Wenger 029A105 User manual

wner’s Manual
3#)'/7'2
/3' Please read and understand these instructions before using the Stage Boxes.
/3' Refer to the illustrations on the following pages. If you need additional information,
contact the Wenger Corporation using the information below.
/3' Save these instructions.
©Wenger Corporation 2012 Printed in USA 03/12 Part #029A150-02
!'.)'1/10/1#3+/. 555 Park Drive, P. . Box 448, watonna, Minnesota 55060-0448
Questions? Call.....USA: 800-4WENGER (493-6437) • Worldwide: 1-507-455-4100 • www.wengercorp.com
-#,,3#)'/7
:67:&7:*
%-7%-7%-
'&+4-3#)'/7
:67:&7:*
%-7%-7%-
#1)'3#)'/7
:67:&7:*
%-7%-7%-
contents
Important User Information . . . . . . . . . . . . . . . . . . . . . . . . . . .2
General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Manufacturer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Intended Use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Stage Box Load Limits . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Stage Box Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Stacking Stage Boxes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Stacking Methods . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Typical Arrangements . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Easy Chair or Throne . . . . . . . . . . . . . . . . . . . . . . . . . .6
Stairway . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Countertop or Bookcase . . . . . . . . . . . . . . . . . . . . . . .7
Sofa or Couch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
Replacement Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8

2
impoRtant UseR infoRmation

Copyright © 2012 by Wenger Corporation
All rights reserved. No part of the contents of this manual may be reproduced, copied, or transmitted in
any form or by any means including graphic, electronic, or mechanical methods or photocopying,
recording, or information storage and retrieval systems without the written permission of the publisher,
unless it is for the purchaser's personal use.
Printed and bound in the United States of America.
The information in this manual is subject to change without notice and does not represent a commitment
on the part of Wenger Corporation. Wenger Corporation does not assume any responsibility for any
errors that may appear in this manual.
In no event will Wenger Corporation be liable for technical or editorial omissions made herein, nor for
direct, indirect, special, incidental, or consequential damages resulting from the use or defect of this
manual.
The information in this document is not intended to cover all possible conditions and situations that might
occur. The end user must exercise caution and common sense when assembling or installing Wenger
Corporation products. If any questions or problems arise, call Wenger Corporation at 1-800-733-0393.
  
The Stage Boxes are manufactured by:
Wenger Corporation
555 Park Drive
watonna, MN 55060
1-800-4WENGER (493-6437) • 1-507-455-4100
www.wengercorp.com
 
•This product is intended for indoor use in normal ambient temperature and humidity conditions —
it must not be exposed to prolonged outside weather conditions.
•This product is intended to simulate basic furniture items in rehearsal and performance situations
and are not intended to provide structural support for heavy equipment or materials.
!"
This product is guaranteed free of defects in materials and workmanship for five full years from date
of shipment. A full warranty statement is available upon request.

3
safety pRecaUtions
Throughout this manual you may find cautions and warnings which are defined as follows.
9 ! means that failure to follow the instruction may result in serious injury or death.
9   means that failure to follow the instruction may result in serious injury or damage to
property.
Read all of the safety instructions before using the Stage Boxes.
Sta e Boxes must always be
supported at the bottom on
a full side.
!caUtion
Never use the Sta e Box
Fasteners to support loadin .
Fasteners are intended only
to hold Sta e Boxes in place.
!caUtion
Never use or store a Sta e
Box near an open flame or
heat source.
!caUtion
Never alter, modify, or use
a Sta e Box in a way that
does not comply with these
instructions.
!caUtion
Make sure that anyone
workin with the Sta e Boxes
has read and understands
these instructions.
!caUtion
Failure to comply with
Warnin s and Cautions in
this document can result in
dama e to property or
serious injury.
!caUtion
Never stand on Sta e Boxes
that are stacked two or more
hi h.
!caUtion
stage Box load limits
The Stage Box is designed to support a maximum load of 125 pounds per square foot
(610 kg per square meter).
Do not support more than
125 pounds per square foot
(610 k per square meter) on
each Sta e Box.
!caUtion

4
stage Box descRiption
Foot
Pockets
Rubber
Foot
Fastener
Molded-in
Insert
Fastener
Molded-in
Insert
Stage Box
Top Surface
Stage Box
Bottom Surface
Fastener
Molded-in
Insert
1/222'%3+/.5+'6/(#23'.'1#.&/,&'&+..2'13
#33#%*+.)36/3#)'/7'23/)'3*'1
Attach two adjacent Sta e Boxes
to ether by ali nin the Fastener to the
Molded-in Insert, pushin the Fastener
inward, and turnin the it clockwise.
80+%#,3#)'/7

