruction No Version Part. No.

30775801 1.1 30775790, 30775791, 30775792, 30775793

Handsfree for cellular phone, system B, entry level

IMG-249663

Instruction No Version Part. No.

30775801 1.1 30775790, 30775791, 30775792, 30775793

Handsfree for cellular phone, system B, entry level

IMG-249663

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 1 / 47

Equipment

A0000162 IMG-239981 IMG-246925 M0000232

IMG-249651

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 2 / 47

IMG-249652

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 3 / 47

IMG-241704

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 4 / 47

IMG-213320

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 5 / 47

INTRODUCTION

Read through all of the instructions before starting installation.

Notifications and warning texts are for your safety and to

minimise the risk of something breaking during installation.

Ensure that all tools stated in the instructions are available

before starting installation.

Certain steps in the instructions are only presented in the form

of images. Explanatory text is also given for more complicated

steps.

In the event of any problems with the instructions or the

accessory, contact your local Volvo dealer.

Note!

These installation instructions apply to left-hand drive

vehicles. When installing in a right-hand drive vehicle, the

procedure is carried out on the opposite side and/or mirrored.

Where the operation differs, right-hand versions are also

displayed with text and images.

When installing antenna and Velcro tape the underlying

surface must be kept at a temperature of at least +20° C

(68°F).

Wiring A is for vehicles with an internal amplifier that is

located in the media player.

Wiring B and C are for vehicles with an external amplifier. This

is located on the left-hand side of the cargo compartment.

Cars with Performance Sound have internal amplifier.

Cars with the High Performance and Premium Sound audio

systems have external amplifier.

There may be components in the accessories kit that are not

used for this installation.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 6 / 47

1

IMG-237320

Turn the ignition switch to position 0.

Disconnect the negative battery cable.

Note!

Wait at least three minutes before unplugging the connectors

or removing other electrical equipment.

2

IMG-240083

Use a weatherstrip tool to carefully pry loose the panel at the

rear edge of the center console. The panel is held in place by a

catch on each short side.

Move the panel to the side to access the two screws

underneath.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 7 / 47

3

IMG-240084

Remove the screws.

4

J8504532

Open the glovebox.

Use a plastic weatherstrip tool to carefully pry loose the panel

inside the center console. It is held in place by two clips on each

short side.

Pull the panel away downwards.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 8 / 47

5

IMG-239762

Apply tape to the center console to protect it during removal and

installation of the glove compartment.

6

J8504893

Detach the surround around the display and the media player:

Press in the catch at the edge of the media player cover. Use a

small screwdriver. Carefully pry off the surround at the corner.

Use a weatherstrip tool.

Note!

Do not damage the panel and dashboard.

Repeat the operation on the other side.

Hint

If the other side does not detach, press the detached side into

position again and repeat the procedure, beginning from the

other side.

Fold the surround backwards. Remove by pulling upwards.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 9 / 47

7

J8504534

Press out the display module from the reverse of the center

console. Use both hands and press straight back.

Disconnect the two connectors. Put the display to one side.

8

IMG-248566

Applies to cars with manual gearbox

Remove the gear selector lever boot from the center console.

First pry it off at the front edge using a weatherstrip tool and then

unhook it at the rear edge.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 10 / 47

9

IMG-240085

Remove the two screws holding the centre console to the

dashboard.

Remove the connector on the reverse of the dashboard

environment panel.

Remove the center console from the dashboard and tunnel

console.

10

J3905272

Remove the two clips securing the cables to the media player by

first pressing them to the sides and then pulling them away

downwards.

Note!

Be careful with the optic cables so that they are not bent or

stretched.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 11 / 47

11

J3904501

Remove the two screws from the bottom of the media player.

Pull out the media player and detach the connectors on the rear

side.

Note!

Note how the wiring is packed on the reverse. The fibre optic

cables are easily damaged and must not be bent to a radius

less than 25 mm (1").

12

J8505197

Angle up both air vents.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 12 / 47

13

J8505198

Grip the air vent, press it out and pull it upward.

Do the equivalent to the other air vent.

14

IMG-249683

Insert a scriber and push up one of the catches in the lower

edge of the air vents' housing.

Insert the tool part no. 9995919 in the space that is opened and

pull out until the catch releases.

Repeat this until all catches in the lower edge have released.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 13 / 47

15

J8505214

Grip the ends of the housing and pull out until all catches on

both the top and bottom are fully free from the inside of the

dashboard. If necessary, use a weatherstrip tool to prize out the

ends of the housing.

Note!

Do not damage the dashboard.

Pull alternately on the right and left-hand sides, otherwise the

edge of the housing will crack where it enters the air ducts on

the inside. The housing is secured firmly so force will be

required to release it.

16

IMG-240082

Remove the panel on the right-hand and left-hand ends of the

dashboard. Carefully pry off the panel until the three clips

release. Use a weatherstrip tool.

Note!

Do not damage the dashboard.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 14 / 47

17

IMG-244221

Remove the clip holding the nozzle for the air duct on the right-

hand and left-hand sides.

18

J8803318

Remove the rubber mat from the glovebox.

Remove the screws, x 5, in the glovebox opening.

Pull the glovebox straight back in the vehicle in order to release

the hidden clips, x 2, in the top edge.

Remove the outer section of the glovebox.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 15 / 47

19

IMG-222669

Unplug the connectors on the top.

20

IMG-239763

Remove the screw or the air vent on the right side.

Pull off the vent to the right and place to one side.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 16 / 47

21

J8504871

Remove the clips at the rear edge of the soundproofing panel

and remove it.

22

J3801121

Position the steering wheel in its lowest and rearmost position.

Remove the two screws from the surround for the combined

instrument panel.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 17 / 47

23

J8803326

Pull out the surround starting at the bottom edge and then the

top. The surround is held in place with a clip on each side of the

bottom edge.

Place the surround to one side.

24

J3905394

Take the mounting from the kit and place its support legs in the

recess for the combined instrument panel surround and in the

left air vent.

Position the left-hand support leg of the mounting as illustrated.

The front edge of the support leg must be parallel with the edge

in the cutout in the dashboard. The measurement to the bottom

edge of the support leg must be taken from the center of the

radius.

Mark out the holes to be drilled for the mounting.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 18 / 47

25

J3905377

Drill out the holes using a Ø5 mm (13/64") diameter drill bit. Use

a 10 mm (25/64") drill stop to prevent damaging the components

on the inside.

Remove any swarf.

26

J3905378

Take two screws and the support plate from the kit. Use the

screws to secure the mounting's left leg to the dashboard.

Position the support plate on the inside of the leg.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 19 / 47

27

J3905385

Drill out the hole for the right-hand support leg with a Ø4 mm

(5/32") diameter bit.

Take a screw from the kit and secure the right-hand support leg.

28

J3905379

Take a mounting plate and the antenna cable connector from the

kit.

Press in the antenna cable connector onto the rear of the

mounting plate.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 20 / 47

Volvo 30775790 User manual

Popular Automobile Accessories manuals by other brands