 
1. When stacking Stage Boxes, always do one of the following:
a. If stacking side to side or side to top surface, use the Fasteners to hold the Stage Boxes
in place.
b. If stacking the top surface to the bottom surface, insert the upper Stage Box Rubber Feet
(on the bottom surface) into the Foot Pockets on the top surface of lower Stage Box
as shown below.
2. When stacking Stage Boxes, the bottom side of each Stage Box must be supported over the
box’s entire bottom surface area.
Never create a brid e by attachin the Fasteners and not supportin the Sta e Box from
the bottom. The Fasteners will not support loadin .
5
Foot
Pockets
Rubber
Foot
Rubber
Foot
Always insert the Rubber Feet on the upper
Sta e Box into the Foot Pockets on the lower
Sta e Box when stackin Sta e Boxes bottom
surface to top surface.
Stage
Box
Stage
Box
The entire bottom surface
must be supported when
stackin Sta e Boxes.
Never create a brid e by attachin the
Fasteners and not supportin the Sta e Box
from the bottom.
These two Sta e Boxes are
attached by the Fasteners
Small
Stage Box
Large
Stage Box
Fastener
Molded-in
Insert
When stackin a Sta e Box side surface to another
Sta e Box, attach the two to ether with the Fasteners.
#
$
stacking stage Boxes
Never stand on Sta e Boxes
that are stacked two or more
hi h.
!caUtion
Sta e Boxes must always be
supported at the bottom on
a full side.
!caUtion
Never use the Sta e Box
Fasteners to support loadin .
Fasteners are intended only
to hold Sta e Boxes in place.
!caUtion

6
Small
Stage Boxes
(two)
Large
Stage Box
Attach the Sta e Boxes
to ether with the Fasteners
Medium
Stage Boxes
(two)
Attach the Sta e Boxes to ether
with the Fasteners
Top
Surfaces
" 
Easy Chair or Throne:
1. Place a Large Stage Box with the Rubber Feet resting upon the floor.
2. Place two Small Stage Boxes on one side of the large Stage Box with the small Stage Box top
surfaces facing inward.
3. Attach the small Stage Boxes to each other and to the large Stage Box by engaging the Fasteners.
Stairway:
1. Attach two Medium Stage Boxes together with the Fasteners.
2. Attach two Small Stage Boxes to the two Medium Stage Boxes with the Fasteners.
stacking stage Boxes (continUed)
Never stand on Sta e Boxes
that are stacked two or more
hi h.
!caUtion
Small
Stage Boxes
(two)

7
Medium
Stage Boxes
(three)
Attach all Sta e Boxes to ether
with the Fasteners
Attach the Sta e Boxes
to ether with the Fasteners
Small
Stage Boxes
(six)
Small
Stage Box
Large
Stage Boxes
(three)
"   
Countertop or Bookcase:
1. Place three Medium Stage Boxes with the 12-inch side of each onto the floor.
2. Attach the three Boxes together with the Fasteners.
3. Place three Medium Stage Boxes with the 12-inch side of each onto the three Boxes placed
on the floor in step 1.
4. Attach the three upper Boxes together with the Fasteners.
5. Attach the three upper Boxes to the three lower Boxes with the Fasteners.
Sofa or Couch:
1. Place three Large Stage Boxes with the Rubber Feet resting on the floor and attach them
together with the Fasteners.
2. Place six Small Stage Boxes with the 8-inch side resting on one side of the large Stage Boxes
and the small Stage Box top surfaces facing inward.
3. Attach the Small Stage Boxes to each other and to the Large Stage Box with the Fasteners.
4. Place a Small Stage Box on each end of the assembly engaging the Rubber Feet and
Foot Pockets as shown below.
stacking stage Boxes (continUed)
Never stand on Sta e Boxes
that are stacked two or more
hi h.
!caUtion
Medium
Stage Boxes
(three)

Stage Boxes can be stored by nesting the Boxes as follows:
1. Insert a Small Stage Box into a Medium Stage Box.
2. Insert the nested Small Stage Box and Medium Stage Box into a Large Stage Box.
8
Small
Stage Box
Large
Stage Box
Medium
Stage Box
4
2
3
1
stoRage
1. Clean the Stage Box surfaces with a mild detergent such as Formula 409 or Fantastic and
a clean cotton cloth.
2. Use a soft bristle brush on textured surfaces.
3. Never use harsh detergents or abrasive products on Stage Box surfaces.
4. Replace damaged Rubber Feet or Fasteners immediately.
maintenance
3'- '2%1+03+/.
1 Fastener Assembly Screw
2 Fastener Assembly Spring
3 Fastener Assembly Washer
4 Rubber Foot
Replacement paRts